Alto-Shaam QC-3/QC-20/QC-40/QC-50/QC-50 Remote/QC-100/Qc-100 Remote Installation Requirements

Page 6

I N S T A L L A T I O N

SITE INSTALLATION

INSTALLATION REQUIREMENTS

The model QC-3 is a counter mounted unit and must be sealed to the counter with a NSF listed silicone sealant.

For all other

models, install

the appliance on a smooth and

level floor surface. Use the adjustable cabinet legs to level the Quickchiller.

Adjust from front-to-back and from side-to-side with the use of a spirit level to evenly distribute the cabinet weight and avoid pulling the cabinet alignment out of square.

After leveling the cabinet of cart equipped models, check the height relationship of the roll-in cart

to the cabinet. Adjust the Quickchiller height as needed to accommodate the cart and to securely close the Quickchiller door(s).

DOOR SEAL:

Check the door gasket to make certain it is sealing properly and that the gasket provides an even and positive seal around the entire door frame.

C A U T I O N

TO PREVENT PERSONAL INJURY,

USE CAUTION WHEN MOVING OR

LEVELING THIS APPLIANCE.

WATER DRAINAGE

DRAINAGE:

QC-3

QC-20

QC-40

 

 

 

EVAPORATOR PANS: NO INSTALLATION REQUIRED

QC-50

QC-100

 

 

ONE (1) FLOOR DRAIN: 1/2" (12,7mm) DIAMETER

A 1/2" I.D. (12,7mm) PVC pipe is furnished with each QC-50 and QC-100 model. Use PVC glue to attach the pipe into the drain opening at the rear of the unit. Insert the PVC pipe into the drain opening with a 1/4" (6mm) clockwise turn. Connect the PVC pipe to discharge through an indirect waste pipe into an open-site drain by means of a 2" (51mm) air gap. Connection must be within 10' (3m) of the unit.

NOTE: In the U.S.A., this equipment is to be installed to comply with the Basic Plumbing Code of the Building Officials and Code­ Administrators International, Inc. [BOCA], and the Food Service Sanitation Manual of the Food & Drug Administration [FDA].

drain opening

at rear

QUICKCHILLER • INSTALLATION/OPERATION/SERVICE MANUAL • 4 .

Page 5 Page 7
Image 6
Page 5 Page 7
Contents Installation Wire Diagrams L I V E R Y P a C K I N GSafety Procedures Precautions N G E RSite Installation InstallationInstallation Unit must not be tipped on its side At any timeDoor Seal Installation RequirementsWater Drainage DrainageTrolley Guide Installation Trolley Guide InstallationSiteub Titleinstallation S Ttailtllaet I O NQC-3 1626mm x 1143mm x 1143mm S Ttailtllaet I onQC-20 R404a Refrigerant404a Refrigerant QC-4044 x 47 x 79 1118mm x 1194mm x 2007mm Approximately 144 lb 65 kg maximumQC-50 QC-50 Remote QC-100 QC-100 RemoteQC-3 QC-20 QC-40 QC-50 QC-100 Optionssub Titleand AccessoriesModel Casters, 5 127mm208-240VAC 50/60 Hz Electrical SpecificationsElectricalsub Title 380-415VAC 50/60 HzTraditional COOK-SERVE Kitchens Etritaltei O NOperating Introduction Modified COOK-CHILL OperationsChill Processing Cycles Quickchiller Operation ModesInitial Quickchiller Operation FAN Operation Power OutageAdditional Information DoorControl Panel Identification Basicsub Titleoperation Manual OperationWhen in the Hold Temp Mode After a Chill Mode Advancedsub Title OperationHold Temp Chilling by Time Factory Default SET PointsWhen in the Hold Temp Mode After Chilling by Probe Chilling by ProbePreset Selections Preset Program OperationProgramming Presets E R a T I O NUser Settings Operationt I T L EUser Information Time & Temperature GuidelinesFood Probe USE Automatic DefrostFoodsub Titlehandling Guidelines Product CoveringPortioning & Packaging Product Capacity PER PAN Quickchiller PAN CapacityI C K C H I L L E R P a N C a P a C I T Y C H a R T D I V I D U a L P a N C a P a C I T I E SStarches PAN Size ›Breakfast Items DessertsCleaning Agents Care Andti T CleaningeCleaning and Preventive Maintenance Cleaning MaterialsFood Trolley Cleaning Interior CleaningExterior Cleaning Monthly Compressor & Condenser MaintenanceO U B Lteitslheo O T I N G Etritvlice E Model QC-3 ControlEtritvlice E Model QC-3 CoilModel QC-20 Control Model QC-20 Coil Model QC-20 Condenser Model QC-40 Model QC-40 Control Model QC-50, QC-100 Control Model QC-100 Coil Model QC-50, QC-100 Breaker Model QC-50, QC-100 FANModel QC-50 Remote Model QC-50, QC-100 Remote Remote condensor connectionModel QC-3 Wiring Model QC-20 Wiring Model QC-40 Wiring Model QC-50 Wiring 1PH 3PH Model QC-100 Wiring 1PH 3PH Page Page Page Page Page Page Page Page Page Page Page Page Page Limited Warranty
Top Page Image Contents