Frymaster 47 Series operation manual This page Intentionally Left Blank

Page 43

THIS PAGE INTENTIONALLY LEFT BLANK

Image 43

Contents Series Gas Fryers Hour Service HotlineCanada Page Series GAS Fryers Table of Contents Retain and Store this Manual in a Safe Place for Future USE Parts Ordering and Service InformationSeries GAS Fryers General Information Applicability and ValidityEuropean Community CE Specific Information Safety InformationEquipment Description Definitions Installation, Operating, and Service PersonnelWhat to do if your equipment arrives damaged Shipping Damage Claim ProcedureGeneral Installation Requirements Series GAS Fryers Installation InstructionsClearance and Ventilation Electrical Grounding Requirements National Code RequirementsFCC Compliance Caster/Leg InstallationPage CE Standard For Incoming Gas Pressures Non-CE Standard For Incoming Gas PressuresCE Standard CE Standard Burner Manifold Gas Pressures Page Honeywell Gas Valves Converting to Another Gas TypeDual-Vat Non-CE Gas Conversion Kits Robertshaw Gas ValvesCE and Non-CE Gas Conversion Instructions Series GAS Fryers Operating Instructions Accessing the PilotLighting the Pilot on NON-EUROPEAN NON-CE Fryers Pilot Button OFF Button Boiling-Out the Frypot Placing the Fryer Into OperationFor units equipped with Thermostat Controls For units equipped with other than Thermostat ControlsPage Controller Operation and Programming Series GAS Fryers Filtration Instructions Page Page Snap the Power Shower into the frypot Page Page Weekly Checks and Services Series GAS Fryers Preventive MaintenanceFryer Preventive Maintenance Checks and Services Daily Checks and ServicesDrain and Clean Frypot Quarterly Checks and ServicesClean Detachable Parts and Accessories Check Thermostat Controller Thermostat Calibration Clean Gas Valve Vent TubeCheck Computer Magic III Set Point Accuracy Check Burner Manifold Pressure SEMI-ANNUAL Checks and ServicesFryer Built-In Filtration System Page Introduction Series GAS Fryers Operator TroubleshootingProblem Probable Causes Corrective Action Problem Troubleshooting Fryers with Thermostat ControlsProbable Causes Corrective Action Troubleshooting the Built-In Filtration System Troubleshooting Abnormal Burner OperationVery slow Pump starts, but noTransfer takes place Or the transfer isSpraying properly Power Shower is notReplacing the Controller or Controller Wiring Harness This page Intentionally Left Blank Service Hotline