Evaporator in Freezer, Freezer Thermistor

Mechanical Disassembly

Evaporator in Freezer

Evaporator is located in the bottom of freezer to produce cold air driven across the evaporator coils.

1.Take off the ductwork in Freezer.

2.Disconnect the wire connector (Heater, Bimental, and Thermistor).

3.Desolder the inlet and outlet tubes.

4.Remove the evaporator.

5.Take the same steps to seal the system as mentioned earlier.

Accumulator

Bimetal

Thermal

Fuse

Thermistor

Freezer Thermistor

The freezer thermistor is located at the top left of freezer vent. It sends temperature signals to the micro-processor.

Freezer Thermistor

Ambient Thermistor

The ambient thermistor is located inside the upper hinge cover. It sends temperature signals to the micro-processor.

Ambient

Thermistor

Ice-MakerThermistor

The Ice-Maker thermistor is located in its bottom. The temperature signal sends the micro-processor.

Thermistor(Ice-Maker)

Page 21

Image 21

Samsung RS2666, RS2544, RS2622, RS2777 Evaporator in Freezer, Freezer Thermistor, Ambient Thermistor, Ice-MakerThermistor

Contents

Model RS2544 RS2622 RS2644 RS2666 RS2777 Important Safety Notice Contents Multi-Flow System Door AlarmXtra SpaceTM Xtra FreshTM To protect refrigerator in movement Cover using a screwdriver, and then disconnectWith the door closed, remove the upper hinge It does not fall on you Models NomenclatureCompany Name Product R Refrigerator Label Location Freezer Refrigerator Specifications Warranty information Shelves and Bins Interior Views and DimensionsFreezer Refrigerator Dimensions of Refrigerator Inches Refrigerant Route in Refrigeration cycle Refrigeration Cycle and Cool Air Circulation RouteFreezer Evaporator Dryer Capillary Tube Cool Air Circulation Freezer Refrigerator Refrigerator Disassembly Mechanical DisassemblyFreezer Disassembly PlasticWire Drawer in Freezer······························ Door Handle Control PanelBeverage StationTM Door Gasket Refrigerator Light Refrigerator Door Light SwitchTempered Glass Shelf Plastic Drawers in Refrigerator Upper Ductwork Water FilterEvaporator Cover in the Refrigerator Evaporator Fan Motor Refrigerator Thermistor Evaporator in RefrigeratorCoolSelect ZoneTM Thermistor CoolSelect ZoneTM Thermistor Plastic Wire Drawer in Freezer Freezer Door Light SwitchDoor Bin in Freezer Freezer Shelf Disconnect the ice maker wire connector Ice maker is located inside of the ice dispenser assemblyAuger Motor Case Unlock the locking tabs to separate the ice maker kit Evaporator Cover in Freezer Freezer Light Freezer Thermistor Evaporator in FreezerAmbient Thermistor Ice-MakerThermistor Water Solenoids Machine Compartment ＆ Electric BoxCondenser Fan Sub-condenser Operation Function Digital Panel Temperature Control Function Quick Ice and Power Cool Functions Power FreezeQuick Ice functionChild Lock Function Fan Motor Delay Function of the Machine Compartment Ice & Water Dispenser FunctionCoolSelect ZoneTM Function RS2666,RS2777 Water Filter Indicator Function Filter IndicatorIce-Maker Function Initial Operation function Preparation of Ice-makerJudgement Remark ·MICOM Port Defrost Function Water Supply functionHeater on Heater OFF Defrost operation Self-Diagnostics Function Beeps will cease immediately when the doors are closedSelf-Diagnostics in the initial Power on Sound Function Error items of self-diagnostics ErrorFunction error Error items LED Display Details Remarks This mode, only the display LEDs for temperature will be on Restoration Function for Power OutageLoad Operation Check Function Set Point Shift Function Table of Set Point Shift Function Shift the freezer temperature sensor Operation Function Shift the Ice maker temperature sensor Shift the CoolSelect ZoneTM temperature sensor Circuit Descriptions Reset Circuit Source Power CircuitOscillator Circuit Terminal Door S/W Sensing Circuit Temperature Sensing CircuitMicom Change DEF-sensor and Bimetal work in parallel Key Scan and Display CircuitKey Scan and display operation Key Scan CoolSelect ZoneTM Panel Circuit Fan Motor Bldc Drive Circuit Motor drive circuitVoltages between high-speed and low-speed Option Circuit Eeprom CircuitLoad Drive Circuit D602 COMP. equivalence circuit of drive section If power is not on DiagnosticsStart Normal If the compressor and cooling fan motor don’t work normally AssemblyCheck after a lapse of 5 min Connection If defrost function Exchange and troubleshoot Corresponding sensorPerform forced defrosting for F Room at a time If there is a trouble with self-diagnosis If the temperature sensor of F and R room has troubleIf the ambient sensor has trouble Start Check if the iced solder of main PCB is Short If Ding-Dong sounds continuously Start If alarm soundIf Beep sounds continuously Start Remove causes after Without sound of buzzer operation Start Main PCB is normal buzzer normalDisplay’ ZoneTM panel If the panel PCB is not working normally Connections of door S/W If fan doesn’t work ReferenceDoor open DC Door close If the lamp of CoolSelect ZoneTM is not lit Start If CoolSelect ZoneTM isn’t operated normally RS2555, RS2577If the Panel PCB key isn’t selected Panel PCB has trouble for itself Is the inside lamp filament cut? If the lamps of freezer / refrigerator does not light Check the operation of SSR71 and Q701 If Crushed Ice/Cubed Ice doesn’t work properly Safety Instructions on Service DC 0V Stop Condition Appendix ⅠReference for circuit diagnosticsResistance value ∼DC 12V load working condition Value Contents For safety, you must turn the power off LoadRef Check a load Ref. Def heater Lamp Lamp on the REF Ref Check Door S/W 834 878791 749 Part Name Specifcation ’TY Ref Service part lists of each circuit boardPage Page Refrigerator Division 2003 Code DA82-00001D Electronics

Samsung RS2666 Evaporator in Freezer, Freezer Thermistor, Ambient Thermistor, Ice-MakerThermistor

Models: RS2777 RS2622 RS2666 RS2544

Mechanical Disassembly

Evaporator in Freezer

Freezer Thermistor

Ambient Thermistor

Ice-MakerThermistor