Section TOC
to Master TOC
TROUBLESHOOTING AND REPAIR |
TROUBLESHOOTING GUIDE - Observe Safety Guidelines detailed in the beginning of this manual.
PROBLEMS | POSSIBLE AREAS OF | RECOMMENDED |
(SYMPTOMS) | MISADJUSTMENTS(S) | COURSE OF ACTION |
|
|
|
| ENGINE PROBLEMS |
|
Return to
Return to Section TOC
Return to Section TOC
Return
Return to Master TOC
Return to Master TOC
Engine will not start.
1.Make sure the ON/OFF Switch is 1. Check the fuel line for breaks or
| in the “ON” position. |
| obstructions. | Replace | the fuel | ||
2. | Check spark plug boot and wire |
| filter. | DO NOT RUN THE EN- | |||
| GINE WITHOUT AN | ||||||
| for loose or faulty connection. |
| |||||
|
| FUEL FILTER. |
|
|
| ||
|
|
|
|
|
| ||
3. | Make sure that the fuel shutoff | 2. | The | spark plug may | be faulty. | ||
| valve is in the “ON” position. |
| Replace. |
|
|
| |
|
|
|
|
|
| ||
4. | Make certain that the engine has | 3. | Service the engine as outlined in | ||||
| adequate fuel and oil. |
| the Maintenance section of this | ||||
|
|
| |||||
5. | Adjust the choke to prevent car- |
| manual. |
|
|
| |
| buretor flooding. | 4. The engine magneto circuit may | |||||
|
| ||||||
6. | The recoil starter may not be |
| be | faulty. | Consult | engine | |
| engaged with the engine. gently |
| owner’s manual. |
|
| ||
| hit the blower housing and/or pull | 5. | The | engine | may | be | faulty. |
| the rope to its fully extended |
| Replace. |
|
|
| |
| position and rapidly wiggle it. |
|
|
|
| ||
|
|
|
|
|
|
| |
| Repeat until the clutch engages |
|
|
|
|
|
|
| with the engine shaft and resis- |
|
|
|
|
|
|
| tance is felt. |
|
|
|
|
|
|
7.Low oil and engine low oil shut- down protection will not allow unit to start.
Return to Section TOC
Return to Master TOC
CAUTION
If for any reason you do not understand the test procedures or are unable to perform the tests/repairs safely, contact the Lincoln Electric Service Department for technical troubleshooting assistance before you proceed. Call
