CME1356R and CME1656R
Introduction
This product manual contains the information needed for the setup, installation, initial start up, sanitation and maintenance of this ice machine. Keep it for future reference.
There are 2 models covered in this manual:
•CME1356R, (5 evaporators)
•CME1656R, (6 evaporators)
Be certain that the information applies to the model in question. If no model is listed, the information applies to all models.
This manual is organized in the same way as the expected use of the machine, it begins with specifications, goes thru unpacking and setup, shows where everything is; continues with initial start up, then describes how it works. After that is the sanitation section, followed by service diagnosis and repair.
TABLE OF CONTENTS
Specifications | . . PAGE 2 |
Condenser and Ice Machine Layouts . . . | . . PAGE 3 |
. . PAGE 4 | |
Location & Assembly | . . PAGE 5 |
Bin Control: Installation | . . PAGE 6 |
Bin Control | . . PAGE 7 |
Stacking | . . PAGE 8 |
For The Installer: Remote Condenser . . . | . . PAGE 10 |
Remote Condenser Location | . . PAGE 11 |
Coupling Instructions | . . PAGE 12 |
Head Pressure Control | . . PAGE 13 |
Electrical | . . PAGE 14 |
Plumbing | . . PAGE 15 |
After Utility Connections | . . PAGE 16 |
Component Location and Function . . . . | . . PAGE 17 |
AutoIQ Controller | . . PAGE 18 |
Initial Start Up | . . PAGE 19 |
Adjustments | . . PAGE 20 |
How To Operate The AutoIQ Controller . . | . . PAGE 21 |
How The Electronic Cuber Works | . . PAGE 22 |
Technicians Only: Freeze Cycle Sequence | . . PAGE 24 |
Technicians Only: Harvest Cycle Sequence & Other Notes . . . . . . . . . . . . . . . . . . . . . PAGE 25
Sanitation and Cleaning | PAGE 26 |
Additional Maintenance | PAGE 27 |
Additional Maintenance: Water Distributors . | PAGE 28 |
Additional Maintenance: Inlet Water Valve |
|
Screen | PAGE 29 |
Additional Maintenance: Ice Sensors, |
|
Condenser | PAGE 30 |
Service Diagnosis: Diagnostic Light Analysis | PAGE 31 |
Service Diagnosis | PAGE 32 |
Service Diagnosis: Components | PAGE 33 |
Service Diagnosis | PAGE 34 |
PTCR | PAGE 35 |
Operational Characteristics: CME1356R . . . | PAGE 36 |
Operational Characteristics: CME1656R . . . | PAGE 37 |
Removal and Replacement | PAGE 38 |
Removal and Replacement | PAGE 39 |
Removal and Replacement: AutoIQ Controller |
|
. . . . . . . . . . . . . . . . . . . . . . . . | PAGE 40 |
Removal and Replacement: Water Level Sensor | |
. . . . . . . . . . . . . . . . . . . . . . . . | PAGE 41 |
Removal and Replacement | PAGE 42 |
Refrigerant | PAGE 43 |
Before Calling for Service | PAGE 45 |
Parts Lists and Wiring Diagrams are in the section at the center of this manual.
May 2000
Page 1