Walker MC19 manual Fuel Filter Location, Blade Overload Shear Bolts, Cutting Blade Shear Bolts

Page 73

Maintenance Instructions

REPLACING/REPAIRING

Fuel Filter

DANGER

Gasoline is extremely flammable and can be highly explosive. To minimize danger:

Use only an approved fuel container for gasoline.

DO NOT allow open flames or sparks near the machine while performing main- tenance or refueling; DO NOT smoke while working with fuel.

Wipe up spilled gasoline immediately and completely.

Model MC19 is equipped with an in-line fuel filter. Visually inspect the filter periodically, and replace the filter yearly.

In-Line

Fuel Filter

Fuel Filter Location

IMPORTANT: Replace the fuel filter only in a clean area where the fuel line and connections will not be contaminated by any dust and dirt.

1.Expand and slide clamps on either side of the filter away from filter and pull fuel lines off filter.

2.Replace filter, making sure that the arrow on the filter is aligned with the fuel flow through the filter.

3.Verify that the fuel lines and clamps are secure- ly attached, and that no fuel leaks are present.

Blade Overload Shear Bolts

NOTE: Blade shear bolts are not used on belt driv- en decks.

On gear driven decks each cutting blade is keyed to a blade hub by two (2) shear bolts (10-24 x 5/8 in. stainless steel machine screws). These bolts are designed to shear and protect the blade drive gear- box from damage if the blade encounters a shock load.

Cutting Blade

Shear Bolts

Cutting Blade Shear Bolts

NOTE: Tightening the 5/8-18 blade mounting nut to 60 lb·ft (81 N·m) is also important for proper shock load protection. It is important to not over- tighten the mounting nut since this defeats (over- rides) the function of the shear bolts.

If these bolts shear, remove the blade and install new bolts. Refer to CHECKING/SERVICING in this section for Sharpen Mower Blades which de- scribes the blade removal and installation proce- dure.

After reinstalling the blade, check blade timing (on gear driven decks) by moving blades through one

(1)complete revolution. Make sure blade tips pass clear of each other. If timing is incorrect, contact your Walker dealer.

69

Image 73
Contents OPERATOR’S Manual Foreword Table of Contents Maintenance Schedule Chart Important Tips for Care Glossary General InformationIdentifying Number Locations Fill In By PurchaserServicing of Engine and Drivetrain Components Engine SpecificationsElectrical System TransmissionTire Size Blade DriveDrive Belts SeatMower Deck GHS SystemFront View and Right Side View Component IdentificationRear View and Left Side View Top View Engine Compartment PTOBefore Operating Safety Instructions Before OperatingDo not mow with bystanders in the area Safety Instructions Before Operating Safety Instructions Operating Safety Instructions Operating Safety Instructions Maintenance Safety Instructions Location Deck Discharge Shield SD Decks Only Part Number Location Each End of Mower Deck Part NumberLocation Catcher Door Hinge Bar LH and RH Sides Part Number Location Right Side, Behind Operator Seat Part NumberSAFETY, CONTROL, and Instruction Decals Setup Instructions Assembly InstructionsBattery Service Wet Battery ServiceBattery Installation Battery ChargingBattery Installation Mower Deck Assembly Deck Caster Wheels InstallationDischarge Shield Installation On Side Discharge Deck Deck Caster Wheel InstallationPTO Shaft Guard Installation PTO Coupler Installation Tool Deck InstallationMower Deck Installation PTO Shaft Connection Quick Disconnect Ring Released Position Deck Counterweight Spring InstallationQuick Disconnect Ring Locked Position Deck Leveling Machine must be shut off during this procedureDeck Leveling Refer to Lubrication for Gear Axle Lubrication Fill Fuel TankBlades in Maintenance Instructions Control IDENTIFICATION, LOCATION, and Function Operating InstructionsEngine Choke Key PositionsChoke and Throttle Location Forward Speed Control FSC Engine ThrottleSteering Levers Blade Clutch PTOLockout Lever Location Parking Brake Disengaged Front Body Latch ReleaseOil Pressure Warning Horn HourmeterOperating Controls Top View from Drivers Point of View Left Wheel Steering LeverStarting the Engine Adjusting Ground Speed and SteeringEngaged Fore Attempting to MOWOperating Instructions Correct Operator Hand Position On the Controls Blade Clutch Disengaged Blade Clutch EngagedStopping the Machine Transmission Lockout Cutting Height AdjustmentLockout Lever Freewheel Position Recommendations for Mowing Lockout Lever Normal Operating PositionNo Driving Zone Side Discharge Deflector Shield Lowest PositionRecommendations for TILT-UP Deck OPERATION/TRANSPORT GHS Flow and Components Blower Intake Cover General InformationRotating Blower Blades Forward Clogging ChecklistBlade Rotation for GHS Mower Deck View from Underneath Powerfil Using the Tilt-Up DeckFull Signal Horn Grass Catcher Screen Removal for CleaningTailgate Dumping Using the Dump BagPositioning Dump Bag on Catcher Dumping Catcher into Dump Bag Maintenance Instructions Important Tips for Care of the Kohler Engine Engine Oil LubricationEach USE Dipstick Operating RangeTurn Oil Drain/Oil Filter LocationMower Deck Gearbox Lubrication DS52 or DS62 Mower Deck Lubrication Changing Gearbox Oil Dipstick Location, Tractor PTO GearboxGear Axle Lubrication RantyGrease Fitting and Oil Point Lubrication Transmission Reservoir Air Bleed Plug LocationLubrication Points for Optional Belt Driven Decks DS62 Shown Chassis and Deck Lubrication Points DS42 Shown Engine Air Cleaner System Components Air Filter Restriction Gauge Location Air Cleaner Components Shown with Cover Being RemovedProper Orientation of Air Cleaner Cover Air Filter Element ReplacementCooling Air Intake System Deck Secured in TILT-UP Position Engine Cooling Air Intake Screen Cooling Fin Access PanelsMaintenance Instructions GHS Exhaust Screen BatteryCHECKING/SERVICING Electrolyte LevelWheel Bolt Torque Charging the BatterySharpen Mower Blades Blade Balanced on Magnetic Wall-Mounted Balancer Mower Blade Profile For SharpeningDrive Belts Spark Plugs Drive Belts There are four 4 individual belts on GHS models REPLACING/REPAIRINGBelt Locations REPLACING/REPAIRINGEngine PTO Drive Belt Removal Engine PTO Drive Belt 3 Groove Power Band Jackshaft Drive Belt Disengaged Jackshaft Drive Belt Jackshaft Drive Belt Engaged GHS Blower Drive Belt Assembly Engaged GHS Blower Drive Belt Assembly DisengagedHydrostatic Ground Drive Belt Assembly Engaged Hydrostatic Ground Drive Belt Assembly DisengagedBlade Overload Shear Bolts Fuel Filter LocationCutting Blade Shear Bolts PTO Shear Pin Steering Handle Adjustment Tilt-Up Deck Adjustable Stop AdjustmentsSteering Handles Pinch Point Spring Loaded Door Operator’s Notes Operator’s Notes Limited Warranty For Walker Commercial Rider Mower Walker MFG. CO E. Harmony ROAD, Fort COLLINS, CO 80528 970