Multiquip DCA180SSJU operation manual Connecting Loads, Over Current Relay

Page 42

OUTPUT TERMINAL PANEL FAMILIARIZATION

Connecting Loads

Loads can be connected to the generator by the

or the convienience receptacles (Figure 14). Make sure to read the operation manual before attempting to connect a load to the generator.

To protect the output terminals from overload, a

3-pole, 500A circuit breaker is provided. Make sure to switch ALL circuit breakers to the OFF position prior to starting the engine.

Over Current Relay
An	(Figure 15) is connected to the main

circuit breaker. In the event of an overload, both the circuit breaker and the over current relay may trip. If the circuit

breaker can not be reset, the on the over cur- rent relay must be pressed. The over current relay is located in the control box.

Figure 15. Over Current Relay

Figure 14. Connecting Loads

PAGE 42 — DCA-180SSJU — OPERATION AND PARTS MANUAL — REV. #3 (02/01/10)

Image 42

Contents Parts List NO. M3870301004 Model DCA180SSJU 60HZ GeneratorProposition 65 Warning Reporting Safety Defects NhtsaMQ Power DCA-180SSJU Whisperwatttm Generator Table of ContentsParts Ordering Procedures Ordering parts has never been easierSpecifications Generator SpecificationsDimensions TOP, Side and Front DimensionsSafety Message Alert Symbols Conjunction with SafetyPotential hazards associated with the operation of this Always wear approved protection ProtectionThis generator, other property Rules for Safe Operation General SafetyResult causing severe Drugs or alcoholElectrical Safety Generator GroundingUse the following guidelines when handling the battery Maintenance SafetyBattery Safety Avoid eye irritationTowing & Transporting Safety DOTEmergencies Generator Decals Generator DecalsGenerator Decals Cont inued Installation Typical Generator Grounding ApplicationWhen connecting the generator Outdoor InstallationIndoor Installation MountingGeneral Information Major Components Generator Major ComponentsDiagnostic Display Menu Button Press this button to enter or exit menu screensDisplay Parameters Next item down Engine. Note Displays only when SAE J1939First Time Start Up Main Menu NavigationEngine Configuration Data Diagnostic CodeStored Fault Codes To make a selectionDiagnostic Display 24 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 Auxiliary Gage Fault Active Fault Codes Backlight Adjustment Shut Down CodesDamage Contrast Adjustment IntensityContrast is highlighted Setup 1- Up Display Select UnitsOnce the Setup 1-up Display menu icon has been Up display functionAutomatic Scan on Setup 4-Up Display Select the 4-Up Custom Setup from the 4-Up Setup menuTouch the Enter Button and a list of parameters will appear Engine OIL Temperature Utilities34 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 Touch the Menu button again to return to the Main MenuTouch the Menu Button Highlight it, then touch Enter No parameter selected for this 4- UP quadrant Glossary Troubleshooting informationECU did not respond to the PowerView request Press and hold the Menu button for approximately 3 secondsButton on the overcurrent relay and place To restore power toGenerator Control Panel Circuit breaker Position onEngine Operating Panel Fuel Gauge Indicates amount of diesel fuel availableEngine by initializing FaultAuto On/Off Engine Controller Mpec Unit. This is considered aOutput Terminal Panel Familiarization Are consideredOutput Terminal Familiarization Pressing Removing the Plastic Face Plate Hard Wire Hookup PanelVAC Gfci Receptacles Counter-clockwise will VoltageConnecting Loads Over Current RelaySystem, amust install an Single Phase LoadThree Phase Load Load ApplicationVoltage Change-Over Board Generator OutputsGenerator Output Voltages Maximum AmpsShow a reading when Generator OUTPUTS/ Gauge ReadingAC Ammeter Gauge Reading Are3Ø-240V Uvwo Terminal Output Voltages Output Terminal Panel ConnectionsUvwo Terminal Output Voltages 1Ø-240V Uvwo Terminal Output Voltages3Ø-480 Uvwo Output Terminal Voltages Uwvo Output Terminal Lugs 1Ø-277V ConnectionsLubrication Oil SetupCircuit Breakers Fuel CheckRefueling Procedure ONLY! useRefueling Coolant Antifreeze Cleaning the RadiatorAir Cleaner Fan Belt Tension Operation Freezing WeatherWiring BatteryBattery Cable Installation AlternatorGenerator START-UP Procedure Manual Before StartingStarting Manual OFF/RESET position Speed switchOn position Figure Starting Auto ModeWhen the generator is set Auto mode, the generator will Ammeter willGenerator START-UP Procedure Auto Mode Generator SHUT-DOWN Procedures Normal Shutdown ProcedureOFF/RESET position Emergency Shutdown Procedure Maintenance Engine Check Oil Level Cleaning the Fuel StrainerAir Removal Replacing Oil FilterMaintenance HEATER/CHARGER Commercial power to theandTo ensure adequate starting Maintenance Trailer Trailer MaintenanceHydraulic Surge Brakes Brake AdjustmentBrakes ActuatorTires/Wheels/Lug Nuts Tire Wear/InflationSuspension Lug Nut Torque Requirements Use an pneumatic airTrailer Wiring Diagram Trailer/Towing Vehicle Wiring DiagramGenerator Wiring Diagram Generator Wiring DiagramDCA-180SSJU Engine Wiring Diagram Engine Wiring DiagramTroubleshooting Generator Generator TroubleshootingTroubleshooting Engine Controller Engine Controller Troubleshooting MpecDCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 Sample Parts List Explanation of Code in Remarks ColumnPart number on this Suggested Spare Parts list Suggested Spare PartsGenerator Assy 0601823282 C01100006020601842334 0018205020Control Panel Assy 022100100 M4223000303M4223000404 022100165Control BOX Assy 0027106018 M32130013020601809666 060187042378 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 29A 0030006000 M42605000030602202592 0027106016Engine and Radiator Assy Part Name QTY Remarks Engine and Radiator ASSY. Part Name Output Terminal Assy Output Terminal AssyM9220101004 M3230700113M9220100914 003932000086 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 0019206020 M426060010425-1 022100150 0601812538Battery Assy M9103000504 0602220196M9310500404 0602220921Muffler Assy M4333000303 M43301005020016910025 0602325066Fuel Tank Assy 0605501069 M43630001020605505070 0605516090Enclosure Assy Enclosure Assy0019208020 M4413000302M1413400004 M4423000312Enclosure ASSY. Enclosure ASSY.M9113000002 003790600028A 0041206000 002180601698 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 M4453001303 M445300120351A M4493403804 52A M4493403904Rubber Seals Assy 0228901200 02292012400228900945 0228901260Nameplate and Decals Assy M9520100603 M4550000303M9520100304 M3550002702Terms and Conditions of Sale Parts Freight PolicyDCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 HERE’S HOW to GET Help