Cable1 3BBA0083P001 | Toshiba G9000 specification

The Power Supply PCB (PSAU-60, designated as PS1) and the Cable1 (designated as 3BBA0083P001) are equipped with G9000 UPS units.

The Cable2 (D-sub 9pin) and the Cable3 (12V power cable) are included in the RemotEyeII package.

The Power Supply PCB (PS1) provides connectivity between the Display Control PCB (DPAU-81, designated as SW1) and the RemotEyeII module in G9000 UPS units.

The RemotEye II communicates with the UPS via a Cable2. The connection is described in FIGURE 2.14 below.

The UPS has to be de-energized when the RemotEyeII module is installed for safety reason.

CAUTION

FIGURE 2.14 Connection between Display Control PCB (SW1) and RemotEyeII module

DPAU-81

SW1

Cable1

3BBA0083P001

PSAU-60

PS1

(male)

Cable3

12V Power Cable

Cable2

D-sub 9-pin Cable

(receptacle)(RJ45)

RemotEyeII

(RJ45) (RJ45)

42	G9000 Installation and Operation Manual

Image 52

Toshiba G9000 operation manual Cable1 3BBA0083P001, Male Cable3 12V Power Cable Cable2 Sub 9-pin Cable

Contents

Document 4GBA0012 Rev. E January Page Document No GBA0012 Rev. E January Page Uninterruptible Power System Important Notice Purpose and Scope of Manual Table of Contents List of Tables List of Figures Power wire connections parallel system configuration How to use this Manual Important Safety Instructions Safety Precautions UPS Installation Environment Environment standard Capacity kVA Bypass Voltage Vac Bypass Rating Aac Breaker a General Definitions Operation Overview CB3 Mccb Single Line Diagram Battery Operation Page 1 UPS Parts Location 80,100kVA UPS Parts Location 300kVA Door Backside Main Cabinet UPS cabinet Front ViewUPS cabinet Front Inside View 4 UPS Parts Location 500kVA UPS cabinet Front View Backside of Left Door Item 10 Grounding bar is not shown in .4.5. Refer to Figure Reset switch Button Test switch 12. SW5 13. SW6 1 Parallel I/F PCB IFAU-08 80-225kVA CN96 CN95 CN94 Description of Figures 1.4.1-5 to External I/F PCB IOAU-09 Figure Signal I/F on IOAU-09 boardLCD Touch Panel Monitor Display 15 L S/W switch for Service Personnel only External contact signal terminal blockRefer to Figures 3.7.1 to 3.7.4 for details AC input, AC output, DC input terminal Specifications 80kVA / 72kW 480V Width Depth Height Net Weight Typical Width Depth Height Gross Weight Lbs KVAUPS Lbs Heating KVA Knockout KBTU/h A Detail of Specifications AC Input Operating Temperature Cooling Phase I 80-225kVA Phase II 300-750kVA Rating of Contactors, Breakers and Fuses Output Capacity of Equipment Number Application Operator Controls and Indicators Battery operation Battery OP. orange EPO Button Emergency Power Off buttonLED Display Load on inverter Load on Inverter green Menu Liquid Crystal DisplayStartup/Shutdown Guidance Figures 2.3.1 to 2 Startup guidance 2 Output values 1 Log menu Input Power Failure Fault Indication Message External Signal Terminal Block Summary Alarm Triggers on fault alarm onlyOUT8 Total Alarm Triggers on any alarm including faults TN2 Battery Breaker Panel TN1 Output Contacts for external alarm annunciation Terminals 7 to 8 Battery Operation contact OUT3Terminals 11 to 12 Battery Low Voltage contact OUT5 Terminals 3 to 4 Load on Bypass contact OUT1 Input Contacts for remote access of UPS 12 Remote Start Contact Connections Terminals 11 to 12 Battery Temp. High contact input IN3 Terminals 13 to 14 Power Demand Command contact input IN4Used to perform a remote UPS Emergency Power Off EPO Terminals 9 to 10 Remote Inverter Stop input terminal IN2 13.1 Configuration of the RemotEyeII Overview 80-225kVA RemotEyeII Introduction Back of the front door Main cabinet RemotEyeII DPAU-81SW1 Cable2 Cable3 Provided PSAU-60 Provided PSAU-60 PS1 Cable1 Back of the front left door Main cabinetSW1 Male Cable3 12V Power Cable Cable2 Sub 9-pin Cable Cable1 3BBA0083P001 15 PSAU-60 PCB PS1 Connector Definition Figure Transportation and Installation Transportation InstallationInstallation Procedure Space requirement for routine maintenance External Battery Supply Procedure for Cable ConnectionsUPS Capacity DC Voltage KVA Rating Current Permitted a Required Page Recommended Cable Sizes Crimp Type Compression Lug UPS Terminal Designation UPS module Location of bus bars and terminal blocks Bottom EntryInput A40,B40,C40 Detailed Power Terminals UPS module 300kVA A50, B50, C50 Grounding Bar not shown 18.5 UPS module 500kVA AC Output 78.7 A50, B50, C50 Grounding Bar Not shown 19.7 UPS module 750kVA BUS BAR Detail TOP View BUS BAR Detail TOP View BUS BAR Connection TOP View Alternate Landing Main Cabinet BUS BAR Connection DC Breaker for Battery Bypass52S Converter CB1 /Charger Inverter 52C CB2 BatteryBreaker 52Ln *1 AC output UPS-1 UPS-1 ~~~~~ UPS-1 No.N UPS Use Ethernet STP Shielded Twisted Pair Cable Cat 5 or ~~~~~ Operating Procedures Circuit protectors location Shut-down Procedure Operation Menu Bypass Operation Procedure UPS MMS Start-up Procedure LCD Screen MMS Operation Response to UPS Failure Replace battery if its capacity is within this percentage BatteryUPS Component Parts Fault Codes Failure Code List Fault Code CB2 Open DC Unbalanced Overvoltage Engineer Inverter Call Service 52S Abnormal How to perform daily inspection Daily InspectionPage National and local codes for possible Consult latest edition of applicableVariations 27.6 x 32.8 x 855 136 13,463 114 150 AT 3/0100 120 150 AT 3/0 94 @ 0.9 PF 235 250 AT Kcmil 300 kcmil 35.4 x 32.8 x 1160 144 17,821 151 181 250 AT Kcmil 300 kcmil160 192 250 AT Kcmil 300 kcmil 149 @ 0.9 PF 372 400 AT Kcmil 35.4 x 32.8 x 1230 152 25,060 212 255 350 AT Kcmil 2 x 250 kcmil225 271 350 AT Kcmil 2 x 250 kcmil 210 @ 0.9 PF 524 600 AT 300 kcmil 2 x 400 kcmil 51.2 x 32.7 x 1230 189 31,659 312 376 500 AT 250 kcmil 2 x 300 kcmil300 361 500 AT 4/0 2 x 250 kcmil 309 @ 1.0 PF 772 800 AT 400 kcmil 70.9 x 32.7 x 3300 205 52.8 23.6 42.3 521 626 800 AT 300 kcmil 3 x 350 kcmil500 601 800 AT 300 kcmil 3 x 350 kcmil 512 @ 1.0 PF 1292 1400 AT 400 kcmil 4 x 500 kcmil 90.6 x 32.7 x 4255 207 79,147 781 939 1400 a 500 kcmil750 902 1200 a X350 kcmil 4 x 400 kcmil 776 @ 1.0 PF 1935 2000 AT 400 kcmil 6 x 500 kcmilPage Page Industrial Division