Multiquip DCA180SSJU M3213001302, 0601809666, 0027106018, 0601870423, 0021006045, 0207006000

Page 77

CONTROL BOX ASSY.

CONTROL BOX ASSY.
NO.	PART NO.	PART NAME	QTY.	REMARKS
1	M3213001302	CONTROL BOX	1
2	0601809666	CURRENT TRANSFORMER, 300/5A	3
3	0027106018	MACHINE SCREW	6
4	0601870423	CIRCUIT BREAKER, 500A	1
4A	0021006045	MAVHINE SCREW	4
4B	0207006000	HEX. NUT	4
5	0601815168	REAR CONNECTOR KIT	1
6	M3273000003	TERMINAL BOARD, VOLTAGE CHANGE-OVER	1
7	M3276400004	CHANGE TERMINAL	10
8	0017106025	HEX. HEAD BOLT	20
9	M4276200004	TERMINAL PLATE	3
10	M3276300004	CHANGE-OVER PALTE	6
11	M4276100004	TIE BOLT	20
12	0040001000	LOCK WASHER	20
13	0041410000	WASHER, FLAT	20
14	0017110040	HEX. HEAD BOLT	3
14A	0207010000	HEX. NUT	4
15	0016908030	HEX. HEAD BOLT	4
16	0601820625	AUTOMATIC VOLTAGE REGULATOR, 5A	1
17	0027105016	MACHINE SCREW	4
18	0601820847	OVER CURRENT RELAY	1
19	0601820848	OVER CURRENT RELAY, 25A	1
20	0027104016	MACHINE SCREW	2
20A	0207004000	HEX. NUT	2
21	M4260600304	BRACKET, DIAGNOSTIC GAUGE	1
22	0016908020	HEX. HEAD BOLT	2
23	0602120690	POWER VIEW	1
24	0601831330	DIAGNOSTIC SWITCH	1
25	0601813977	RECEPTACLE	1
25A	0601812891	DUST CAP	1
25B	0601812890	STRAIN RELIEF	1
26	0027103015	MACHINE SCREW	2
26A	0030003000	HEX. NUT	2
26B	0041203000	DRAIN WASHER	2

DCA-180SSJU — OPERATION AND PARTS MANUAL — REV. #3 (02/01/10) — PAGE 77

Image 77

Contents Model DCA180SSJU 60HZ Generator Parts List NO. M3870301004Proposition 65 Warning Nhtsa Reporting Safety DefectsTable of Contents MQ Power DCA-180SSJU Whisperwatttm GeneratorOrdering parts has never been easier Parts Ordering ProceduresGenerator Specifications SpecificationsDimensions Dimensions TOP, Side and FrontPotential hazards associated with the operation of this Safety Message Alert SymbolsConjunction with Safety This generator, other property Always wear approved protectionProtection Result causing severe General SafetyRules for Safe Operation Drugs or alcoholGenerator Grounding Electrical SafetyBattery Safety Maintenance SafetyUse the following guidelines when handling the battery Avoid eye irritationEmergencies Towing & Transporting SafetyDOT Generator Decals Generator DecalsGenerator Decals Cont inued Typical Generator Grounding Application InstallationIndoor Installation Outdoor InstallationWhen connecting the generator MountingGeneral Information Generator Major Components Major ComponentsDisplay Parameters Diagnostic DisplayMenu Button Press this button to enter or exit menu screens First Time Start Up Engine. Note Displays only when SAE J1939Next item down Main Menu NavigationStored Fault Codes Diagnostic CodeEngine Configuration Data To make a selectionDiagnostic Display 24 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 Auxiliary Gage Fault Active Fault Codes Damage Backlight AdjustmentShut Down Codes Contrast is highlighted Contrast AdjustmentIntensity Select Units Setup 1- Up DisplayUp display function Once the Setup 1-up Display menu icon has beenAutomatic Scan on Touch the Enter Button and a list of parameters will appear Setup 4-Up DisplaySelect the 4-Up Custom Setup from the 4-Up Setup menu Utilities Engine OIL Temperature34 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 Touch the Menu Button Highlight it, then touch Enter Touch the Menu button again to return to the MainMenu ECU did not respond to the PowerView request Glossary Troubleshooting informationNo parameter selected for this 4- UP quadrant Press and hold the Menu button for approximately 3 secondsGenerator Control Panel To restore power toButton on the overcurrent relay and place Circuit breaker Position onFuel Gauge Indicates amount of diesel fuel available Engine Operating PanelAuto On/Off Engine Controller Mpec FaultEngine by initializing Unit. This is considered aOutput Terminal Familiarization Output Terminal Panel FamiliarizationAre considered VAC Gfci Receptacles Removing the Plastic Face Plate Hard Wire Hookup PanelPressing Counter-clockwise will VoltageOver Current Relay Connecting LoadsThree Phase Load Single Phase LoadSystem, amust install an Load ApplicationGenerator Output Voltages Generator OutputsVoltage Change-Over Board Maximum AmpsAC Ammeter Gauge Reading Generator OUTPUTS/ Gauge ReadingShow a reading when AreUvwo Terminal Output Voltages Output Terminal Panel Connections3Ø-240V Uvwo Terminal Output Voltages 1Ø-240V Uvwo Terminal Output VoltagesUwvo Output Terminal Lugs 1Ø-277V Connections 3Ø-480 Uvwo Output Terminal VoltagesCircuit Breakers SetupLubrication Oil Fuel CheckRefueling Refueling ProcedureONLY! use Air Cleaner Fan Belt Tension Cleaning the RadiatorCoolant Antifreeze Operation Freezing WeatherBattery Cable Installation BatteryWiring AlternatorStarting Manual Generator START-UP Procedure ManualBefore Starting Speed switch OFF/RESET positionWhen the generator is set Auto mode, the generator will Starting Auto ModeOn position Figure Ammeter willGenerator START-UP Procedure Auto Mode OFF/RESET position Emergency Shutdown Procedure Generator SHUT-DOWN ProceduresNormal Shutdown Procedure Maintenance Engine Air Removal Cleaning the Fuel StrainerCheck Oil Level Replacing Oil FilterTo ensure adequate starting Maintenance HEATER/CHARGERCommercial power to theand Trailer Maintenance Maintenance TrailerBrakes Brake AdjustmentHydraulic Surge Brakes ActuatorSuspension Tires/Wheels/Lug NutsTire Wear/Inflation Use an pneumatic air Lug Nut Torque RequirementsTrailer/Towing Vehicle Wiring Diagram Trailer Wiring DiagramGenerator Wiring Diagram Generator Wiring DiagramEngine Wiring Diagram DCA-180SSJU Engine Wiring DiagramGenerator Troubleshooting Troubleshooting GeneratorEngine Controller Troubleshooting Mpec Troubleshooting Engine ControllerDCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 Explanation of Code in Remarks Column Sample Parts ListSuggested Spare Parts Part number on this Suggested Spare Parts listGenerator Assy 0601842334 C01100006020601823282 0018205020Control Panel Assy M4223000404 M4223000303022100100 022100165Control BOX Assy 0601809666 M32130013020027106018 060187042378 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 0602202592 M426050000329A 0030006000 0027106016Engine and Radiator Assy Part Name QTY Remarks Engine and Radiator ASSY. Part Name Output Terminal Assy Output Terminal AssyM9220100914 M3230700113M9220101004 003932000086 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 25-1 022100150 M42606001040019206020 0601812538Battery Assy M9310500404 0602220196M9103000504 0602220921Muffler Assy 0016910025 M4330100502M4333000303 0602325066Fuel Tank Assy 0605505070 M43630001020605501069 0605516090Enclosure Assy Enclosure AssyM1413400004 M44130003020019208020 M4423000312Enclosure ASSY. Enclosure ASSY.28A 0041206000 0037906000M9113000002 002180601698 DCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 51A M4493403804 M4453001203M4453001303 52A M4493403904Rubber Seals Assy 0228900945 02292012400228901200 0228901260Nameplate and Decals Assy M9520100304 M4550000303M9520100603 M3550002702Freight Policy Terms and Conditions of Sale PartsDCA-180SSJU Operation and Parts Manual REV. #3 02/01/10 HERE’S HOW to GET Help