Johnson Controls GG9S'MP Airflow Airflow, Downflow - Inducer Rotated For Left Side Venting

Page 19

Johnson Controls Unitary Products

FIGURE 26: Downflow Configuration

When drain hose routing changes are required, be sure to cap all un-used openings.

If rerouting hoses - excess length should be cut off so that no sagging loops will collect and hold condensate, which will cause the furnace to not operate.

AIRFLOW

Move rain gutter hose to this position

1Move pressure switch hose to this position. NOTE: May require the longer hose that is provided with wider cabinets

Move rain gutter hose to this position

364861

DOWNFLOW - INDUCER ROTATED

FOR LEFT SIDE VENTING

Move condensate drain hose to this position (May exit either side of the cabinet)

DOWNFLOW - INDUCER ROTATED

FOR RIGHT SIDE VENTING

-UIM-H-0712

Image 19

Contents 95.5% AFUE Single Stage Multi-position INSTALLATION MANUALRESIDENTIAL GAS FURNACE MODELS TG9S*MP, GG9S*MP364861-UIM-H-0712 SECTION I SAFETYSPECIFIC SAFETY RULES AND PRECAUTIONS SAFETY REQUIREMENTS364861-UIM-H-0712 STEP 1 - SafetySTEP 2 - General Installation STEP 6 - Gas Piping and Gas Pipe Pressure TestingINSPECTION Clearances for access/serviceInstallation in a residential garage 364861-UIM-H-0712SECTION II DUCTWORK FLOOR BASE AND DUCTWORK INSTALLATION - DOWNFLOWThe duct system’s design and installation must installedCOIL FLANGE INSTALLATION COIL INSTALLATIONCOIL/FURNACE ASSEMBLY - MC/FC/PC SERIES COILS FURNACE ASSEMBLY - MC & FC SERIES COILSDIMENSION “C” INCH DOWNFLOW DUCT CONNECTORSCOIL / FURNACE ASSEMBLY - HC SERIES COILS BOTTOM RETURN AND ATTIC INSTALLATIONSDOWNFLOW APPLICATION ATTIC INSTALLATIONSUSPENDED FURNACE / CRAWL SPACE INSTALLATION 364861-UIM-H-0712attempt to install filters inside the furnace FILTER INSTALLATIONFIGURE 13 Dimensions Cabinet Dimensions InchesSECTION IV GAS PIPING DANGERGAS SAFETY GAS PIPING INSTALLATIONDANGER SECTION V ELECTRICAL POWERHIGH ALTITUDE PRESSURE SWITCH CONVERSION ELECTRICAL POWER CONNECTIONSInput LOW VOLTAGE CONTROL WIRING CONNECTIONS364861-UIM-H-0712 SUPPLY VOLTAGE CONNECTIONS364861-UIM-H-0712 AC 5DJohnson Controls Unitary Products Single Stage Heat Pump - Single Stage PSC Furnace HP 2C364861-UIM-H-0712 364861-UIM-H-0712 ACCESSORY CONNECTIONSELECTRONIC AIR CLEANER CONNECTION SECTION VI TWINNING AND STAGINGSTAGING 364861-UIM-H-0712Twinning Operation Staging OperationOpen Stand Pipe Anti-siphonair vent 5” Min Tee 364861-UIM-H-0712CONDENSATE DRAIN TERMINATION Johnson Controls Unitary ProductsUPFLOW pressure switch hose1 pressure switchhose INDUCER ROTATED FOR RIGHT SIDE VENTINGDOWNFLOW - INDUCER ROTATED FOR LEFT SIDE VENTING AIRFLOW AIRFLOWDOWNFLOW - INDUCER ROTATED FOR RIGHT SIDE VENTING AIRFLOW HORIZONTAL - LEFT INDUCER ROTATEDHORIZONTAL - LEFT INDUCER AS RECEIVED Except for 130K ModelHORIZONTAL - RIGHT Move pressure switch hose to this position1Move pressure switch hose to this position HORIZONTAL - RIGHT INDUCER ROTATEDCOMBUSTION AIR/VENT PIPE SIZING COMBUSTION AIR AND VENT SAFETYSECTION VIII COMBUSTION AIR AND VENT SYSTEM 364861-UIM-H-0712364861-UIM-H-0712 COMBUSTION AIR AND VENT PIPING ASSEMBLYFIGURE 29 Dimensions Elbow A DimensionVENT CLEARANCES Canadian Installations1,3US Installation2,3 364861-UIM-H-0712VENTING MULTIPLE UNITS 364861-UIM-H-0712VENT SYSTEM VENT APPLICATIONS AND TERMINATIONOutdoor Combustion Air 364861-UIM-H-0712DOWNWARD VENTING COMBUSTION AIR SUPPLYCombustion Air Source From Outdoors 364861-UIM-H-0712Ambient Combustion Air Supply Dampers, Louvers and Grilles Canada OnlyVentilated Combustion Air Termination 364861-UIM-H-0712Air Supply Openings and Ducts Ventilated Combustion AirVENT BLOWER ROTATION SECTION IX START-UPAND ADJUSTMENTSSpecially Engineered Installations 364861-UIM-H-0712HOT SURFACE IGNITION SYSTEM 364861-UIM-H-0712IGNITION SYSTEM SEQUENCE CALCULATING THE FURNACE INPUT NAT. GAS1 Cu Ft 364861-UIM-H-0712Johnson Controls Unitary Products 1 RevolutionRead the manifold gas pressure ADJUSTMENT OF MANIFOLD GAS PRESSURE & INPUT RATE364861-UIM-H-0712 Read the inlet gas pressure364861-UIM-H-0712 ADJUSTMENT OF TEMPERATURE RISEADJUSTMENT OF FAN CONTROL SETTINGS DANGERBottom Airflow Data SCFM 364861-UIM-H-0712Johnson Controls Unitary Products 364861-UIM-H-0712ROLLOUT SWITCH CONTROLS SECTION X SAFETY CONTROLSSECTION XI NORMAL OPERATION AND DIAGNOSTICS BLOWER DOOR SAFETY SWITCH364861-UIM-H-0712 FURNACE CONTROL DIAGNOSTICSJohnson Controls Unitary Products 364861-UIM-H-0712 SECTION XII REPLACEMENT PARTS LISTREPLACEMENT PART CONTACT INFORMATION DIAGNOSTIC FAULT CODE STORAGE AND RETRIEVALJohnson Controls Unitary Products Wiring Diagram - 95% Single-StageFurnaceSECTION XIII WIRING DIAGRAMNorman, OK York International Corp 5005 York Drive