Southbend STRG-3D, STRG-5D manual StratoSteam Countertop Steamer

Page 1

Owner’s Manual

IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment.

Model #: _________________________

Serial # __________________________

Date Purchased: ___________________

StratoSteam

Countertop Steamer

Models STRG-3D and STRG-5D

Model STRG-3D

Model STRG-5D

WARNING

Improper installation, adjustment, alteration, service, or maintenance can cause property damage, injury, or death. Read installation, operation, and maintenance instructions throroughly before installing or servicing this equipment.

1100 Old Honeycutt Road, Fuquay-Varina, NC 27526 USA • www.southbendnc.com

MANUAL 1185290 $18.00

STRATOSTEAM COUNTERTOP STEAMER MANUAL SECTION STRATOSTEAM

Image 1

Contents StratoSteam Countertop Steamer Safety Precautions Location of Serial Plates IntroductionClearances DimensionsDimensions GAS Pressure Requirements Electrical RequirementsWater Requirements Drain RequirementsStartup Troubleshooting by OperatorOperation ShutdownControls TimerCooking Tips Suggested Cooking Times Daily Cleaning and Maintenance Cleaning & MaintenanceSTAINLESS-STEEL Surfaces Periodic DE-LIMING AS NeededInstallation Unpacking Attach LegsAttach Legs Attach to Countertop Installation on CountertopMounting on Cabinet Base Stacking TWO SteamersDrain Connection Location of Connections and VentsWater Connection Water DrainWater Connection GAS Connection Testing the GAS Supply PipingElectrical Connection SHUT-DOWN and WIPE-CLEAN Steamer Check the InstallationCheck Steamer Operation Service HOW the Steamer Operates Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring DiagramsHow the Steamer Operates Disconnect Power AT Circuit Breaker Steamer Not Heating Up, Power Light Is Not LitCheck that water-supply pressure is adequate Buzzer Does Not Come On When Timer Runs Out Hot Surface Ignitor Glows Red, But Burners Not On Hot Surface Ignitor Does Not Glow Red Not All Burners Ignite Burner Lights But Goes Out Within a Few Seconds Symptom Possible Cause Cure Disconnect Power AT Circuit Breaker Power Switch CheckTimer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt and 115 Volt Models Parts Parts DiagramStructural Parts See parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Burner Assemblies, Thermocouple, and Ignition Module Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Stratosteam Countertop Steamer StratoSteam Countertop Steamer Models STRG-3D STRG-5D