ASSEMBLY
Align the holes on the frame support with the holes on the generator frame.
Slide a washer on the bolt, then insert the bolt through the hole in the generator frame so it extends down through the frame support.
Install flange nut and tighten securely.
Repeat on other side.
installing the wheels
See Figure 5.
Wheels are provided to assist in moving the generator to the desired location and should be installed on the side opposite the handle.
Locate the following items:
2 bolts | 2 wheels |
4 washers (3/8 in.) | 2 lock nuts |
2 spacers (.38 ID) |
|
Place a washer on end of bolt.
Install nut on bolt and tighten securely.
Repeat the process on the other side to install second wheel.
securing the handle
See Figures 6 - 7.
Locate the following items:
Handle lock pins Lanyards
Attach the lanyard to the handle lock pin and the handle as shown in figure 6.
Insert the pin through the hole in the handle and the generator frame to secure handle in place.
Repeat on other side.
Raise the end of the generator opposite the handle high enough to gain access to the frame bottom; securely position props underneath to support.
Insert a wheel spacer into the center of the wheel.
Place a washer on the bolt, then slide bolt through the wheel.
Slide the bolt through the
generator .
warning:
Do not attempt to lift the unit by the handle assembly. If it is necessary to lift the generator, always grasp by the frame. Use proper lifting techniques to avoid back injury.
operation
DANGER:
Carbon Monoxide. Using a generator indoors CAN KILL YOU IN MINUTES.
Generator exhaust contains high levels of carbon mon- oxide (CO), a poisonous gas you cannot see or smell. If you can smell the generator exhaust, you are breathing CO. But even if you cannot smell the exhaust, you could be breathing CO.
Never use a generator inside homes, garages, crawl- spaces, or other partly enclosed areas. Deadly levels of carbon monoxide can build up in these areas. Us- ing a fan or opening windows and doors does NOT supply enough fresh air.
ONLY use a generator outdoors and far away from open windows, doors, and vents. These openings can pull in generator exhaust.
Even when you use a generator correctly, CO may leak into the home. ALWAYS use a
If you start to feel sick, dizzy, or weak after the generator has been running, move to fresh air RIGHT AWAY. See a doctor. You could have carbon monoxide poisoning.
danger:
Failure to properly ground generator can result in elec- trocution, especially if the generator is equipped with a wheel kit. National Electric Code requires generator to be properly grounded to an approved earth ground. Call an electrician for local grounding requirements.
WARNING:
Do not allow familiarity with this product to make you careless. Remember that a careless fraction of a second is sufficient to inflict serious injury.
WARNING:
Do not use any attachments or accessories not recommended by the manufacturer of this product. The use of attachments or accessories not recommended can result in serious personal injury.