DCS BFG-30G, BFG-308S, BFG-308GD manual Using the Grill, Lighting Instructions, USE of the Grill

Page 29

USING THE GRILL

LIGHTING INSTRUCTIONS

Note:

Remove the top grill cover before lighting. Turn all knobs to “OFF”. Turn the main gas supply on. If you smell gas, shut- off gas supply and call for service.

Grill Lighting Instructions:

The grill knob is connected to the electronic ignition module. Pushing in on the grill knob will activate the igni- tion module to get a spark. Push and hold the ignition button, turn the selected burner knob to “SEAR”. If burner does not light in 4 to 5 seconds, turn knob “OFF” and wait 5 minutes before trying again for any accumulated gas to dissipate.

Grill Match Lighting:

If the burner will not light after several attempts, then the burner can be match lit. If you’ve just attempted to light the burner with the ignition, allow 5 minutes for any accumulated gas to dissipate. Keep your face as far away from the outdoor appliance as possible and hold a paper book match over the hole located on the top left for burner on the left, or the right hole for the right burner (Fig. 52 and Fig. 53). Push and turn the control knob which is centered on the burner where the lit match is located, to “SEAR”. If the burner does not light in 4 sec- onds, turn the knob off, wait 5 minutes and try again.

Once the left or right burner is lit, the adjacent burner can be lit by the cross-lighting method. Light the left or right burner using the standard or match light procedure. Push and turn the control knob for the adjacent burner to “SEAR”. The gas will be ignited by the adjacent burners flame. If the burner does not light in 4 seconds, turn knob off, wait 5 minutes and try again.

Fig. 52Fig. 53

USE OF THE GRILL

 

 

Each grill section consists of a large stainless steel burner,

stainless steel heat baffles, a

 

series of ceramic rods encased in a stainless steel radiant tray, and a stainless steel heat

 

retaining grates. Each burner is rated at 25,000 Btu/hr. Below the burners there is a stain-

 

less steel heat baffle which reflects usable heat upward into the cooking area and reduces

 

temperatures of the drip pan below. Above the burners are stainless steel

 

radiant trays which encase the ceramic rods and protect the grill burner ports from block-

 

Fig. 54

age (Fig. 54).

 

The grill is supplied with radiant ceramic rods. Because of the porosity of ceramic rods,

performance is superior in the rods’ ability to capture heat as it rises from the grill burners. They also possess the thermal mass needed for results. Flare ups are controlled because our radiant ceramic rods keep grease from get- ting to the flames and igniting. The intense heat produced by this system produces true outdoor-cooked flavor as fats and juices are brought to the surface of the food and caramelized. Discoloration is normal after use.

27

Page 28 Page 30
Image 29
Page 28 Page 30
Contents Professional Liberty Collection Page Please Retain this Manual for Future Reference Message to OUR CustomersContents Important Safety Notice Safety Practices & PrecautionsOutdoor Appliance Placement Safety Practices & Precautions Outdoor Appliance Models BFG-30G All-Grill Before Using Your ApplianceLocation InstallationLocating Outdoor APPLIANCE/BUILT-IN Clearances Insulated Jacket Locating BUILT-IN ClearancesGeneral Standard layout for non-combustible enclosure BUILT-IN Construction DetailsLocating the Cart Cart Assembly InstructionsStep Outdoor Appliance Head Preparation Pinch Point Cover Hanger Gas Hookup LPGAS Requirement GAS HOOK-UPLP Tank Requirements LP GAS Hook UP Type 1 or QCC1 Regulator18 max LP Tank Restraint for BUILT-IN InstallationStep Before Testing Leak Testing GRILL/GRIDDLE UnitBurner Adjustment Side Burner Leak Testing Side BurnerBurner Efficiency and Flame Characteristics Flame HeightOutdoor Appliance Burner Flame Height Burner Adjustment GRILL/GRIDDLE UnitLOW Setting Adjustment Radiant Assembly Installation Radiant AssemblySink Faucet InstallationSink Installation Side Shelf Optional accessory These Instructions Check ListUSE of the Grill Using the GrillLighting Instructions Grilling Hints Important Using the GrillMatch Lighting Using the Side BurnerBefore Using the Griddle for the First Time or To RE-SEASON Using the GriddleThermocouple USE of the GriddleUsing the Griddle Using the Sink Battery Replacement Care and MaintenanceRegulator and Hose Replacement Cleaning Grill GratesCeramic Rods Grill Burner CleaningStainless Steel Grill BurnerSide Burners Orifice CleaningSide Burner Grate Sink Side Burner ElectrodesControl Knobs Problem What to do Troubleshooting Outdoor ApplianceBefore Calling for Service Troubleshooting Side Burner HOW to Obtain Service ServiceLimited Warranty WarrantyHOW Long does the Limited Warranty LAST? This Warranty does not CoverNo Other Warranties HOW to GET ServiceCommercial USE Page LA Collection Professionnelle Liberty Veuillez Conserver CE Manuel À Titre DE Référence ’INTENTION DE NOS ClientsUtilisation DE LA Plaque Chauffante Table DES MatièresPage Mesures DE Sécurité ET DE Précaution Hauteur de Emplacement ’APPAREIL D’EXTÉRIEURRemaque Modèles D’APPAREILS D’EXTÉRIEUR BFG-30G Tout gril Avant D’UTILISER L’APPAREILEmplacement Emplacement DE L’APPAREIL D’EXTÉRIEUR ET DES DégagementsEnveloppe Isolée Emplacement DES DégagementsGénéralités Disposition standard pour une enceinte non combustible Détails D’UNE Construction IntégréeInstructions DE Montage DE Chariot Placement DE LA DesserteÉtape Préparation de la tête de l’appareil d’extérieur Points DE Pincement Accrochez Branchement du gaz PropanePour Connecter LES Raccords Fournis Avec LE Gril Branchement DU GAZExigences Concernant LE GAZ Exigences Concernant LA Bouteille DE Propane Branchement DU Propane Régulateur DE Type 1 OU QCC145,7 cm 18 po Max Placez le dispositif de retenue de bouteille dans l’îlot Fig Avant la vérification Réglage DES Brûleur Brûleur Latéraux Test DE Détection DES Fuites Brûleur LatérauxBrûleurs Efficacité DES Brûleurs ET Caractéristiques DE LA FlammeRéglages Pour Niveau BAS Hauteur DES Flammes DU Brûleur DU GrilInstallation DE L’ENSEMBLE DU Radiant Installation DE L’ENSEMBLE DU RadiantÉvier Installation DES RobinetsInstallation DE L’ÉVIER Tablette Latérale accessoire en option Veuillez Lais Liste DE Contrôle DE L’INSTALLATEURInstructions D’ALLUMAGE Utilisation DU GrilUtilisation DU Gril Conseils AU Sujet DU Gril Important Utilisation du grilAllumage À L’ALLUMETTE Utilisation DU Drûleur LatéralTableau DE Cuisson DE LA Plaque Chauffante Utilisation DE LA Plaque ChauffanteUtilisation DE LA Plaque Chauffante Utilisation DE LA Plaque Chauffante Utilisation DE L’ÉVIER Remplacement DU Régulateur ET DU Tuyau Remplacement DE LA PileEntretien ET Nettoyage Nettoyage DES Grilles DU GrilTiges EN Céramique Entretien ET MaintenanceAcier Inoxydable Brûleur DU GrilGrille DU Brûleur Latéral Nettoyage DE L’ORIFICEPlaque Chauffante Électrodes DE Brûleurs LatérauxBoutons DE Réglage ÉvierDépannage Appareil D’EXTÉRIEUR Avant D’APPELER LE Service TechniqueProblème Solution Dépannage Brûleur Latéral Pour L’OBTENTION DU Service DE Garantie Garantie Limitée GarantieFisher & Paykel S’ENGAGE À Quelle EST LA Durée DE LA Garantie LIMITÉE?Aucune Autre Garantie Pour Obtenir DES RéparationsUtilisation Commerciale Remarque Remarque Remarque Page Litho in USA 09/2001
Top Page Image Contents