DCS BFG-30G, BFG-308S, BFG-308GD manual Safety Practices & Precautions, Important Safety Notice

Page 5

SAFETY PRACTICES & PRECAUTIONS

IMPORTANT SAFETY NOTICE!

Certain Liquid Propane dealers may fill liquid propane cylinders for use in the outdoor appliance beyond cylinder filling capacity. This “Overfilling” may create a dangerous condition.

IMPORTANT SAFETY NOTICE!

Be sure to remove covers from grill, griddle or side burners before attempting to light or use.

“Overfilled” tanks can build up excess pressure. As a safety device, the tanks pressure relief valve will vent propane gas vapor to relieve this excess pressure. This vapor is combustible and therefore can be ignited. To reduce this danger, you should take the following safety precautions:

1.When you have your tank filled, be sure you tell the supplier to fill it to no more than 3/4 (75%) of its total capacity.

2. If you own or use a spare tank, or have a disconnected tank, you should NEVER store it near or under the outdoor appliance/cart unit or heat box, or near any other igni- tion or heat source. A metallic sticker with this warning is provided with the grill to remind you, your family and all others who may use your grill of these safety precautions. Install this sticker close to your barbeque grill.

3. Do not store a full tank in direct sunlight.

WARNING!

Do not try lighting this appliance without reading the “LIGHTING INSTRUCTIONS” section of this manual. This outdoor appliance is for outdoor use only.

WARNING!

Push and hold the igniter button, turn the selected burner knob to “HI” or “SEAR”. If burner does not light in 4 to 5 seconds turn knob “OFF” and wait minutes for any accumulated gas to dissipate before trying again.

STICKER

5

■Begin by insuring proper installation and servicing. Follow the installation instructions within this manual. Have your outdoor appli- ance installed by a qualified technician. Have the installer show you where the gas supply shut-off valve is located so that you know where to shut off the gas to the outdoor ap- pliance. If you smell gas, your installer has not done a proper job of checking for leaks. If the connections are not perfectly sealed, you can have a small leak and therefore a faint gas smell. Finding a leak is not a “do-it-yourself ” procedure. Some leaks can only be found with the burner control in the “ON” position and this must be done by a qualified technician.

•Always follow lighting instructions.

•Lid must be off before lighting the grill or side burners.

•Check for gas leaks before lighting.

•Never lean over an open grill when lighting. Serious burns may result.

WARNING

•Hot surfaces surrounding grill grates could cause serious burns.

•Always leave at least 12" clearance to combustibles around the grill.

•Never store a spare LP cylinder under or near this unit.

•Never fill the tank beyond 3/4 full. A fire causing death or serious injury may occur.

■Children should not be left alone or unattended in an area where the outdoor appliance is being used. Never allow them to sit, stand or play on or around the outdoor appliance at any time. When in use, portions of the outdoor appliance can get hot enough to cause severe burns.

■Do not store items of interest to children around or below the outdoor appliance, in the cart or masonry enclo- sure. Never allow children to crawl inside a cart or enclosure.

3

Page 4 Page 6
Image 5
Page 4 Page 6
Contents Professional Liberty Collection Page Please Retain this Manual for Future Reference Message to OUR CustomersContents Important Safety Notice Safety Practices & PrecautionsOutdoor Appliance Placement Safety Practices & Precautions Outdoor Appliance Models BFG-30G All-Grill Before Using Your ApplianceLocation InstallationLocating Outdoor APPLIANCE/BUILT-IN Clearances Insulated Jacket Locating BUILT-IN ClearancesGeneral Standard layout for non-combustible enclosure BUILT-IN Construction DetailsLocating the Cart Cart Assembly InstructionsStep Outdoor Appliance Head Preparation Pinch Point Cover Hanger Gas Hookup LPGAS Requirement GAS HOOK-UPLP Tank Requirements LP GAS Hook UP Type 1 or QCC1 Regulator18 max LP Tank Restraint for BUILT-IN InstallationStep Before Testing Leak Testing GRILL/GRIDDLE UnitBurner Adjustment Side Burner Leak Testing Side BurnerBurner Efficiency and Flame Characteristics Flame HeightOutdoor Appliance Burner Flame Height Burner Adjustment GRILL/GRIDDLE UnitLOW Setting Adjustment Radiant Assembly Installation Radiant AssemblySink Faucet InstallationSink Installation Side Shelf Optional accessory These Instructions Check ListUSE of the Grill Using the GrillLighting Instructions Grilling Hints Important Using the GrillMatch Lighting Using the Side BurnerBefore Using the Griddle for the First Time or To RE-SEASON Using the GriddleThermocouple USE of the GriddleUsing the Griddle Using the Sink Battery Replacement Care and MaintenanceRegulator and Hose Replacement Cleaning Grill GratesCeramic Rods Grill Burner CleaningStainless Steel Grill BurnerSide Burners Orifice CleaningSide Burner Grate Sink Side Burner ElectrodesControl Knobs Problem What to do Troubleshooting Outdoor ApplianceBefore Calling for Service Troubleshooting Side Burner HOW to Obtain Service ServiceLimited Warranty WarrantyHOW Long does the Limited Warranty LAST? This Warranty does not CoverNo Other Warranties HOW to GET ServiceCommercial USE Page LA Collection Professionnelle Liberty Veuillez Conserver CE Manuel À Titre DE Référence ’INTENTION DE NOS ClientsUtilisation DE LA Plaque Chauffante Table DES MatièresPage Mesures DE Sécurité ET DE Précaution Hauteur de Emplacement ’APPAREIL D’EXTÉRIEURRemaque Modèles D’APPAREILS D’EXTÉRIEUR BFG-30G Tout gril Avant D’UTILISER L’APPAREILEmplacement Emplacement DE L’APPAREIL D’EXTÉRIEUR ET DES DégagementsEnveloppe Isolée Emplacement DES DégagementsGénéralités Disposition standard pour une enceinte non combustible Détails D’UNE Construction IntégréeInstructions DE Montage DE Chariot Placement DE LA DesserteÉtape Préparation de la tête de l’appareil d’extérieur Points DE Pincement Accrochez Branchement du gaz PropanePour Connecter LES Raccords Fournis Avec LE Gril Branchement DU GAZExigences Concernant LE GAZ Exigences Concernant LA Bouteille DE Propane Branchement DU Propane Régulateur DE Type 1 OU QCC145,7 cm 18 po Max Placez le dispositif de retenue de bouteille dans l’îlot Fig Avant la vérification Réglage DES Brûleur Brûleur Latéraux Test DE Détection DES Fuites Brûleur LatérauxBrûleurs Efficacité DES Brûleurs ET Caractéristiques DE LA FlammeRéglages Pour Niveau BAS Hauteur DES Flammes DU Brûleur DU GrilInstallation DE L’ENSEMBLE DU Radiant Installation DE L’ENSEMBLE DU RadiantÉvier Installation DES RobinetsInstallation DE L’ÉVIER Tablette Latérale accessoire en option Veuillez Lais Liste DE Contrôle DE L’INSTALLATEURInstructions D’ALLUMAGE Utilisation DU GrilUtilisation DU Gril Conseils AU Sujet DU Gril Important Utilisation du grilAllumage À L’ALLUMETTE Utilisation DU Drûleur LatéralTableau DE Cuisson DE LA Plaque Chauffante Utilisation DE LA Plaque ChauffanteUtilisation DE LA Plaque Chauffante Utilisation DE LA Plaque Chauffante Utilisation DE L’ÉVIER Remplacement DU Régulateur ET DU Tuyau Remplacement DE LA PileEntretien ET Nettoyage Nettoyage DES Grilles DU GrilTiges EN Céramique Entretien ET MaintenanceAcier Inoxydable Brûleur DU GrilGrille DU Brûleur Latéral Nettoyage DE L’ORIFICEPlaque Chauffante Électrodes DE Brûleurs LatérauxBoutons DE Réglage ÉvierDépannage Appareil D’EXTÉRIEUR Avant D’APPELER LE Service TechniqueProblème Solution Dépannage Brûleur Latéral Pour L’OBTENTION DU Service DE Garantie Garantie Limitée GarantieFisher & Paykel S’ENGAGE À Quelle EST LA Durée DE LA Garantie LIMITÉE?Aucune Autre Garantie Pour Obtenir DES RéparationsUtilisation Commerciale Remarque Remarque Remarque Page Litho in USA 09/2001
Top Page Image Contents