Rotary Actuator Drain Valves, Item, Part # | Frymaster BIELA14

Image 65

Frymaster BIELA14 manual Rotary Actuator Drain Valves, Item, Part #, Component

Contents

FRYMASTER BIELA14 SERIES GEN LOV ELECTRIC FRYER SERVICE AND PARTS MANUALemail: service@frymaster.com 8196446 NOTICE NOTICENOTICE DANGER DANGER Do not use water jets to clean this equipmentDANGERi DANGER B.WARRANTY PROVISIONS - FRYPOTS A.WARRANTY PROVISIONS - FRYERSD.WARRANTY EXCLUSIONS C.PARTS RETURN ELECTRICAL POWER SPECIFICATIONS CHAPTER 1: Service Procedures TABLE OF CONTENTSBIELA14 SERIES GEN II LOV ELECTRIC FRYERS BIELA14 SERIES GEN II LOV ELECTRIC FRYERS TABLE OF CONTENTS contCHAPTER 2: Parts List BIELA14 SERIES GEN II LOV ELECTRIC FRYERS CHAPTER 1: SERVICE PROCEDURES1.1 General 1.2 Replacing a Computer 3.Remove the two screws from the upper corners of the computer and allow the computer to swing down 1.5 Replacing a Temperature Probe 1.4 Replacing a High-LimitThermostatDANGER 4.Locate the red or yellow and white wires of the temperature probe to be replaced. Note where the leads are connected prior to removing them from the connector. Unplug the 12-pinconnector C-6and using a pin-pusherpush the pins of the temperature probe out of the connector 1.6Replacing a Heating Element Element grounding and wire routing Full vat element wire routingDual vat element wire routing 1.7Replacing Contactor Box Components DANGER 1.8 Replacing a Frypot 17.Disconnect the oil return flexlines malfunction DANGER 1.9.3 Replacing the Transformer or Filter Relay 1.10.1 ATO Automatic Top-offTroubleshooting 1.10 ATO Automatic Top-offService ProceduresProblem Probable Causes SERVICE ProblemProbable Causes Corrective Action Wire Reset Switch 1.10.4 Replacing the ATO PumpDrain Switch Switch The following buttons are inoperable in auto mode Buttons and LED’sConstant Illumination: Drain open No Illumination: Drain closed Problem 1.11.2 MIB Manual Interface Board TroubleshootingProbable Causes Corrective Action Probable Causes ProblemCorrective Action 1-19 Connector DISPLAY ResettingEXPLANATION Drain 1.11.6 Replacing the MIB Board 1.11.7 Control Power Reset Switch Troubleshooting 1.12RTI Service Issues 1.12.1 RTI MIB TestsWaste full signal AC voltage measurements 1.12.2 RTI LOV Wiring DISPOSE TO WASTE, REFILL VAT FROM BULK 1.12.4 RTI LOV TEST QUICK REFERENCEDISPOSE TO WASTE FILL VAT FROM BULK FILL JUG FROM BULK 1.13.1 AIF Troubleshooting ProblemCorrective Action Probable Causes Wire 1.13.4 Replacing a Linear Actuator Problem 1.13.5 Replacing a Rotary ActuatorRECOVERY FAULT Problem Probable CausesMISCONFIGURED Corrective Action Corrective Action ProblemProbable Causes 1.14.2 M3000 Useful Codes PASSWORDSProblem •0469 – Reset FILTER STAT DATA ERROR MESSAGE 1.14.3 Service Required ErrorsEXPLANATION 1-34 ERROR MESSAGE 1.14.4 Error Log CodesEXPLANATION 1-35 1.14.5 Tech Mode ERROR 1.14.6 M3000 Filter Error Flowchart NORMALSYSTEM ERROR FIXED? YES OPERATION RESUMES Adding New Menu Items 1.14.7 M3000 Menu Summary TreeStoring Menu Items in Product Buttons Draining, Refilling, and Disposing of Oil 1.14.8 M3000 Board Pin Positions and Harnesses SETUP COMPLETE is displayed 1.15Loading and Updating Software ProceduresUNTIL THE DISPLAY PROMPTS TO DO SO IN STEP 24.FILTER NOW YES/NO is displayed 1.16 BIELA14 Series LOV Data Network Flowchart Diagnostic LED Legend 1.17 Interface Board Diagnostic ChartPN 826-2260 1-42 Probe Resistance Chart 1.18 Probe Resistance ChartOHMS OHMS 1.19.1 Component Wiring Domestic 1.19 Wiring Diagrams 1.19.2 Component Wiring CE 1.19.3 Component Wiring CSA 1.19.4 Component Wiring Australia 1.19.5 Contactor Box – Delta Configuration 1.19.6 Contactor Box - WYE Configuration Page Page Page Page Page Accessories CHAPTER 2 PARTS LISTITEM PART # PART # ITEMCOMPONENT Not illustrated 2.3.1 Drain Tube Sections and Associated Parts 2.3Drain System ComponentsPART# ITEM ITEM 2.3.2.2 Rotary Actuator Drain ValvesPART # COMPONENTPage ITEM PART # 2.4.1 Component Boxes contboxes COMPONENT 2.4.2Contactor Boxes 106-8658 PART #COMPONENT 2.4.3Heating Element Assemblies and Associated Parts 2.4.3.1 Element Assemblies and Hardware WYE units 2.4.3.1 Element Assemblies and Hardware contITEM PART # COMPONENT DUAL-VATELEMENT ASSEMBLY 2.4.3.2 Element Tube AssembliesFULL-VATELEMENT ASSEMBLY 2.4.4 2.4.3.2 Element Tube Assemblies contdComputers ITEM COMPONENT Contactor Box Harness Assembly Dual Vat 2.4.5WiringPART # ITEM PART # 14/17 kW Mechanical Contactor 106-8744ITEM PART # 2.4.5.5 Main Wiring Harnesses PART # Filter Pump C2 to Component Box Wiring HarnessCOMPONENT Full Vat Control Harness J4 to J2 Standard Reset Switch 4-5Battery only 2.4.5.8 M3000, MIB, AIF and ATO Wiring Harnessesonly ITEMPage Filtration Components cont 2.5.1COMPONENT ITEM ITEM PART # 2.5.2.2 Manual Interface Board AssemblyCOMPONENT ITEM PART # 2.5.2.4 LOV PCB/Computer Board Matrix 2.5.2.3 AIF Board AssemblyITEM PART # COMPONENT COMPONENT See Page 2-5for Drain Valve AssembliesPART # ITEM 2.6.2 Frypots with Rotary ActuatorsPART # COMPONENT 2.8 Return Valves and Associated Parts 2.7 Oil Return ManifoldsITEM PART # 2.8.2 Return Valve Rotary Actuators 2.9.2 JIB Cap and Pick Up Assembly2.9Auto Top Off Components 2.9.1 JIB Basket PART # 2.9.3 Automatic Top Off Board Assembly 2.9.2 JIB Cap and Pick Up Assembly contshipping ITEM Domestic Units 2.9.4ATO Pump AssemblyInternational Units ITEM PART # ITEMCOMPONENT 108-3041 2.10RTI 2.10.1 RTI Manifold and Accessories ITEM 2.10.1 RTI Manifold and Accessories contPART # COMPONENT 2.10.3 RTI Test Box 2.10.2RTI Dispose Waste ValveMicroswitch, Gold Sealed Valve, ½” Ball Cover, DV Safety Switch Cover, DV Safety Switch Connectors and Tools ITEM 2.12FastenersPART # COMPONENT THIS PAGE INTENTIONALLY LEFT BLANK FAX Parts SERVICE HOTLINETech Support 1-800-551-8633