Sharp UX-5000 operation manual Sharp

Page 105
Engineering Control/Ventilation: Work/Hygienic Practice:
Steps to be taken in case of Spill or Leak:
Waste Disposal Method:
Contaiminated Packaging:

SHARP

MATERIAL SAFETY DATA SHEET

UX5000U MSDS

Date Issued: 1996. 8. 1

MSDS No. B-1008

Section 1. Product Identification

Product Code:

FO-50ND

Toner Cartridge

Section 2. Supplier’s Name and Address

Sharp Corporation

22-22 Nagaike-cho, Abeno-ku, Osaka, Japan

Local suppliers are listed below. Please contact the nearest supplier for additional information.

 

 

 

 

 

 

(Country)

(Name and Telephone Number)

 

 

 

U.S.A.

Sharp Electronics Corporation

 

 

 

 

Telephone number for information :

201-529-8200

 

 

Emergency telephone number

:

1-800-255-3924

 

Canada

Sharp Electronics of Canada Ltd.

 

 

 

 

Telephone number for information :

416-890-2100

 

 

Emergency telephone number

:

1-800-424-9300

 

United Kingdom

Sharp Electronics(U.K.)Ltd.

 

 

 

 

Telephone number for information :

01923-474013

Section 3. Ingredients

Ingredients

 

CAS No.

Proportion

OSHA PEL

ACGIH TLV

Other Limits

Polyester resin

 

361615-5042-P

>85 %

3.5mg/m3

3.5mg/m3

 

Carbon black

1333-86-4

1-5

%

 

Polypropylene

9003-07-0

1-5

%

 

 

 

Organic pigment

 

361615-5025-P

1-5

%

 

 

 

Section 4. Hazardous Identification (Emergency Overview)

Toner is a fine, black powder prossessing no immediate hazard. There are no anticipated carcinogenic effects from exposure based on animal tests performed using toner. When used as intended according to instructions, syudies do not indicate any symptoms of fibrosis will occur.

Section 5. Health Hazard Data

Route(s) of Entry:

Eye contact, inhalation, ingestion

Health Hazards:

No data available

Carcinogenicity:

In 1996 the IARC reevaluated carbon black as a Group 28 carcinogen (possible human carcinogen). This classification is given to chemicals for which there is

 

inadequate human evidence, but sufficient animal evidence on which to base an opinion of carcinogenicity. The classification is based upon the development of lung

 

tumors in rats receiving chronic inhalation exposures to free carbon black at levels that induce particle overload of the lung. Studies performed in animal models other

 

than rats did not show any association between carbon black and lung tumors. Moreover, a two-year cancer bioassay using a typical toner preparation containing carbon

 

black demonstrated no association between toner exposure and tumor development in rats.

Signs and Symptoms of Exposure:

No symptoms expected under intended use.

Medical Conditions Generally Aggravated by Exposure: None

Choronic effect:

In a study in rats of chronic inhalation exposure to a typical toner, a mild to moderate degree of lung fibrosis was observed in 92% of the rats in the high concentration

 

(16mg/m3) exposure group, and a minimal to mild degree of fibrosis was noted in 22% of the animals in the middle (4mg/m3) exposure group, but no pulmonaly change

 

was reported in the lowest (1mg/m3) exposure group, the most relevant level to potential human exposures.

Emergency and First Aid Porcedures:

 

Inhalation:

If symptoms are experienced, remove source of contaimination or move victim to fresh air and obtain medical advice.

Eye Contact:

Do not allow victim to rub eye(s). Flush with gently flowing water (lukewarm preferable) for 15 minutes or untill particle is removed. Have victim look right and left,

 

and, then up and down. If irritation does occur, obtain medical attention. DO NOT attempt to manually remove anything stuck to the eye(s).

Ingestion:

If irritation or discomfort occur, obtain medical attention immediately.

Section 6. Physical Chemical Characteristics

Boiling/Melthing Point:

N.AP.

Specific Gravity:

1.2

Vapor Pressure:

N.AP.

Solubility In Waster:

Negligible

Vapor Density:

N.AP.

PH:

N.AP.

Evaporation Rate:

N.AP.

Viscosity:

N.AP.

Appearance:

powder

Color:

Black

Odor:

oder

 

 

Section 7. Fire and Explosion Data

Flash Point (Method Used):

N.AP.

 

Ignition Temperature:

450°C

 

Flammable Limits:

(LEL); N.AP.

(UEL); N.AP.

Extinguishing Media:

CO2, water spray, foam and dry chemical

Special Fire Fighting Procedure:

None

 

Unusual Fire and Explosion Hazard:

If dispersed in air, like most finely divided organic powders, may form an explosive mixture.

Sensitivity to Mechanical Impact:

None

 

Sensitivity to Static Charge:

None

 

Section 8. Reactivity Data

Stability:

Stable

Incompatibility (Materials to Avoid):

Oxidizing materials

Hazardous Decomposition:

CO, CO2

Hazardous Polymerization:

None

Section 9. Precautions for Safe Handling and Use

Personal Protection Information (Respiratory, Eye Protection and Protective Glove):

Use of a dust mask is recommended when handling a large quantity of toner or during long term exposure, as with any non-toxic dust. None required under intended use.

Inhalation should be minimized as with any non-toxic dust.

Wipe off with paper or cloth. DO NOT use vacuum cleaner when released a large amount. It, like most finely divided organic powders, may create a dust explosion. Preparation (community provisions): Waste may be disposed or incinerated under conditions which meet all federal, state and local environmental regulations. Waste may be disposed or incinerated under conditions which meet all federal, state and local environmental regulations.

Section 10. Regulatory Information

NFPA Rating (U.S.A.):

Health = 1

Flammability = 1

Reactivity = 0

WHMIS Legislation (Canada):

None

 

 

Transport Information:

None

 

 

UN No.:

None listed.

 

 

Section 11. Other Information

Reference:

IARC (1996)

 

IARC Monographs on the Evaluation of the Carcinogenic Risk of Chemicals to Humans, Vol. 65, Printing Process and Printing inks, Carbon Black and Some Nitro

 

Compounds, Lyon, pp-149-261

 

H. Muhle, B. Bellmann, O. Creutzenberg, C. Dasenbrock, H. Ernst, R. Kilpper, J. C. Mackenzie, P. Morrow, U. Mohr, S. Takenaka, and R. Mermelstein (1991) Pulmonary

 

Response to Toner upon Chronic Inhalation Exposure in Rats.

 

Fundamental and Applied Toxicology 17, pp. 280-299

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Page 104 Page 106
Image 105
Page 104 Page 106
Contents UX-5000 UX5000U-FCC-2 Important safety information IntroductionUX5000U-INBU Table of Contents Unpacking Checklist InstallationPrecautions before setting up InstallationUX5000U-ISPC Installing the Printer CartridgesPull the old drum cartridge out of the compartment Its packagingInstalling the Printer Cartridges Close the printer cover Replacing the cartridgesAttachments and Connections UX5000U-ISACHandset Telephone line cordPower lead Assembly and ConnectionsTrays UX5000U-ISLP Loading Printing PaperLoading the paper cassette Push the pressure plate down until it Loading the paper trayLocks into position Back. Grasp the hand hold onLegal Place the paper in the tray LetterClose the original document in tray If desired, attach a letter or legalLoading Paper Installation Initial Settings Initial SettingsUX5000U-IPOP Look AT the Operation PanelLook AT the Operation Panel Broadcast key Document key Report keyCopy key Redial keyUX5000U-IPSN Entering Your Name and FAX NumberStep Press these keys Comments Entering Letters for Names Symbol listUX5000U-IPSD Setting the Date and TimeUX5000U-IPAD Chain Dialing for area and access codesStoring Numbers for Automatic Dialing Storing numbersStoring Numbers for Automatic Dialing Making changes Clearing numbersStoring Numbers in Group Keys UX5000U-IPVA Volume AdjustmentSpeaker HandsetVolume Adjustment Initial Settings Basic Operations Size and weightUX5000U-BOPS Sending DocumentsDual access Other restrictionsSending Documents Memory Retransmission If the memory becomes fullExample the transmission you want to cancel To cancel a memory transmissionChecking documents in memory Enter the 3-digit memory number assigned toAdjust the document guides to Loading the documentWidth of your document Optional transmission settings ResolutionStandard Cover Sheet ContrastLight To send a cover sheet, press the Cover Sheet keyExample Batch Page NumberingUX5000U-BOSD Dialing and transmissionNormal Dialing Rapid Key Dialing Direct Keypad DialingPress the Start key. Replace Handset if you used itChain Dialing Speed DialingPress the Search Dial key Using the Search Dial keyPress the → or the ← key to scroll Through the names. Stop whenUsing the Redial key To cancel a fax transmission or receptionChecking the telephone line status RedialingUX5000U-BORD Setting the mode of receptionReceiving Documents Auto receptionManual reception Hang up when Receiving appears in the displayReceiving Documents HandsetNumber from which each document was Substitute receptionMaking Copies UX5000U-BOCYPress the Copy key Press 1 to select Multi COPY, orMaking Copies Checking copy operations in memoryUX5000U-BOVC Making Telephone CallsRedial Making Telephone Calls Basic Operations Special Functions UX5000U-SFBRBroadcasting Broadcasting Broadcasting using a Group KeyPress the Start key twice Transmission will beginUX5000U-SFCO Confidential OperationsConfidential transmission Confidential reception Confidential OperationsTransmission will take place once the connection is made Clearing the passcode Programming the confidential passcodePrinting out received documents UX5000U-SFRR Relay RequestStoring a relay group Relay Relay RequestClearing a relay group Load the document Making a relay requestRelay Broadcast UX5000U-SFPO PollingPolling others ∙ Memory Poll Mode will appear Serial Polling using a Group KeyBeing polled Memory polling Press 1 to select SET Press 1 to allow polling to be donePolling Security To clear a documentTurning Polling Security on and off Programming and clearing a System number Storing and clearing fax numbers for polling permissionEnter the number 4 digits with the numeric Storing and clearing ID numbers for polling permissionExample keys To the date and time displayTimer Operations Initial procedureUX5000U-SFTI Timer Operations TransmissionLoad the document Step if the receiving machine does not have Serial Polling PollingRelay Request BroadcastingExample Enter the appropriate relay group number Otherwise skip this stepTimer Canceling a timer operationBatch Transmission UX5000U-SFBTEntering a batch program Storing documents for transmissionClearing a document stored for batch transmission UX5000U-SFEP Entering and Using ProgramsEntering and Using Programs If you want the document to be sent from Enter the fax numbers of the machines to be Broadcasting Batch transmission Clearing a Program Key Using a Program Key Press the appropriate Program KeyPress the Program Key Example UX5000U-SFDC Department ControlEntering Department Codes Accessing the machine Telephone billingDepartment Control Anti Junk FAX UX5000U-SFAJDistinctive Ring UX5000U-IPDRAccessing the settings Optional SettingsSettings Option SettingsAlways Prints Never Prints 5 Error only Optional SettingsSetting 13 Copy CUT-OFF Setting 20 Heater Mode Setting 23 Dial Mode Setting 22 Alarm VolumeSetting 25 Multi TTI Setting 26 Beep Length=006 Printing out a list Printing OUT Reports and ListsActivity Report Explanation of headingsReception errors Transmission errorsTimer list Telephone Number ListRelay Group List Passcode List Optional Setting ListProgram and Group List Batch Transmission List Department Usage ListConfidential Reception List Transaction Report Anti Junk Number ListHousing MaintenanceUX5000U-MAMA Reading glass and rollersMaintenance Problems and Solutions TroubleshootingTroubleshooting Problem Check and remedyProblems and Solutions Messages and Signals UX5000U-TSDMDisplay messages Display Messages Audible signalsClearing Paper Jams UX5000U-TSCPClearing a jammed document Clearing jammed printing paperCompartment Clearing Paper JamsReplace the drum cartridge, and then the toner cartridge Gently pull the paper outSpecifications SpecificationsFCC Regulatory Information Sharp UX5000U-QRQR Quick Reference GuideTransmitting documents Quick Reference GuideFunction key menu Reception Mode Listing Mode Entry Mode Optional SettingsProgram/Group Serial Polling Memory Mode UX5000U-ESQR Guia DE Consulta RapidaTransmisión de documentos Guia DE Consulta RapidaModo listado Menú de la FunctionModo de entrada Ajustes opcionalesRapida-iii Rapida-iv Index Index Limited Warranty Sharp Electronics Corporation
Top Page Image Contents