S1800 SELF-CONTAINED 1 Phase, Control Board | Manitowoc Ice

Electrical System	Section 6

S1800 - SELF-CONTAINED - 1 PHASE

				WATER
L1				VALVE
L1			(20)	(21)
			(20)	(21)
					(22)
(89)				LH HARVEST
(89)	(55)		(61)	(77) SOLENOID
		CONTROL BOARD		(88)	(87)
HIGH PRESSURE		CONTROL BOARD		(88)
CUTOUT		(2)
		(2)		RH HARVEST
(88)		(6)	(60)	RH HARVEST	(80)
(88)		(6)	(60)	SOLENOID	(80)
		(5)

L2 OR N

(99)

(42)

ICE THICKNESS

PROBE

WATER LEVEL

PROBE

CONTACTOR

CONTACTS

L1

(51)

	(1)			(76)	(81)
	(7)			DUMP	(81)
	(4)		(57)	SOLENOID
	(4)		(57)	(98)
				(98)
	TRANS.				WATER
					PUMP
	FUSE (7A)		(58)	TERMINATES AT
				TERMINATES AT
				PIN CONNECTION
	CLEAN			(59)
	CLEAN	L2	AIR	CONTACTOR
	LEFT BIN	L2	AIR
	LEFT BIN		COMP
	RIGHT BIN		(56)	COIL
	RMT BIN			AIR
	WTR PROBE		(26)	AIR
	ICE PROBE		(26)	COMPRESSOR
	HARVEST			WHEN USED
	HARVEST
	SL-1		(25)
	SL-2		(25)
	SL-2	(9)
		(9)			(74)
					(74)
			(8)	BIN
	LOW D.C.		(6)	SWITCH
			(6)

	VOLTAGE
	PLUG
			(1)	CLEAN
			(1)	OFF
				OFF
				ICE
		(RED)	(2)
		(RED)
	COMPRESSOR			RUN
	COMPRESSOR			CAPACITOR
				CAPACITOR
R	S	(YELLOW)		R
*OVERLOAD	C		(46)	R
*OVERLOAD			(46)	R	(50)
				R	(50)
(BLACK)			PTCR	(45)
(85)	(86)		(44)
			(44)

FAN MOTOR

(AIR COOLED ONLY)

FAN CYCLE

CONTROL

(75)

RUN CAPACITOR**

6-10	Part Number 80-1634-3

Image 48

Manitowoc Ice service manual S1800 SELF-CONTAINED 1 Phase, Control Board

Contents

Service Manual Read These Before Proceeding Personal Injury Potential Table of Contents Table of Contents Section Ice Machine Operation Section MaintenanceSection Before Calling For Service Table of Contents Section Electrical System Section Refrigeration System Table of Contents How to Read a Model Number Model NumbersIce Cube Sizes Self-Contained Water-Cooled General Information Section Accessories Section General Information Model/Serial Number Location Model/Serial Number Location Warranty Coverage Ice Machine Dimensions Width, Depth, and Height DimensionsElectrical and AuCS Dimensions General Installation Instructions Section Location of Ice Machine Ice Machine Heat of RejectionS1800M Water-Cooled Series Heat of Rejection Ice Machine Air Conditioning Section Installation Instructions Electrical Service VoltageMinimum Circuit Ampacity Electrical Requirements For United Kingdom Only Self Contained ICE Machine 115/1/60 or 208-230/1/60Self Contained ICE Machine 208-230/3/60 Self Contained ICE Machine 230/1/50 Cooling Tower Applications Water SupplyWater Inlet Lines Drain Connections Installation Instructions Section Typical Water Supply Drain InstallationWater Supply and Drain Line SIZING/CONNECTIONS Condenser Section Installation Instructions Installation Check List AuCS Automatic Cleaning System Potential Personal Injury Situation Section Ice Machine Operation Component Identification Ice Machine Operation Section Sequence Of Operation Initial START-UP or START-UP After Automatic SHUT-OFF Safety Timers Harvest Sequence 5. Water PurgeHarvest Automatic SHUT-OFF 7. Automatic Shut-Off Ice Machine Operation Section Operational Checks Water LevelICE Thickness Check Ice Thickness Check Water Purge Adjustment Harvest Sequence Water Purge Ice Machine Operation Section This page Intentionally Left Blank Exterior Cleaning Ice Machine InspectionWater-Cooled Condenser Water Regulating Valve AlphaSan→ Maintenance Section Guardian InstallationSachet Replacement Frequency Sachet Replacement Procedure Section Maintenance Interior Cleaning and Sanitizing Cleaning ProcedureModel Amount of Cleaner Step Maintenance Section Sanitizing ProcedureSolution Type Water Mixed With Sanitizer Removal of Parts for CLEANING/SANITIZING Solution Type Water Mixed With Water Curtain Water Curtain Removal Ice Thickness ProbeIce Thickness Probe Removal Water Distribution Tube Water TroughWater Distribution Tube Removal Water Level Probe Water PumpWater Pump Removal Dump Valve Disassembly Water Dump Valve Evaporator Tray Removal Drain Line Check Valve Water Inlet Valve Maintenance Section Removal from Service/Winterization Pry Open the Water Regulating Valve AUCS→ AccessorySELF-CONTAINED WATER-COOLED ICE Machines Checklist Problem Possible Cause To Correct Before Calling For Service Section Safety Limit Feature Energized Parts Charts Section Electrical SystemSELF-CONTAINED WATER-COOLED Models SELF-CONTAINED Models Initial Start-Up or Start-Up After Automatic Shut-OffWater Purge Self-Contained Water Purge Refrigeration System Start Up 5 Seconds Toggle Switch Refrigeration System START-UPSelf-Contained Refrigeration System Start-Up Electrical System Section Freeze SequencePRE-CHILL Self-Contained Pre-Chill Self-Contained Models Toggle Switch Bin Switch Control Board Relays FreezeSelf-Contained Freeze Self-Contained Models Harvest Sequence Harvest Automatic Shut-Off Automatic SHUT-OFFSelf-Contained Automatic Shut-Off Section Electrical System Wiring Diagrams Wiring Diagram Legend S1800 SELF-CONTAINED 1 Phase Control Board S1800 SELF-CONTAINED 3 Phase Specifications Check ProcedureBIN Switch Main Fuse Symptoms Diagnostic AidsContinuity Test Water Curtain Removal Notes Compressor Electrical Diagnostics Check Resistance Ohm ValuesCheck Motor Windings to Ground Determine if the Compressor is Seized Ptcr Diagnostics What is a PTCR?Compressor Start Sequence Troubleshooting PTCR’s WHY a Good Ptcr MAY Fail To Start the CompressorModel Automatic Shut-Off and Restart During Start-Up First .25 1.0 Seconds Checking the Ptcr Manitowoc PtcrModel Manitowoc Cera-Mite Room Part Number Diagnosing Start Components CapacitorRelay Relay Operation Check ICE/OFF/CLEAN Toggle Switch Switch Setting Terminals Ohm Reading Electronic Control Board Control Board Safety Limits Inputs Freeze Time LOCK-IN Feature Ice Thickness Probe CleaningHOW the Probe Works Harvest Light Diagnosing ICE Thickness Control Circuitry Monitoring of Harvest Light Correction Water Inlet Valve Safety SHUT-OFF Electrical System Section Water Level Control CircuitryWater Level Probe Light Freeze Cycle Circuitry Problem Water Trough Overfilling During Freeze Cycle Diagnosing Water Level Control CircuitryWait until the freeze cycle starts On or OFF Step Check Self Contained 1 Phase with Terminal Board SELF-CONTAINED Water -COOLED Models Freeze Cycle Refrigeration Sequence Refrigeration System Section S1800 SELF-CONTAINED Tubing Schematic General Before Beginning Service Weights are in poundsICE Production Check Times are in minutes INSTALLATION/VISUAL Inspection Checklist Water System ChecklistPossible Problem Corrective Action ICE Formation Pattern Extremely Thin at Evaporator OutletNormal Ice Formation Extremely Thin at Evaporator Inlet No Ice Formation Safety Limits Safety Limit IndicationAnalyzing Why Safety Limits May Stop the Ice Machine Safety Limit Notes Possible Cause Check/Correct Section Refrigeration System Procedure Freeze Cycle Discharge Pressure High ChecklistFreeze Cycle Discharge Pressure Low Checklist Analyzing Discharge Pressure During Freeze or Harvest Cycle Step Example Using SY1004A Model Ice Machine Analyzing Suction Pressure During Freeze Cycle Freeze Cycle Suction Pressure High Checklist Freeze Cycle Suction Pressure Low Checklist Harvest Valve Temperature Check General Harvest Valve AnalysisFindings Comments Discharge Line Temperature Analysis General Final Analysis Column 1 Harvest Valve LeakingColumn 2 LOW CHARGE/TXV Starving Column 3 TXV Flooding Refrigeration System Operational Analysis Tables Models Dual Expansion Valve Ice Machine Model Number High Pressure CUT-OUT Hpco Control S1800 Series Self-Contained Water-Cooled Cycle TimesHour Ice Production Operating Pressures SELF-CONTAINED RECOVERY/EVACUATION Connections Self-Contained Charging Procedures Charging Connections System Contamination CLEAN-UP Determining Severity Of Contamination Mild System Contamination Cleanup Procedure Severe System Contamination Cleanup Procedure Section Refrigeration System 10. Using Pinch-Off Tool FILTER-DRIERS Drier End Part Model Connection Size Number Total System Refrigerant Charges Series Version Charge S1800M48 oz Recover New Product SpecificationsRefrigerant Definitions Recycle Recovered or Recycled Refrigerant Refrigerant RE-USE PolicyNew Refrigerant Reclaimed Refrigerant HFC Refrigerant Questions and Answers This page Intentionally Left Blank Page Attend a Manitowoc Factory Service School