Henny Penny Pressure Fryers Model Model Computron 2000 Controls
OPERATOR’S MANUAL
Page
FM07-219-B Revised
LIMITED WARRANTY FOR HENNY PENNY EQUIPMENT
Model 500/600
Page
DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS
Technical Data for CE Marked Products
Page
TABLE OF CONTENTS
Section
Section 4. PROGRAMMING
TABLE OF CONTENTS Continued
Section 5. TROUBLESHOOTING
1-3. ASSISTANCE 1-4. MODEL VARIATIONS
SECTION 1. INTRODUCTION
1-1. PRESSURE FRYER P-H-T Pressure Heat Time 1-2. PROPER CARE
CAUTION used with the safety alert symbol indicates a
1-5. SAFETY
potentially hazardous situation which, if not avoided
may result in minor or moderate injury
SECTION 2. INSTALLATION
2-2. UNPACKING INSTRUCTIONS Continued
2-3. SELECTING THE FRYER
position and install fryer to prevent tipping or move
LOCATION
ment. Restraining ties may be used for stabilization
Ventilation must conform to local, state, and national codes
2-6. GAS SUPPLY
2-7. GAS PIPING
Henny Penny Part No. 19921, which complies with
1207
2-7. GAS PIPING Continued
Model 500/600
The gas pressure regulator on the automatic gas valve
2-10. GAS PILOT & BURNER 7. Turn main power switch to ON position
2-13. ELECTRICAL REQUIREMENTS ELECTRIC FRYER
GAS FRYER
2-14. ELECTRICAL
REQUIREMENTS
2-17. OPERATIONAL CHECKS
2-15. CHECKING THE FILTER PUMP Step 2-16. MOTOR BEARINGS
Page
SECTION 3. OPERATING INSTRUCTIONS
Figure 1 Control Panel
3-1. OPERATING CONTROLS Continued
Model 500/600
1207
Item
3-2. OPERATING COMPONENTS
Description
Function
3-2. OPERATING COMPONENTS
DO NOT OPEN THE DRAIN VALVE WHILE FRYPOT
A microswitch that provides protection for the frypot in the event an
Continued
3-2. OPERATING COMPONENTS
Description
Function
3-2. OPERATING COMPONENTS Continued
ELECTRIC MODEL Figure 2. Operating Controls
Model 500/600
1207
3-2. OPERATING COMPONENTS Continued
GAS MODEL Figure 3. Operating Controls
Model 500/600
1207
Model 500/600
3-2. OPERATING COMPONENTS Continued
Figure 5. Operating Controls Figure 4. Operating Controls
Figure 6. Operating Controls
3-3. FILLING OR ADDING SHORTENING
3-4. CARE OF THE SHORTENING FOLLOW THE INSTRUCTIONS BELOW TO AVOID
1. Be sure the drain valve is in the closed position
3-5. BASIC OPERATIONS AND PROCEDURES Continued Step Step
LID WHEN THE FRYPOT IS PRESSURIZED ALLOWS
WHEN FRYER IS UNDER PRESSURE. DO NOT
DO NOT ATTEMPT TO OPEN LID UNTIL THE
PRESSURE DROPS TO ZERO. LID IS LOCKED
Frequency
3-6. REGULAR MAINTENANCE SCHEDULE Procedure
3-7. FILTER PUMP MOTOR PROTECTOR- MANUAL RESET
3-8. FILTERING OF SHORTENING Step Step
3-8. FILTERING OF SHORTENING Continued
3-8. FILTERING OF SHORTENING Continued Step 7b Step 7c Step 7f
When bubbling occurs, immediately close the filter valve. This prevents aeration of the shortening, therefore increasing shortening life
3-9. FILTER PUMP PROBLEM PREVENTION
6. Unthread the suction standpipe from the screen assembly
10. Fold the corners in and then double fold the open end
3-11. CLEANING THE FRYPOT
3-11. CLEANING THE FRYPOT Continued
DEADWEIGHTASSEMBLY cleaned as follows
TIONS FOR OPTIONAL DIRECT-CONNECT SHORTENING SYSTEM
3-13. OPERATING INSTRUC
Reversing the lid gasket helps to prevent early failure of lid gasket
3-14. REVERSING THE
LID GASKET
and the loss of pressure during a cook cycle
3-15. LID LUBRICATION
3-16. LIMIT STOP ADJUSTMENT Step Step
3-17. CLEANING THE SAFETY RELIEF VALVE
3-16. LIMIT STOP ADJUSTMENT Continued
3-18. CHECK & TIGHTEN ELEMENT SPREADER BARS Model 500 only
To Change Set-Point Temperatures
SECTION 4. PROGRAMMING
4-1. INTRODUCTION 4-2 TIME AND SET-POINT PROGRAMMING
To change Product Cooking Times
MODE
Inputs Status high limit, drain switch, fan switch, module
4-3. SPECIAL PROGRAM
4-3. SPECIAL PROGRAM MODE Continued
5-1. TROUBLESHOOTING GUIDE
SECTION 5. TROUBLESHOOTING
Problem
Cause
ERROR CODE TABLE
ERROR CODES
DISPLAY
CAUSE
Continued
3-2. ERROR CODE TABLE
DISPLAY
CAUSE
Model 500/600
GLOSSARY
gas fryers only
gas fryers only
gas fryers only
Model 500/600
level also referred to as level indictor lines
have three filter screens that include a crumb catcher
Model 500/600
fryers, the lid assembly includes spindles
gas fryers only
gas fryers only
gas fryers only
Model 500/600
gas fryers only
gas fryers only
Toll free in USA
Henny Penny Corporation P.O.Box Eaton,OH