Rheem GEN12AD-V, Generator Systems Roduction, Initial Start Up No Lo, Battery Specifications

Page 26

Battery

WARNING Battery posts, terminals and related accessories contain lead and lead compounds, chemicals known to the State of California to cause cancer and reproductive harm. Wash hands after handling.

The installer must supply and install a sealed, valve- regulated, lead-acid rechargeable starting battery. The starting battery MUST conform to the specifications shown below in the chart.

Battery Specifications

Volts

12 Volt DC

 

 

Amps (MIN)

600 CCA (cold cranking amps)

Type

AGM (Absorbed glass mat)

 

 

Terminal Hardware

M6

 

 

Dimensions (MAX):

 

 

 

Width

5.5 inches (140mm)

Length

9.0 inches (230mm)

Height

8.25 inches (210mm)

 

 

Use the supplied tie-down strap (A) to secure the battery to the unit. One end of strap should be attached to the platform and the other end to the slot that is cut in the back wall of the unit.

A

WARNING Storage batteries give off explosive

 

 

 

 

 

 

RODUCTION

 

hydrogen gas during recharging.

 

 

NOTICE Be sure the

 

tery termin

do not contact the

 

Slightest spark will ignite hydrogen

back wall as this may

cause a s

hort.

 

and cause explosion, resulting

 

 

Initial Start-

up (No Lo

ad)

 

in death, serious injury and/or

 

 

 

 

 

 

 

property damage.

 

 

 

 

 

 

 

 

 

 

 

Unit has b

en set-up

for NG operation at the factory.

Battery electrolyte fluid contains acid and is

 

 

 

 

 

 

 

 

Fuel

 

 

 

 

version, if

needed, must be completed prior to

extremely caustic.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

perf

r

ming these

steps. See Fuel Conversion later in

 

 

NOT

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Contact with battery contents could caus

e severe

 

 

 

 

 

 

 

 

th

s section.

 

 

 

 

 

 

 

 

 

 

chemical burns.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Before o

perating the generator or placing it into service,

A battery presents a risk of

ctrical sh

ock and high short

 

 

 

 

 

 

 

the entire installation carefully. Then begin testing the

circuit current.

 

 

 

 

 

 

 

 

FOR

 

 

 

 

 

 

 

 

spect

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

t DO NOT dispose of batte

 

 

 

 

 

e.

.

 

 

 

 

 

sys

tem without any electrical loads connected, as follows:

ry in a fir

 

 

cycle battery

 

 

 

 

 

 

 

 

 

 

 

t DO NOT allow any open flam

e,

spa

 

 

 

 

REPR

 

 

1. Remove four screws (B) that secure control box front

k, heat, or lit

 

 

 

 

garette

 

 

 

 

 

 

 

 

 

 

 

 

 

to enclosure to expose unit’s circuit breaker.

during and for several minutes

 

 

 

 

 

 

 

 

a

 

 

 

 

 

 

 

 

 

 

 

 

 

ter charging

 

battery.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

2. Connect an accurate frequency meter to line side of

t DO NOT open or mutilate the batter

y.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

generator’s main circuit breaker.

t Wear protective goggles, rubber apron,

 

 

 

 

 

 

 

and

 

 

 

 

 

ubber boots

 

 

 

 

 

 

 

 

 

 

 

B

 

 

 

 

 

rubber gloves.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

B

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

t Remove watches, rings, or other metal objects. t Use tools having insulated handles.

Install the battery as described in Servicing the Battery in the Maintenance section of the Operator’s Manual.

SYSTEM

FAULT CODES

MANUAL

OVER-RIDE

SET

EXERCISE

B

B

3.Set generator’s main circuit breaker to ON (closed) position.

4.Set generator’s system switch to OFF.

26

Page 25 Page 27
Image 26
Page 25 Page 27
Contents Generator Systems Not ReproductionDate of Purchase Generator Where to Find UsFor Future Reference EngineTable of Contents NotSafety Symbols and Meanings ReprFor VictimResulting in minor or moderate injury Maintenance clearances Rect generator operationSystem installed on this engine Control panel for shippingEquipment Description Installing Dealer/Contractor ResponsibilitiesREPROUnpacking Precautions Cold Weather KitShipment Contents Not Reproduction forOwner Information Installation ChecklistReprod Contractor InformationNot Reproductionpage Left Intentionally Blank National Fire Protection Association Nfpa Generator PlacementStandard Nfpa 37 Requirements and Testing RequirementsDoors DbyWindows Is overc meForreproduction Cannot Placement of Standby Generator to Reduce the Risk of FireVertical Clearances Shrubs, or vegetation over 12 inches 30.5 cm Single Structure InstallationsEproduction Two Structure Installations FireElectrical and Fuel Inlet Locations UtionReprod Not For Lifting the GeneratorRepro Access PortsCtion To install side panels ReproductionUP Sted, in accordance with applicable codes Gaseous Fuel SystemGenerator fuel inlet port a and rigidREPRODUCTIONpiping to StandardsUction System Connectors ReprodutionUtility Circuit Connectio Generator AC Connection SystemGrounding the Generator Reprodu Not Transfer Switch CommunicationFault Detection System System Control PanelEngine Oil Final Installation ConsiderationsConcrete Slab Optional Roduction BatteryBattery Specifications Initial Start Up No LoEngine Adjustment Watt Schematic Diagram Watt Wiring Diagram Engine Cool-down Timer Setting Exercise TimerInstallation Inspection Not Reproduction For Not Intentionallyreproductionleft Blank Sistema generador Fecha de compra Generador Información de contactoPara futura referencia MotorSolera de concreto opcional Cubra con grav UtilizaciónInstrucciones importantes de seguridad Instalación NsideracioneSímbolos sobre la seguridad y significados El contacto con  no toque los cables pelados ni las tomas expuestasRecargadas Mueva el generador sin ayuda No ex Pas, deResponsabilidades del pro Responsabilidades del distribuidor/técnico instaladorJuego para climas fríos EtaNo incluye Contenido de la cajaEl sistema de generador de doméstico incluye lo siguiente  #BUFSÓBEFBSSBORVF  $BCMFZDPOEVDUPEFDPOFYJØOLista de control de la instalación Not Reproductionpage Intentionally Left Blank Requisitos y prueb as de la norma Nfpa 37 de National Fire Ection Association NfpaAgote Lado del Generador RequisitosMonóxido de carbono Potencialmente ocupadas Cio Libre Respecto a Estructuras/Vegetación RoductiEspacio libre vertical Espacio Libre Respecto a Estructuras/Vegetación Instalaciones De Una Sola EstructuraInstalaciones de Dos Estructuras Lo menos a 1,5 m 5 pies de las ventanas, puertas, deSoliciten, no es necesario construir una losa de concreto Los cables eléctricos puede provocarEl sistema de generador de doméstico se envía ya unido a Con los cables eléctricosPara abrir una puerta de acceso ReproductioPuertas de acceso Para cerrar una puerta de accesoPara instalar los paneles laterales ProductionPara desmontar el panel de escape Tire del panel de escape B hacia arriba y hacia afueraSistema de combustible gaseoso For PROduction PreguntasConversión de Dimensiones de la cañería de combustibleGas Natural Consumo de combustible75 C-90 C como mínimo Conexiones de sistemaSalida de +12 V CC y 0,5 a Fuente de Generador Tamaño delDe control Sistema de conexión de c.a. del generadorConexión a tierra del generador Interconexiones el circuComunicación del conectador Sistema de detección de fallasConsideraciones finales para la instalación Solera de concreto opcionalCubra con grava Base opcional Aceite de motorArranque inicial sin carga ReproductinBatería Ajuste del motor En onTemporizador de enfriamiento del motor Secuencia de operación automáticaDe electricidad Configuración del temporizador de práctica Inspección posterior a la instalaciónGroupe électrogène Date d’achat Génératrice Où nous trouverPour la future référence NotGlage du moteur Directives de sécurité importantes InstallationFonctionneNOTment Symboles de sécurité et leur signification Direct avec la victime Étincelles conçu pour le système d’échappement installé Conformément aux instructions et recommandations duLa fumée Com Installées Avertissement Tout contact avec la zone duVérification de la livraison Chargé de l’installationReproduti Trousse pour les temps froidsArticles non fournis Contenu de la boîteLe Groupe électrogène est livré avec les éléments suivants Date Liste de vérification d’installationSignature de l’entrepreneur responsable de l’installation Exigences et tests de la norme NFP37 de la ’emplacementRerod National Fire Prot Tion AssociationUler et Not Reproduction for Structures et de la Végétation Dégagement Des Structures et de la Végétation Installations à Une StructureRepr Oduction Installations à Deux Structures ReroductionSoulèvement de la génératrice Pour enlever le toit et le séparateur Ouvrez la porte d’accès du tableau de commandeCommande à OFF Réglez le disjoncteur de la génératrice à la Réglez l’interrupte ur du système du tableau deNot R Roduction Pour retirer le panneau d’échappementRepoduction Le système de combustible gazeuxGrosseur du tuyau de combustible Consommation de combustibleGaz Naturel Vapeur PL PropaneReproducion Connexions de systèmeSystème de branchement c.a. de la génératrice Interconnexion Du circ De commandeMise à la masse de la génératrice Reprodu Tableau de commande du systèmeFusible de 15 ampères Le circuit de commande Communication du commutateur de transfertLa Base de gravier facultatif Mesures de l’emplacement d e perçage pour boulonsOT R Eproduction Huile à moteurEt de BatterieSpécifications de la batterie Réglage du moteur Démarrage initial sans chargeSéquence de fonctionnement automatique De serviceCapteur de Prise en charge de la tension de service Terie de refroidissement du moteurVérification installation Réglage de la minuterie du cycle d’exercice

GEN12AD-V, Generator Systems specifications

Rheem Generator Systems has built a reputation for delivering reliable, high-performance generators, and the GEN12AD-V model is no exception. This innovative generator is designed to provide robust power solutions for residential and light commercial applications, ensuring security and comfort during power outages.

One of the standout features of the GEN12AD-V is its impressive power output. With a maximum output of 12 kW, this generator is capable of powering essential household appliances, heating systems, and air conditioning units during emergencies. This level of output ensures that homeowners can maintain their normal routines without interruption, adding peace of mind in times of need.

The GEN12AD-V is engineered with advanced technologies that promote efficiency and ease of use. One such technology is the automatic start feature, which intelligently detects power outages and activates the generator without any manual intervention. This ensures that the home is powered back up within seconds of a blackout, minimizing inconvenience for residents.

Another notable characteristic of the GEN12AD-V is its ultra-quiet operation. Utilizing advanced muffling technology, the generator produces significantly lower noise levels compared to traditional models. This makes it a suitable choice for neighborhoods where noise restrictions are in place, allowing users to enjoy the benefits of backup power without disturbing their surroundings.

Durability is another key attribute of the GEN12AD-V. Constructed with high-quality materials and components, the generator is built to withstand harsh weather conditions and extensive use. This commitment to durability ensures reliable performance over many years, making it a smart investment for homeowners seeking long-term power solutions.

The generator features an intuitive control panel, which simplifies operation and monitoring. Users can easily access information about fuel levels, generator status, and maintenance alerts, helping them stay informed and proactive about their generator's care.

Overall, the Rheem GEN12AD-V combines power, efficiency, and convenience into a single reliable package. With its automatic start feature, ultra-quiet operation, and durable design, this generator is an exceptional choice for anyone looking to ensure that their home remains powered and secure during unexpected outages. Whether for light commercial applications or home use, the GEN12AD-V stands out as a premium selection in the generator market.
Top Page Image Contents