Electrolux SG 424 Pressure Testing, Checking The Grill, Checking The Hotplate

Page 46
FIT A 3 AMP FUSE TO THE PLUG HOLDER.

If the wiring is extended or a completely new cable fitted a 3-pin 13 amp plug should be fitted. (See Fig.5). Connect the wires as follows:

BROWN to the Live Terminal.

BLUE to the Neutral Terminal.

GREEN and YELLOW to the Earth Terminal.

As the colours of the wires in the mains lead which you fit may not correspond with the coloured markings identifying the terminals in your plug, proceed as follows:

The wire which is GREEN and YELLOW must be connected to the terminal in the plug which is marked with the letter 'E'

or by the earth symbol or coloured GREEN or GREEN

and YELLOW.

Fig.5

The wire which is coloured BLUE must be connected to the

 

terminal which is marked with the letter 'N' or coloured

 

BLACK.

 

The wire which is coloured BROWN must be connected to the terminal which is marked with the letter 'L' or coloured RED.

FIT A 3 AMP FUSE TO THE PLUG HOLDER.

Ensure that the supply cable cannot get caught by the stability bracket. Plug in the appliance.

6. PRESSURE TESTING

1The oven injector is used as a pressure test point.

Remove the oven furniture. Remove oven burner box retaining clips (one spring clip from each side) and remove box front cover. Replace one clip back into the right hand side of the burner box.

Remove oven burner by removing the spring clip from the right hand side of the oven burner and slide burner off injector, whilst easing it forward and taking care not to strain the F.S.D. phial.

2.Connect the pressure gauge to the oven injector.

3.Check the supply pressure by turning the thermostat on and one hotplate tap full on and light the appropriate burner. The pressure should be either:-

(i)For Natural Gas 20mbar

(ii)For LP.GasThe pressure must be set to 28 mbar for use on butane or 37mbar for use on propane.

4.Turn off the taps, disconnect the pressure gauge and replace oven burner and cover, ensuring that the F.S.D. phial is correctly located into the bracket on the burner.

5.Check operation of oven.

7. CHECKING THE GRILL

Place the grill pan containing the grid, with the handle attached, into the grill compartment. Light the grill burner by turning the grill tap full on and pressing the ignition button on the fascia panel. As soon as the burner is lit the button can be released.

8. CHECKING THE HOTPLATE

Lift the lid. Fit the burner crowns and caps ensuring that they are correctly seated. Fit the pan supports. Check each of the hotplate burners in turn by turning the hotplate tap to it's full on position and pressing the ignition button. As soon as the burners are lit the button can be released.

9.CHECKING LID CUT-OFF DEVICE

1.Lift the lid.

2.Turn on and ignite hotplate burner.

3.Close lid. There should be no gas supply to the hotplate and the burner will go out.

4.Turn off the hotplate tap.

5.Lift the lid. The gas supply should now be restored to the hotplate when the tap is turned on.

46

Page 45 Page 47
Image 46
Page 45 Page 47
Contents Operating and Installation Instructions S G 4 2 For your safetyIntroduction RATING PLATEContents ContentsLighting the appliance Lighting the applianceHotplate To lightGrill Grill/second ovenSecond oven To turn off any burner Main ovenOven light Heat control Prior to using the grillThe grill The grillPreheating Cooking positionsGeneral Putting food on the gridThe grill pan and handle The hotplate The hotplateBurner sizes Largest burner Rapid - use a large pan for food such as chipsFor your safety Helpful hints Oven shelves The ovensHeat zones The ovensBaking trays and dishes Roasting CondensationOven cooking chart - Main oven Oven cooking chartYorkshire pudding Turkey below 4.5kg 10lbsRich fruit 0.90kg 2lb loaves and have no rim underneath, place onBread 0.45kg 1lb loaves To help pastry brown on the undersideOven cooking chart - Second oven 3½-4½ hours Rich fruit, 180mmBaked sponge pudding electronic minute minder THE ELECTRONIC MINUTE MINDER1. TO SET THE TIME OF DAY The bell symbol will show in the display The electronic minute minder2. TO USE THE MINUTE MINDER If you change your mind and want to cancel the minute minderSlow cooking Slow cookingFood preparation-slow cooking Joints of meat and poultryMilk puddings S G 4 2 Soups, casseroles and stewsVegetables General points for slow cooking Frozen foodsCleaning the brass plated handles and control knobs Where applicable Care and cleaning1. Crown to body Do not try to force the crown on to the body When replacing hotplate burner partsThe hotplate 2. Cap to crownThe grill The grill and top ovenThe Main Oven Main Oven cleaning cycle To carry out a cleaning cycle 1. Remove the oven shelvesCleaning between the outer and inner door glass To remove the outer glassInstallation Cleaning The Door GlassInstalling the appliance LocationAppliance dimensions PositioningMoving your appliance General information For your safetyConnecting to the electricity supply General informationReplacing the oven light bulb Having difficulty cleaning any part of the appliance What is wrong and why?Problem CheckThe ovens are not cooking evenly S G 4 2 ProblemThe oven light will not work Servicing Service and spare parts0 8 7 0 5 9 2 9 9 2 Customer Care Department The Gas Consumers CouncilINSTALLATION INSTRUCTIONS Serial number at front. Rating Plate on top rear of panelCONNECTIONS TECHNICAL DATADIMENSIONS GRILLSECOND OVEN IMPORTANT - SAFETY REQUIREMENTSMAIN OVEN GENERAL100 less than 400 All dimensions in mmLOCATION OF APPLIANCE Fig.1a2. LEVELLING THE APPLIANCE INSTALLATION1. PARTS REQUIRED 3. FITTING THE STABILITY BRACKET4. CONNECTING TO GAS 5. CONNECTION TO THE ELECTRICITY SUPPLY8. CHECKING THE HOTPLATE 6. PRESSURE TESTING7. CHECKING THE GRILL 9. CHECKING LID CUT-OFF DEVICE12. CHECKING THE MAIN OVEN LIGHT 10. CHECKING THE MAIN OVEN11. CHECKING THE SECOND OVEN 13. TO SET THE TIME OF DAY14. MINUTE MINDER OPERATION GENERAL NOTEN O T E S SG 424 Contents Check List PARKINSON COWAN 55 - 77 HIGH STREET SLOUGH BERKSHIRE SL1 1DZ IMPORTANT NOTICETELEPHONE 0870 5 Part Number311684200
Top Page Image Contents