Programming Modes/Menu Sequence | Garland XG36-JIB, XG24-JIB

PROGRAMMING

Programming Modes/Menu Sequence:

System Information

27

27

27

28

28

28

26

26

26 26

26 27

27



Page 24					Part # JIBSM08 Rev 7 (08/04/09)

Image 24

Garland XG36-JIB, XG24-JIB service manual Programming Modes/Menu Sequence

Contents

Jack in the BOX GAS Xpress GRILLS, Models XG24-JIB, XG36-JIB Table of Contents Table of Contents Dimensions and SPECIFICATIONS, XG24-JIB Model Dimensions and SPECIFICATIONS, XG36-JIB Model Specifications Plug Configuration Safety WarrantyShipping Damage Claim Procedure Introduction Safety Unit Installation Rating Plate LocationGeneral Information National Codes Requirements Unit Installation Accessory Kit Main Gas InletAppliances Equipped with Casters Electrical Connections Accessory Kit Electrical Supply Lines Electrical Connection Terminal Block Connection Grease BucketVentilation and Clearance Changing to a different type of gas Burner Air Adjustment Igniter AdjustmentIgniter Inspection Grill Controls Grill Controls Programming Mode System Setup Platen Zeroing Platen Zeroing Lower Front Left Raise Back Right Optional Accessories Release Material Installation Release material sheet must be replaced when Normal Operation Normal Operation Cleaning and Maintenance Cleaning During OperationDaily Cleaning Cleaning and Maintenance Programming Programming Modes/Menu Sequence Programming To Change Upper Platen Set Temperature To Change Grill Set TemperatureTo Change Product Gap Setting To Change the Cook Time of a Product To View Recovery Time Upper Platen To View Recovery Time GrillTo Change Product Button,KeyAssignment To Change a Product Name To Change temperature Units, F or C To Change Gap Setting Display UnitsTo View the Flash Number To View the Software Number To Change the Alarm Volume To Change the Key ChirpTo Change Probe Calibration Upper To Change Probe Calibration Grill To Change Platen Set To Change Instant-On TimeTo Change Control Type To Turn Extended Time On/Off To Change the Start Delay To Change the Alarm ModeTo Turn Clean Mode On/Off To Change the Grill Function To Perform Limit Switch Test To Modify a Product Name in LibraryTo Change SCK Address Calibration Bi-Weekly CalibrationTo Calibrate Calibration Probe Locations Troubleshooting Error Messages Technical Troubleshooting Low Internal Product Temperatures Technical Troubleshooting Controller Displays Too HotYES YES Controller displays Probe Error Inconsistent Or Erratic Internal Product Temperature Upper platen is not zeroed properly Probable diagnosis YES Check voltage of upper limit Does Upper Limit Controller Displays Ignition Failure No flame at all YES Noyes Linear Actuator Replacement Linear Actuator Replacement JIBSM08 Rev 7 08/04/09 Parts List Contents Model XG24-JIB Gas Xpress Grill Complete Exploded View Model XG24-JIB Description Quantity Xpress Grill Actuator Gas Xpress Grill Actuator Assembly View Model XG24-JIB Xpress Grill Platen Gas Xpress Grill Platen Assembly View Model XG24-JIB 4517022 Platen Conduit Xpress Grill Burner Gas Xpress Grill Burner Assembly View Model XG24-JIB Assembly View Model XG24-JIB Component Bracket Contactor BracketIgnition Module Xpress Grill Heat Sink Assembly View Model XG24-JIB Gas Xpress Grill Heat Sink Assembly View Model XG24-JIB Revision History REV. #Item # Part List Book Released Parts List Right Zone Grill Complete Assembly Gas Xpress Grill Complete Exploded View Model XG36-JIB Description Quantity Critical 4520578 Grill Plate Thermocouple JIBSM08 Rev.6 08/04/09 Actuator Assembly GAS Xpress Grill Actuator Assembly View Model XG36-JIB Platen Assembly Gas Xpress Grill Platen Assembly View Model XG36-JIB Assembly View Model XG35-JIB Gas Xpress Grill Burner Assembly View Model XG36-JIB Xpress Grill Bracket Component Mounting Bracket Xpress Grill Heat Sink Assembly View Model XG36-JIB Gas Xpress Grill Heat Sink Assembly View Model XG36-JIB Description & Location Quantity Critical Gas Xpress Grill Accessories And Tools Model XG36-JIB Gas Xpress Grill Gas Tubing Model XG36-JIB Center Zone Right Zone Left Zone Revision History Item # Date Wiring Diagram Wiring Diagram Controller Menu Items Jack in the Box Menu ItemsTime Temperature Conversion F / C Page JIBSM08 Rev.6 08/04/09