Discharge Line | Hoshizaki KM-901MWH, KM-901MAH, KM-901MRH/3

3. KM-901MRH/3 (remote air-cooled)

Condenser

Inlet Water Valve

Water Supply

Cleaning Valve

Float Switch

Fan

Headmaster (C.P.R.)

Spray Tubes

Access

Valve

Drier

Receiver

Tank

Evaporator

Thermistor		Liquid Line
		Valve
		Suction Line
		Access Valve
Water Pump
Water		Access
		Access
		Valve
Tank		Valve
Tank
		Discharge Line
		Discharge Line

High Pressure Switch

Strainer

Hot Gas

Valve

Check

Valves

Drain

Compressor

Freeze Pump-Out

Expansion Valves

Refrigeration Circuit	Check Valve
Water Circuit

39

Image 39

Hoshizaki KM-901MWH, KM-901MAH, KM-901MRH/3 service manual Discharge Line

Contents

KM-901MAH KM-901MWH Hoshizaki AMERICA, INC Contents Page Page Unit Important Safety InformationSerious injury Indicates important information about the use and care 1a. KM-901MAH air-cooled Auxiliary Code T-0, U-0 Specifications Icemaker 1b. KM-901MAH air-cooled Auxiliary Code U-1 and Later Water Cooled Condenser 2a. KM-901MWH water-cooled Auxiliary Code T-0, U-0 2b. KM-901MWH water-cooled Auxiliary Code U-1 and Later 3a. KM-901MRH remote air-cooled Auxiliary Code T-0, U-0 3b. KM-901MRH remote air-cooled Auxiliary Code U-1 and Later 4a. KM-901MRH3 remote air-cooled Auxiliary Code T-0, U-0 4b. KM-901MRH remote air-cooled Auxiliary Code U-1 and Later Condenser Unit Model URC-9F Specifications KM-901MAH air-cooled II. General Information Construction KM-901MWH water-cooled KM-901MRH/3 remote air-cooled Sequence of Operation Sequence Cycles and ShutdownControl Board Auxiliary Code T-0, U-0 Control Board Auxiliary Code U-1 and Later Shutdown OFF Cycle at Shutdown Mechanical Bin Control Activation Bin Full Control Board Sequence Flow ChartSequence Flow Chart Cycle Fill Cycle Control Board Auxiliary Code U-1Later Minute Harvest Cycle Freeze Cycle Pump-Out Cycle Control Board Control Board Control Board Layout Part Number 2A3792-01 Maximum Water Supply Period 6 minutes Harvest Backup Timer and Freeze TimerHigh Temperature Safety Low Water Safety Energized Time LEDs are On Components Min Max Avg LED Lights and Audible Alarm SafetiesNo. of Beeps Type of Alarm Every 3 sec Sequence Step Control Board Auxiliary Code U-1 and Later S4 Dip Switch S4 Dip Switch No Controls and AdjustmentsDefault Dip Switch Settings Harvest Timer S4 dip switch 1 Pump-Out Timer S4 dip switch 3 Pump-Out Frequency Control S4 dip switch 5S4 Dip Switch Setting Time seconds Inlet Control Board S4 Dip Switch Setting Pump Motor Time seconds Bin Control Selector/Harvest Pump Timer S4 dip switchFactory Use S4 dip switch Control Board S4 Dip Switch Setting Bin Control S4 Dip Switch Setting Time Minutes Freeze Timer S4 dip switch 9Float Switch Control S5 dip switch 1 G Control Board Refill Counter S5 dip switch 2 through 5 G Control Board Thermistor Float SwitchControl Switch Bin Control Water Pump Switch Discharge Line Wiring Diagrams ModelCooled-AirWater-Cooled Model PressureHigh* SwitchKM-901MAH air-cooled and KM-901MWH water-cooled PressureSwitch KM-901MRH remote air-cooledHigh KM-901MRH3 remote air-cooled Cooled-AirModel High* Pressure Switch Cooled-WaterModel High Pressure Switch SwitchPressure Performance Data 1570 912835 1480 KM-901MRH remote air-cooled KM-901MRH3 remote air-cooled Diagnostic Procedure IV. Service DiagnosisPage OFF Shutdown Thermostatic Bin Control Auxiliary Code T-0, U-0 Control Board Check Control Correct LED Board Lighting Sequence Bin Control Check Mechanical Bin Control Check Mechanical Bin Control Cleaning Float Switch Check Float Switch Check and Cleaning Float Switch Cleaning Thermistor Check Diagnostic Charts Problem Possible Cause RemedyNo Ice Production Problem Possible Cause Remedy Problem Possible Cause Remedy Evaporator is Frozen Up Problem Possible Cause Remedy Low Ice Production Abnormal Ice Other Removal and Replacement of Components Service for Refrigerant LinesRefrigerant Recovery Evacuation and Recharge R-404A Brazing Removal and Replacement of Compressor Removal and Replacement of Expansion Valve Page Removal and Replacement of Evaporator Removal and Replacement of Air-Cooled Condenser Removal and Replacement of Water-Cooled Condenser Removal and Replacement of Remote Air-Cooled Condenser Page Adjustment of Water Regulating Valve water-cooled model Removal and Replacement of Thermistor Removal and Replacement of Inlet Water Valve Removal and Replacement of Pump Motor Removal and Replacement of Control Board Cleaning and Sanitizing Instructions VI. Cleaning and Maintenance Cleaning Procedure Sanitizing Procedure Following Cleaning Procedure Preparing the Icemaker for Long Storage Maintenance Drain the water tank