BIELA14 Series LOV Data Network Flowchart | Frymaster specs

Image 48

Frymaster manual BIELA14 Series LOV Data Network Flowchart

Contents

SERVICE AND PARTS MANUAL FRYMASTER BIELA14 SERIES GEN LOV ELECTRIC FRYERemail: service@frymaster.com 8196446 NOTICE NOTICENOTICE DANGER Do not use water jets to clean this equipment DANGERDANGERi DANGER A.WARRANTY PROVISIONS - FRYERS B.WARRANTY PROVISIONS - FRYPOTSD.WARRANTY EXCLUSIONS C.PARTS RETURN ELECTRICAL POWER SPECIFICATIONS TABLE OF CONTENTS BIELA14 SERIES GEN II LOV ELECTRIC FRYERSCHAPTER 1: Service Procedures TABLE OF CONTENTS cont CHAPTER 2: Parts ListBIELA14 SERIES GEN II LOV ELECTRIC FRYERS CHAPTER 1: SERVICE PROCEDURES BIELA14 SERIES GEN II LOV ELECTRIC FRYERS1.1 General 1.2 Replacing a Computer 3.Remove the two screws from the upper corners of the computer and allow the computer to swing down 1.4 Replacing a High-LimitThermostat DANGER1.5 Replacing a Temperature Probe 4.Locate the red or yellow and white wires of the temperature probe to be replaced. Note where the leads are connected prior to removing them from the connector. Unplug the 12-pinconnector C-6and using a pin-pusherpush the pins of the temperature probe out of the connector 1.6Replacing a Heating Element Full vat element wire routing Dual vat element wire routingElement grounding and wire routing 1.7Replacing Contactor Box Components 1.8 Replacing a Frypot DANGER 17.Disconnect the oil return flexlines malfunction DANGER 1.9.3 Replacing the Transformer or Filter Relay 1.10 ATO Automatic Top-offService Procedures 1.10.1 ATO Automatic Top-offTroubleshootingProblem Probable Causes Problem SERVICEProbable Causes Corrective Action Wire 1.10.4 Replacing the ATO Pump Reset SwitchDrain Switch Switch Buttons and LED’s The following buttons are inoperable in auto modeConstant Illumination: Drain open No Illumination: Drain closed 1.11.2 MIB Manual Interface Board Troubleshooting ProblemProbable Causes Corrective Action Problem Probable CausesCorrective Action 1-19 Connector Resetting DISPLAYEXPLANATION Drain 1.11.7 Control Power Reset Switch 1.11.6 Replacing the MIB Board 1.12RTI Service Issues 1.12.1 RTI MIB Tests TroubleshootingWaste full signal AC voltage measurements 1.12.2 RTI LOV Wiring 1.12.4 RTI LOV TEST QUICK REFERENCE DISPOSE TO WASTE, REFILL VAT FROM BULKDISPOSE TO WASTE FILL VAT FROM BULK FILL JUG FROM BULK Problem 1.13.1 AIF TroubleshootingCorrective Action Probable Causes Wire 1.13.4 Replacing a Linear Actuator 1.13.5 Replacing a Rotary Actuator ProblemRECOVERY FAULT Probable Causes ProblemMISCONFIGURED Corrective Action Problem Probable CausesCorrective Action PASSWORDS 1.14.2 M3000 Useful CodesProblem •0469 – Reset FILTER STAT DATA 1.14.3 Service Required Errors ERROR MESSAGEEXPLANATION 1-34 1.14.4 Error Log Codes ERROR MESSAGEEXPLANATION 1-35 1.14.5 Tech Mode 1.14.6 M3000 Filter Error Flowchart NORMAL ERRORSYSTEM ERROR FIXED? YES OPERATION RESUMES 1.14.7 M3000 Menu Summary Tree Adding New Menu ItemsStoring Menu Items in Product Buttons Draining, Refilling, and Disposing of Oil 1.14.8 M3000 Board Pin Positions and Harnesses 1.15Loading and Updating Software Procedures SETUP COMPLETE is displayedUNTIL THE DISPLAY PROMPTS TO DO SO IN STEP 24.FILTER NOW YES/NO is displayed 1.16 BIELA14 Series LOV Data Network Flowchart 1.17 Interface Board Diagnostic Chart Diagnostic LED LegendPN 826-2260 1-42 1.18 Probe Resistance Chart Probe Resistance ChartOHMS OHMS 1.19 Wiring Diagrams 1.19.1 Component Wiring Domestic 1.19.2 Component Wiring CE 1.19.3 Component Wiring CSA 1.19.4 Component Wiring Australia 1.19.5 Contactor Box – Delta Configuration 1.19.6 Contactor Box - WYE Configuration Page Page Page Page Page CHAPTER 2 PARTS LIST AccessoriesITEM PART # ITEM PART #COMPONENT Not illustrated 2.3Drain System Components 2.3.1 Drain Tube Sections and Associated PartsPART# ITEM 2.3.2.2 Rotary Actuator Drain Valves ITEMPART # COMPONENTPage 2.4.1 Component Boxes cont ITEM PART #boxes COMPONENT 2.4.2Contactor Boxes PART # COMPONENT106-8658 2.4.3Heating Element Assemblies and Associated Parts 2.4.3.1 Element Assemblies and Hardware 2.4.3.1 Element Assemblies and Hardware cont WYE unitsITEM PART # COMPONENT 2.4.3.2 Element Tube Assemblies FULL-VATELEMENT ASSEMBLYDUAL-VATELEMENT ASSEMBLY 2.4.3.2 Element Tube Assemblies contd 2.4.4Computers ITEM 2.4.5Wiring COMPONENT Contactor Box Harness Assembly Dual VatPART # ITEM PART # 106-8744 14/17 kW Mechanical ContactorITEM PART # 2.4.5.5 Main Wiring Harnesses Filter Pump C2 to Component Box Wiring Harness PART #COMPONENT Full Vat Control Harness J4 to J2 Standard 2.4.5.8 M3000, MIB, AIF and ATO Wiring Harnesses Reset Switch 4-5Battery onlyonly ITEMPage 2.5.1 Filtration Components contCOMPONENT ITEM 2.5.2.2 Manual Interface Board Assembly ITEM PART #COMPONENT ITEM PART # 2.5.2.3 AIF Board Assembly 2.5.2.4 LOV PCB/Computer Board MatrixITEM PART # COMPONENT See Page 2-5for Drain Valve Assemblies PART #COMPONENT 2.6.2 Frypots with Rotary Actuators ITEMPART # COMPONENT 2.7 Oil Return Manifolds 2.8 Return Valves and Associated PartsITEM PART # 2.9.2 JIB Cap and Pick Up Assembly 2.8.2 Return Valve Rotary Actuators2.9Auto Top Off Components 2.9.1 JIB Basket PART # 2.9.2 JIB Cap and Pick Up Assembly cont 2.9.3 Automatic Top Off Board Assemblyshipping ITEM 2.9.4ATO Pump Assembly Domestic UnitsInternational Units ITEM ITEM PART #COMPONENT 108-3041 2.10RTI 2.10.1 RTI Manifold and Accessories 2.10.1 RTI Manifold and Accessories cont ITEMPART # COMPONENT 2.10.2RTI Dispose Waste Valve 2.10.3 RTI Test BoxMicroswitch, Gold Sealed Valve, ½” Ball Cover, DV Safety Switch Cover, DV Safety Switch Connectors and Tools 2.12Fasteners ITEMPART # COMPONENT THIS PAGE INTENTIONALLY LEFT BLANK SERVICE HOTLINE FAX PartsTech Support 1-800-551-8633