Manuals / Henny Penny / Kitchen Appliance / Fryer

Henny Penny EEG-144, EEG-142 Assistance, Safety, Avoided, Will Result In Death Or Serious Injury

Models: EEG-143 EEG-144 EEG-141 EEG-142

1 72

Download 72 pages 1.4 Kb

Page 10

ASSISTANCE

		Model EEG-141, 142, 143, 144
1-4.	ASSISTANCE	Should you require outside assistance, call your local independent
		distributor in your area, or call Henny Penny Corp. at
		1-800-417-8405 or 1-937-456-8405.
1-5.	SAFETY	The Henny Penny open fryer has many safety features incorporated.
		However, the only way to ensure a safe operation is to fully under-

stand the proper installation, operation, and maintenance proce- dures. The instructions in this manual have been prepared to aid you in learning the proper procedures. Where information is of particu- lar importance or safety related, the words DANGER, WARNING, CAUTION, and NOTICE are used. Their usage is described below.

SAFETYALERT SYMBOL is used with DANGER, WARNING, or CAUTION which indicates a personal injury type hazard.

NOTICE is used to highlight especially important information.

CAUTION used without the safety alert symbol indicates a potentially hazardous situation which, if not avoided, may result in property damage.

CAUTION used with the safety alert symbol indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury.

WARNING indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.

DANGER INDICATES AN IMMINENTLY

HAZARDOUS SITUATION WHICH, IF NOT

AVOIDED, WILL RESULT IN DEATH OR SERIOUS

INJURY.

1-2

609

Image 10

Henny Penny EEG-144, EEG-142, EEG-141 Assistance, Safety, Danger Indicates An Imminently Hazardous Situation Which, If Not

Contents

Reduced Oil Capacity Open Fryers Split Vat & Full Vat- Gas OPERATOR’S MANUALHenny Penny Evolution Elite Model EEG-141 Model EEG-142 Model EEG-143 Model EEG-144Page DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS FM05-057-C RevisedTechnical Data for CE Marked Products LIMITED WARRANTY FOR HENNY PENNY EQUIPMENT Revised 01/01/07Section TABLE OF CONTENTSPage Page TABLE OF CONTENTS ContinuedSection Fryer SetupPage 1-1. INTRODUCTION 1-2. FEATURESSECTION 1. INTRODUCTION 1-3. PROPER CAREDANGER INDICATES AN IMMINENTLY HAZARDOUS SITUATION WHICH, IF NOT SAFETYASSISTANCE AVOIDED, WILL RESULT IN DEATH OR SERIOUS INJURYWaste Electrical and Electronic Equipment WEEE Symbol 1-5. SAFETY ContinuedEquipotential Ground Symbol Shock Hazard Symbols OR Hot Surface Symbols ORPage 2-1. INTRODUCTION SECTION 2. INSTALLATION2-2. UNPACKING 2-3. SELECTING THE FRYER LOCATION 2-4. LEVELING THE FRYER To prevent severe burns from splashing hot oil2-6. GAS SUPPLY 2-6. GAS SUPPLY Continued 2-6. GAS SUPPLY Continued Model EEG-141, 142, 1432-7. GAS LEAK TEST 2-8. GAS PRESSURE REGULATOR SETTING 2-9. ELECTRICAL REQUIREMENTS2-9. ELECTRICAL REQUIREMENTS Continued 2-10. MOTOR BEARINGS 2-11. LIGHTINGAND SHUTDOWN OF THE BURNERS2-12. DIMENSIONS Model EEG-141, 142, 143Page Refer to explanations on the next pages SECTION 3. OPERATION3-1. OPERATING COMPONENTS Bulk Oil Supply Fryers OnlyFunction 3-1. OPERATING COMPONENTS ContinuedDescription 3-1 3-1 3-1 3-1 3-1 3-1 3-1Description Continued3-1. OPERATING COMPONENTS FunctionDrain Valve Knob DescriptionFunction Vat Covers3-2. SET-UP MODE 3-3. FILLING OR ADDING OIL 3-4. MORNING START-UP PROCEDURES 3-5. BASIC OPERATION 3-6. IDLE MODE WITHADIFFERENT SETPOINT 3-9. REPLACING THE JIB 3-7. OIL GUARDIAN Auto Top-Off 3-8. SELECTINGA PRODUCTManual Top-Off 3-10. MODEL EEG-141 OIL RESERVOIR Removing/Cleaning ReservoirFilling Oil Reservoir 3-11. SMARTFILTER EXPRESS Filter Error 3-11. SMARTFILTER EXPRESS Continued3-12. DAILY FILTERING 3-12. DAILY FILTERING Continued 3-13. DISCARDING OIL FROM VAT USING OPTIONAL OIL DISCARD SHUTTLE 3-14. DISCARDING OIL FROM VAT USING OPTIONAL BULK OIL DISPOSE SYSTEM 3-15. CHANGING THE FILTER PAD 3-15. CHANGING THE FILTER PAD Continued 3-15. CHANGING THE FILTER PAD Continued 3-16. REMOVING AND CLEANING BASKET RESTBe sure that the drain pan, bottom screen, crumb catcher, and the retaining ring are thoroughly dry before placing filter pad into pan as water will dissolve the filter pad 3-17. CLEAN-OUT MODE 3-17. CLEAN-OUT MODE Continued 3-17. CLEAN-OUT MODE Continued “RINSE COMPLETE” “YES NO”3-18. CHECK/REPLACE FILTER DRAIN PAN O-RINGS To prevent oil leaking, and to keep filtering process operating properly, the filter drain pan o-rings should be inspected for nicks and tears at least every 3 months. FigureSet-point Temperature Actual Oil Temperatureand the actual oil temperature shows in the Recovery Information for each Vat3-21. PREVENTIVE MAINTENANCE SCHEDULE ProcedureFrequency3-22. CLEAN BLOWER & VENTS Page SECTION 4. INFORMATION MODE 4-1. INFORMATION MODE DETAILSFUNCTION 4-1. INFORMATION MODE DETAILS ContinuedDISPLAY EX Press the right 4-1. INFORMATION MODE DETAILS ContinuedPress button to start viewing the cook data to view data for other days of weekFUNCTION 4-1. INFORMATION MODE DETAILS ContinuedDISPLAY EX FUNCTION Reset usage data4-1. INFORMATION MODE DETAILS Continued DISPLAY EXChange Product Names 5-1. MODIFYING PRODUCT SETTINGSSECTION 5. PRODUCT PROGRAM MODE Assign ButtonAlarms 1 5-1. MODIFYING PRODUCT SETTINGS ContinuedTo Change Times and Temperatures Quality Timer hold time5-1. MODIFYING PRODUCT SETTINGS Continued MixFilterdAfterFil TrackingX Number of LoadsLoad Compensation, Load Compensation Reference, Full Heat, PC Factor Tech Mode SECTION 6. LEVEL 2 PROGRAMMING6-1. SPECIAL PROGRAM MODE StatsDegrees Fahrenheit or Celsius SP-1 Audio Volume SP-46-1. SPECIAL PROGRAM MODE Continued Language SP-2Liquid or Solid Cooking Oil Used SP-6 Idle Mode Enabled SP-7Audio Tone SP-5 6-1. SPECIAL PROGRAM MODE Continued6-1. SPECIAL PROGRAM MODE Continued Filter Tracking Mode SP-8MIXED Cycle6-1. SPECIAL PROGRAM MODE Continued Filter Tracking Mode SP-8 Continued GLOBALIf GLOBAL is selected, press button Cooking Indicator SP-15 Clean-Out Time SP-11Clean-Out Temperature SP-12 Polish Duration SP-9Engery Save Mode SP-18 2nd Volume SP-172nd Language SP-16 Fryer Type SP-19Bulk Oil Disposal SP-23 Autolift Enabled SP-21Bulk Oil Supply SP-22 Serial Number Log SP-24Dispose Requires Code ? SP-27 Program Code Change SP-25 ContinuedUsage Code Change SP-26 Longer Fill Time SP-286-2. CLOCK SET 6-3. DATA LOGGING, HEAT CONTROL, TECH, STAT, AND FILTER CONTROL MODESCause SECTION 7. TROUBLESHOOTING 7-1. TROUBLE SHOOTING GUIDEProblem CorrectionContinued 7-1. TROUBLE SHOOTING GUIDEProblem CauseCAUSE 7-2. ERROR CODESDISPLAY CORRECTIONCAUSE 7-2. ERROR CODESDISPLAY CORRECTIONPage Henny Penny Corporation P.O.Box Eaton,OH Toll free in USA