Manuals / Frymaster / Kitchen Appliance / Fryer

Frymaster BIELA14 manual Manual Interface Board Assembly, Item Part #, Component

Models: BIELA14

1 96

Download 96 pages 23.21 Kb

Page 81

2.5.2.2 Manual Interface Board Assembly

2.5.2Auto Intermittent Filtration Components 2.5.2.1 LOV™ Indicator Lights Assembly

106-8231SP LOV™ Panel Assembly

ITEM PART #

COMPONENT

1106-8106SP Light, Blue 24VDC LED Flush

2106-8105SP Light, Yellow/Orange 24VDC LED Flush

3230-4271 Plate, Control Frame LOV™

2.5.2.2 Manual Interface Board Assembly

108-1298 Manual Interface Board Assembly

ITEM PART #

108-1298

1220-6288

√2 108-2156 807-4481

3220-5793

√Recommended parts.

COMPONENT

Assembly, MIB

Cover, MIB

Assembly, MIB Computer w/ Frame

Overlay

Assembly Back, Box MIB

2-20

Image 81

Frymaster BIELA14 manual Manual Interface Board Assembly, Item Part #, Component

Contents

FRYMASTER BIELA14 SERIES GEN LOV ELECTRIC FRYER SERVICE AND PARTS MANUALemail: service@frymaster.com 8196446NOTICE NOTICENOTICE DANGERDANGER Do not use water jets to clean this equipmentDANGERi DANGERB.WARRANTY PROVISIONS - FRYPOTS A.WARRANTY PROVISIONS - FRYERSD.WARRANTY EXCLUSIONS C.PARTS RETURNELECTRICAL POWER SPECIFICATIONS TABLE OF CONTENTS BIELA14 SERIES GEN II LOV ELECTRIC FRYERSCHAPTER 1: Service Procedures TABLE OF CONTENTS cont CHAPTER 2: Parts ListBIELA14 SERIES GEN II LOV ELECTRIC FRYERS BIELA14 SERIES GEN II LOV ELECTRIC FRYERS CHAPTER 1: SERVICE PROCEDURES1.1 General 1.2 Replacing a Computer3.Remove the two screws from the upper corners of the computer and allow the computer to swing down 1.5 Replacing a Temperature Probe 1.4 Replacing a High-LimitThermostatDANGER 4.Locate the red or yellow and white wires of the temperature probe to be replaced. Note where the leads are connected prior to removing them from the connector. Unplug the 12-pinconnector C-6and using a pin-pusherpush the pins of the temperature probe out of the connector 1.6Replacing a Heating Element Full vat element wire routing Dual vat element wire routingElement grounding and wire routing 1.7Replacing Contactor Box Components DANGER 1.8 Replacing a Frypot17.Disconnect the oil return flexlines malfunction DANGER 1.9.3 Replacing the Transformer or Filter Relay 1.10.1 ATO Automatic Top-offTroubleshooting 1.10 ATO Automatic Top-offService ProceduresProblem Probable CausesSERVICE ProblemProbable Causes Corrective ActionWire Reset Switch 1.10.4 Replacing the ATO PumpDrain Switch SwitchThe following buttons are inoperable in auto mode Buttons and LED’sConstant Illumination: Drain open No Illumination: Drain closedProblem 1.11.2 MIB Manual Interface Board TroubleshootingProbable Causes Corrective ActionProbable Causes ProblemCorrective Action 1-19Connector DISPLAY ResettingEXPLANATION Drain1.11.6 Replacing the MIB Board 1.11.7 Control Power Reset SwitchTroubleshooting 1.12RTI Service Issues 1.12.1 RTI MIB TestsWaste full signal AC voltage measurements1.12.2 RTI LOV Wiring DISPOSE TO WASTE, REFILL VAT FROM BULK 1.12.4 RTI LOV TEST QUICK REFERENCEDISPOSE TO WASTE FILL VAT FROM BULKFILL JUG FROM BULK 1.13.1 AIF Troubleshooting ProblemCorrective Action Probable CausesWire 1.13.4 Replacing a Linear Actuator Problem 1.13.5 Replacing a Rotary ActuatorRECOVERY FAULTProblem Probable CausesMISCONFIGURED Corrective ActionProblem Probable CausesCorrective Action 1.14.2 M3000 Useful Codes PASSWORDSProblem •0469 – Reset FILTER STAT DATAERROR MESSAGE 1.14.3 Service Required ErrorsEXPLANATION 1-34ERROR MESSAGE 1.14.4 Error Log CodesEXPLANATION 1-351.14.5 Tech Mode ERROR 1.14.6 M3000 Filter Error Flowchart NORMALSYSTEM ERROR FIXED? YES OPERATION RESUMESAdding New Menu Items 1.14.7 M3000 Menu Summary TreeStoring Menu Items in Product Buttons Draining, Refilling, and Disposing of Oil1.14.8 M3000 Board Pin Positions and Harnesses SETUP COMPLETE is displayed 1.15Loading and Updating Software ProceduresUNTIL THE DISPLAY PROMPTS TO DO SO IN STEP 24.FILTER NOW YES/NO is displayed1.16 BIELA14 Series LOV Data Network Flowchart Diagnostic LED Legend 1.17 Interface Board Diagnostic ChartPN 826-2260 1-42Probe Resistance Chart 1.18 Probe Resistance ChartOHMS OHMS1.19.1 Component Wiring Domestic 1.19 Wiring Diagrams1.19.2 Component Wiring CE 1.19.3 Component Wiring CSA 1.19.4 Component Wiring Australia 1.19.5 Contactor Box – Delta Configuration 1.19.6 Contactor Box - WYE Configuration Page Page Page Page Page Accessories CHAPTER 2 PARTS LISTITEM PART #PART # ITEMCOMPONENT Not illustrated2.3.1 Drain Tube Sections and Associated Parts 2.3Drain System ComponentsPART# ITEMITEM 2.3.2.2 Rotary Actuator Drain ValvesPART # COMPONENTPage ITEM PART # 2.4.1 Component Boxes contboxes COMPONENT2.4.2Contactor Boxes PART # COMPONENT106-8658 2.4.3Heating Element Assemblies and Associated Parts 2.4.3.1 Element Assemblies and Hardware WYE units 2.4.3.1 Element Assemblies and Hardware contITEM PART # COMPONENT2.4.3.2 Element Tube Assemblies FULL-VATELEMENT ASSEMBLYDUAL-VATELEMENT ASSEMBLY 2.4.4 2.4.3.2 Element Tube Assemblies contdComputers ITEMCOMPONENT Contactor Box Harness Assembly Dual Vat 2.4.5WiringPART # ITEM PART #14/17 kW Mechanical Contactor 106-8744ITEM PART #2.4.5.5 Main Wiring Harnesses ITEM Filter Pump C2 to Component Box Wiring HarnessPART # COMPONENTReset Switch 4-5Battery only 2.4.5.8 M3000, MIB, AIF and ATO Wiring Harnessesonly ITEMPage Filtration Components cont 2.5.1COMPONENT ITEMITEM PART # 2.5.2.2 Manual Interface Board AssemblyCOMPONENT ITEM PART #2.5.2.4 LOV PCB/Computer Board Matrix 2.5.2.3 AIF Board AssemblyITEM PART # COMPONENTSee Page 2-5for Drain Valve Assemblies PART #COMPONENT ITEM 2.6.2 Frypots with Rotary ActuatorsPART # COMPONENT2.8 Return Valves and Associated Parts 2.7 Oil Return ManifoldsITEM PART #2.8.2 Return Valve Rotary Actuators 2.9.2 JIB Cap and Pick Up Assembly2.9Auto Top Off Components 2.9.1 JIB Basket PART #2.9.3 Automatic Top Off Board Assembly 2.9.2 JIB Cap and Pick Up Assembly contshipping ITEMDomestic Units 2.9.4ATO Pump AssemblyInternational Units ITEMPART # ITEMCOMPONENT 108-30412.10RTI 2.10.1 RTI Manifold and Accessories ITEM 2.10.1 RTI Manifold and Accessories contPART # COMPONENT2.10.3 RTI Test Box 2.10.2RTI Dispose Waste ValveMicroswitch, Gold Sealed Valve, ½” Ball Cover, DV Safety Switch Cover, DV Safety SwitchConnectors and Tools ITEM 2.12FastenersPART # COMPONENTTHIS PAGE INTENTIONALLY LEFT BLANK FAX Parts SERVICE HOTLINETech Support 1-800-551-8633