Pitco Frialator SELV14T operation manual Troubleshooting Charts, Fryer Troubleshooting Chart

Page 32

SELV INSTALLATION & OPERATIONAL MANAUAL

14 TROUBLESHOOTING CHARTS

14.1FRYER TROUBLESHOOTING CHART

	Problem	Probable Causes	Corrective Actions
		No power to appliance.	Check main building power supply.
		Circuit Breaker tripped.	Reset circuit breaker.
	Computer Controller	Power Cord loose or not	Connect power cord. Check power cord where it
	Computer Controller	Power Cord loose or not	enters the rear of the fryer's entrance box. Verify
	display doesn't light.	connected.	that it os plugged all the way into the receptacle.
	display doesn't light.		that it os plugged all the way into the receptacle.

		Fuse blown.	Contact Authorized Service Company.
		Transformer Defective.	Contact Authorized Service Company.
		Defective Controller.	Contact Authorized Service Company.
	Controller is on and	Computer is in Melt Cycle	Allow time for unit to heat up.
	appliance will not	High temperature limit has	Allow appliance to cool and reset High
	heat up.	tripped.	temperature limit.

	Appliance will not	Faulty temperature probe.	Contact Authorized Service Company.
	maintain temperature	Faulty temperature probe.	Contact Authorized Service Company.
	maintain temperature	Faulty High temperature limit.	Contact Authorized Service Company.
	properly.	Faulty High temperature limit.	Contact Authorized Service Company.

	Computer display
	shows off and can not	Faulty computer	Contact Authorized Service Company.
	be turned on.
	Oil Temperature is	Temperature Calibration	Refer to section 3.8
	hotter, or cooler than	Temperature Calibration	Refer to section 3.8
	shown by Computer	Defective Temperature Probe	Contact Authorized Service Company.
	Controller	Defective Temperature Probe	Contact Authorized Service Company.
	Controller
	Computer Controller	Blue drain vavle is not	Close blue drain valve handle.
	Computer Controller	completely closed.	Close blue drain valve handle.
	displays "DRAINING"
	displays "DRAINING"	Improperly adjusted or
	or "TURN OFF"	Improperly adjusted or	Contact Authorized Service Company.
	or "TURN OFF"	defective drain switch.	Contact Authorized Service Company.
		defective drain switch.
	Computer Controller
	displays "PROBE	Open temperature probe	Contact Authorized Service Company.
	OP" "OPEN"

32	L20-406 Rev 5 (3/14)

Image 32

Contents Reduced OIL Volume Frying System To the PURCHASER, Owner and Store Manager Table of Contents Routine Cleaning Theory of Operation Installation Checking and Unpacking Your NEW Appliance General Installation Requirements Installation ClearancesLeveling the FRYER‐ LEGS/CASTERS Caster and leg typesElectrical Connections RequirementsOptional Cord SET & Plug and Restraint Cable 1 Drain line removed for clarityVentilation and Fire Safety Systems InspectionFilling the Cooking Tank Cooking GuidelinesOperation Operational Features Basic Operational Features Drain Valve Handle Blue Pull to drain frypotOIL Temperature Appliance Start UPComputer Controller Operation To View Current Settings for cook, shake, and hold times Typical displays using key 4 as an exampleTo perform a Boil Out operation Automatic Boil Entry Water DetectionTo Set Cook Temperature To Enter Programming Level 1 for the Store ManagerCook Time Shake TimeHold Pre-Alarm To Exit Level 1 programmingTo Enter Programming Level 2 for the Store Manager Fahrenheit or Celsius DisplayPassword Change or Required? Beeper Volume and ToneRecovery Test Value Language SelectionControl or Timer Left side of Dual or Single Vat Control or Timer Right side of Dual VatOther Displays Appliance ShutdownOIL Management Push Button OIL TOP OFF System Automatic OIL TOP System OptionFlush Hose Operation if equipped Cook Counter AdjustmentQuick Strain Filtering Filter Soon light flashing Routine Cleaning Cleaning Schedule Clean Filter PartsStart of DAY Replacing the Filter Media if equippedInstallation & Operational Selv Manual Cleaning the Cabinet Daily Cleaning InstructionsEND of DAY Cleaning the Cook Tank Filter Cleaning If Equipped Weekly Preventative MaintenanceMonthly Preventative Maintenance Boil OUT ProcedureTemperature Check ANNUAL/PERIODIC Preventative Maintenance and InspectionHeating Element Drain Valve Interlock Troubleshooting Power FailureHigh Temperature Limit Troubleshooting Charts Fryer Troubleshooting ChartFilter Troubleshooting Problem Probable Causes Corrective ActionsDisplay Problems Action Computer & Digital Controller DisplaysPROBLEM‐SOLVING Shortening Frying oil Problem-Solving Possible Cause SolutionSelv Installation & Operational Manaual