Falcon U109988 - 02 manual To Remove Grill Element, To Replace an Oven Door

Page 25

WARNING – SERVICING TO BE CARRIED OUT ONLY BY AN AUTHORISED PERSON

Disconnect from electricity before servicing. Check appliance is safe when you have finished.

9.To Remove the Grill Door

Remove the control panel (see 1). Remove the left-hand side panel (see 2). Remove the centre cover strip (5 screws, 2 top, 2 bottom, 1 in middle). Remove the two countersunk screws (1 each side) securing the grill hinge arms to the front of the grill chamber.

Note: The arms are spring tensioned. Carefully remove the grill door. Retain the gaskets.

Reassemble in reverse order ensuring that the gasket is fitted between the hinge arm and the front of the grill chamber.

10.To Remove Grill Element

Disconnect from electricity supply.

Remove grill pan from inside the grill compartment; remove the enamelled front shield from the grill roof, by undoing the two screws and washers.

Fig.7-1

ArtNo.216-0009 - Elan removing the handles

Fig.7-2

Fig.7-3

�

�

Remove the two screws and washers securing the grill element front support. Remove the screws from the grill element.

Lift the element out carefully, disconnecting the leads from the element terminals (noting their position). If it is not possible to disconnect the leads in this way, pull the cooker forward to gain access to the rear, remove the screws securing the electric cover to the back sheet, remove the cover and disconnect the terminals from the rear.

Fit the new element and reassemble in reverse order. Check the operation of the grill.

11.To Replace an Oven Door

Open the oven door. Support the door and remove the two screws securing the upper hinge and gasket to the cooker front (Fig.7-2).Remove the door from the lower hinge by lifting slightly and moving outwards (Fig.7-3).

The door is heavy, so take care.

Reassemble in reverse order.

12.To Adjust an Oven Door Angle

The bottom hinge of either oven door can be adjusted to alter the angle of the door (Fig.7-4). Loosen the bottom hinge fixing screws and use the notch and a flat bladed screwdriver to move the position of the hinge to set the hinge position (Fig.7-5).

Retighten the hinge screws.

13.To Replace an Oven Door Outer Panel

Move the cooker forward to gain access to the sides.

Open the oven door slightly and remove the front panel fixing screws from the door sides – two each side (Fig.7-6).

Carefully lift off the outer door panel.

Remove the two plastic blanking plugs from the door handle. Remove the door handle from the panel by unscrewing the two retaining nuts. Fit the door handle to the new panel and refit the two blanking plugs to the fixing holes.

Note: If replacing the outer panel on the right-hand door (with the Thermodial), take care to make sure the sensor of the Thermodial is sealed to the door by the rubber grommet (Fig.7-7).

Fit the panel to the door. Reassemble in reverse order.

ArtNo.320-0001 Door hinges

ArtNo.320-0001 Door hinges

Fig.7-4

ArtNo.320-0006 Oven door hinge adjustment 1

Effect of hinge adjustment - exagerrated for clarity

Centreline of hinge pin

Fig.7-5

ArtNo.320-0007 Oven door hinge adjustment 2

Oven door omitted for clarity

Fig.7-6

ArtNo.320-0002c

- Oven door side screws (Elan)

23

Page 24 Page 26
Image 25
Page 24 Page 26
Contents User Guide Contents Personal Safety Installation and MaintenanceBefore You Start VentilationHob Care CleaningCooker Care  do not use the hob surface as a cutting boardHob Cooker OverviewPan Detector Residual Heat Indicator, HAutomatic Heat-up, a Child Lock, L Glide-out GrillPan Protection Function 0Fig.2-8Ovens  Never close the grill door when the grill is onLeft-Hand Multi-function Oven Multi-function oven functionsFanned grilling Fan ovenFan assisted oven Conventional oven top and base heatOperating the Ovens Right-hand tall ovenTo start and then stop the left-hand oven using the Timer Setting the time of dayClock Minute MinderAuto is showing, but you want to revert to manual cooking AccessoriesKey Lock Oven Shelves Left-hand Main OvenOven shelves Right-hand Tall Oven Main Oven LightHandyrack Main Oven Cooking Tips Tips on Cooking with the TimerGeneral Oven Tips Cleaning Spills Cleaning Your CookerCleaning Burned-on Spills Daily CareControl Panel and Doors ‘Cook & Clean’ PanelsTall Oven Removing the Panels to clean the Enamel InteriorTroubleshooting Timed oven is not coming on when automatic cooking Timed oven is not coming on when turned on manuallyOven temperature getting hotter as the cooker gets older Food is cooking too slowly, too quickly, or burningDear Installer InstallationSafety Requirements Provision of VentilationUnpacking the Cooker Positioning the CookerMoving the Cooker Repositioning the Cooker following Connection Completing the MoveLevelling Fitting the HandlesElectrical Connection Fitting the Splashback optionalHob Check Grill CheckServicing To Remove Grill Element To Adjust an Oven Door AngleTo Replace an Oven Door  The door is heavy, so take careTo Replace the Tall Oven Door Outer Panel To Adjust the Main Oven Door Catch KeepTo Change the Main Oven Door Latch To Replace an Oven Door SealTo Remove the Left-hand Oven Bottom and Top Elements To Replace an Oven FanTo Change Oven Light Bulb Key Circuit Diagram OvenCode Description Colour Code Circuit Diagram Hob Dimensions Technical DataConnections Français Avant de commencer… Installation et EntretienOdeur de neuf Sécurité personnelleNettoyage Français Conseils relatifs à la table de cuissonTable de cuisson Vue d’ensemble de la CuisinièreIndicateur de chaleur résiduelle, H Détection de récipient de cuissonTableau Verrouillage sécurité enfants, L Chauffage automatique, aProtection de récipient de cuisson Fours Gril Coulissant Glide-outFour gauche Fonctions du four multifonctionsGril ventilé Four ventiléFour ventilé mixte Fonctionnement des fours Four droitRéglage de l’heure HorlogeMinuterie Arrêt automatique du four gaucheGrilles de four Four gauche four principal Fonction de verrouillageActivation de la fonction de verrouillage Désactivation de la fonction de verrouillageGrilles de four Four droit four haut Eclairage du FourHandyrack Conseils généraux pour la cuisson au four Conseils pour la CuissonInformations importantes Nettoyage de la CuisinièreEntretien Quotidien Nettoyage des Déversements AccidentelsNettoyage des Déversements Brûlés Gril CoulissantFour Haut Panneau de Commande et PortesPanneaux autonettoyants Dépannage Le four ne s’allume pas La cuisson au four n’est pas uniforme’éclairage du four ne fonctionne pas Emplacement de la Cuisinière ’intention de l’installateurPrescriptions de Sécurité Positionnement de la CuisinièreDéballage de la Cuisinière Déplacement de la CuisinièrePositionnement Final Abaissement des Deux Galets ArrièreRepositionnement de la Cuisinière après Raccordement Mise à NiveauRaccordement Électrique Montage des poignéesContrôle de la Table de Cuisson Contrôle du grilEntretien Remplacement d’un élément de table de cuissonRemplacement d’un thermostat Remplacement de l’interrupteur d’éclairageRemplacement d’un regulateur de gril Remplacement d’une porte de fourRemplacement d’un joint de porte de four Remplacement du verrouillage de porte principale de four19. Dépose d’un protecteur thermique d’element de four 20. Dépose de la partie arriere interne du four Remplacement de l’ampoule d’éclairage du four21. Dépose de l’element du four ventile 22. Dépose du ventilateur du fourLégende Schéma de câblage FoursCode Elément Couleur Schéma de câblage Table de cuisson Raccordments Fiche techniquePuissances ElectricitéArtNo.000-0001 Aga address block
Top Page Image Contents