Specifications, Plug Configuration | Garland XG36-JIB, XG24-JIB

SPECIFICATIONS continued

Plug Configuration

The grill is supplied with an electrical power supply cord and plug to match the specific voltage as it was constructed. The following table shows the correct plug configuration to match the model and voltage.

Xpress Grill Cord and Plug Configuration

	P/N			Cord				Maximum	Minimum
	(includes electrical			Cord			Voltage	Maximum	Minimum
	(includes electrical	Plug Type		Gauge	NEMA Plug	Model	Voltage	Current	Cord
	and gas inlet	Plug Type		Gauge	NEMA Plug	Model	(3ph Delta)	Current	Cord
	and gas inlet			Supplied			(3ph Delta)	(Amps)	Gauge
	plumbing)			Supplied				(Amps)	Gauge
	plumbing)
		Y X	GND			XG24-JIB	208	24.90	4-10AWG
	4524785			4-6AWG	15-50P		208	37.43	4-6AWG
						XG36-JIB
		Z					240	32.43	4-8AWG
		Y X	GND
	4525509			4-10AWG	15-30P	XG24-JIB	240	21.61	4-10AWG

Z

Page 6

Part # JIBSM08 Rev 7 (08/04/09)

Image 6

Garland XG36-JIB, XG24-JIB service manual Specifications, Plug Configuration

Contents

Jack in the BOX GAS Xpress GRILLS, Models XG24-JIB, XG36-JIB Table of Contents Table of Contents Dimensions and SPECIFICATIONS, XG24-JIB Model Dimensions and SPECIFICATIONS, XG36-JIB Model Specifications Plug Configuration Shipping Damage Claim Procedure SafetyWarranty Introduction Safety General Information Unit InstallationRating Plate Location National Codes Requirements Appliances Equipped with Casters Unit InstallationAccessory Kit Main Gas Inlet Electrical Connections Accessory Kit Electrical Supply Lines Ventilation and Clearance Electrical Connection Terminal Block ConnectionGrease Bucket Changing to a different type of gas Burner Air Adjustment Igniter AdjustmentIgniter Inspection Grill Controls Grill Controls Programming Mode System Setup Platen Zeroing Platen Zeroing Lower Front Left Raise Back Right Optional Accessories Release Material Installation Release material sheet must be replaced when Normal Operation Normal Operation Cleaning and Maintenance Cleaning During OperationDaily Cleaning Cleaning and Maintenance Programming Programming Modes/Menu Sequence Programming To Change Product Gap Setting To Change Upper Platen Set TemperatureTo Change Grill Set Temperature To Change the Cook Time of a Product To Change Product Button,KeyAssignment To View Recovery Time Upper PlatenTo View Recovery Time Grill To Change a Product Name To View the Flash Number To Change temperature Units, F or CTo Change Gap Setting Display Units To View the Software Number To Change Probe Calibration Upper To Change the Alarm VolumeTo Change the Key Chirp To Change Probe Calibration Grill To Change Control Type To Change Platen SetTo Change Instant-On Time To Turn Extended Time On/Off To Turn Clean Mode On/Off To Change the Start DelayTo Change the Alarm Mode To Change the Grill Function To Perform Limit Switch Test To Modify a Product Name in LibraryTo Change SCK Address Calibration Bi-Weekly CalibrationTo Calibrate Calibration Probe Locations Troubleshooting Error Messages Technical Troubleshooting Low Internal Product Temperatures Technical Troubleshooting Controller Displays Too HotYES YES Controller displays Probe Error Inconsistent Or Erratic Internal Product Temperature Upper platen is not zeroed properly Probable diagnosis YES Check voltage of upper limit Does Upper Limit Controller Displays Ignition Failure No flame at all YES Noyes Linear Actuator Replacement Linear Actuator Replacement JIBSM08 Rev 7 08/04/09 Parts List Contents Model XG24-JIB Gas Xpress Grill Complete Exploded View Model XG24-JIB Description Quantity Xpress Grill Actuator Gas Xpress Grill Actuator Assembly View Model XG24-JIB Xpress Grill Platen Gas Xpress Grill Platen Assembly View Model XG24-JIB 4517022 Platen Conduit Xpress Grill Burner Gas Xpress Grill Burner Assembly View Model XG24-JIB Assembly View Model XG24-JIB Component Bracket Contactor BracketIgnition Module Xpress Grill Heat Sink Assembly View Model XG24-JIB Gas Xpress Grill Heat Sink Assembly View Model XG24-JIB Item # Revision HistoryREV. # Part List Book Released Parts List Right Zone Grill Complete Assembly Gas Xpress Grill Complete Exploded View Model XG36-JIB Description Quantity Critical 4520578 Grill Plate Thermocouple JIBSM08 Rev.6 08/04/09 Actuator Assembly GAS Xpress Grill Actuator Assembly View Model XG36-JIB Platen Assembly Gas Xpress Grill Platen Assembly View Model XG36-JIB Assembly View Model XG35-JIB Gas Xpress Grill Burner Assembly View Model XG36-JIB Xpress Grill Bracket Component Mounting Bracket Xpress Grill Heat Sink Assembly View Model XG36-JIB Gas Xpress Grill Heat Sink Assembly View Model XG36-JIB Description & Location Quantity Critical Gas Xpress Grill Accessories And Tools Model XG36-JIB Gas Xpress Grill Gas Tubing Model XG36-JIB Center Zone Right Zone Left Zone Revision History Item # Date Wiring Diagram Wiring Diagram Controller Menu Items Jack in the Box Menu ItemsTime Temperature Conversion F / C Page JIBSM08 Rev.6 08/04/09