Southbend STRG-5D, STRG-3D manual Timer, Controls

Page 8

OPERATION

STRATOSTEAM COUNTERTOP STEAMER

Figure 3

Controls

TIMER	0
OFF		5
		5

Timer

Set for up to 60 minutes as a reminder to operator. DOES

60

55

50

10

15

20

25

NOT CONTROL STEAMER. When buzzer sounds, turn knob counterclockwise to silence the buzzer.

45

4030

35

		180	190
		160	200
	140	70 80	90	210
	140	70 80	90
	120	60	105	220
	120	50	105	220
	100	40	110	230
	100	0°C	115
	80	0°C	115

40240

°F

Power

OFF

Thermometer

Indicates temperature in cooking cavity. Steamer is “ready to cook” when temperature reaches 190°F (88°C).

Power Light

Lights when the steamer has electric power and Control Lever is turned to ON.

Control Lever

Turn to ON to cook. Steamer will reach cooking temperature in about 4 minutes. Turn to OFF to shut down or to conserve

water and electricity duringON idle periods.

PAGE 8 OF 50

OWNER’S MANUAL 1185290

Image 8

Contents StratoSteam Countertop Steamer Safety Precautions Introduction Location of Serial PlatesDimensions ClearancesDimensions Electrical Requirements GAS Pressure RequirementsWater Requirements Drain RequirementsTroubleshooting by Operator StartupOperation ShutdownTimer ControlsCooking Tips Suggested Cooking Times Cleaning & Maintenance Daily Cleaning and MaintenancePeriodic DE-LIMING AS Needed STAINLESS-STEEL SurfacesInstallation Attach Legs Attach LegsUnpacking Installation on Countertop Attach to CountertopMounting on Cabinet Base Stacking TWO SteamersLocation of Connections and Vents Drain ConnectionWater Connection Water DrainWater Connection Testing the GAS Supply Piping GAS ConnectionElectrical Connection Check Steamer Operation Check the InstallationSHUT-DOWN and WIPE-CLEAN Steamer Service Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring Diagrams HOW the Steamer OperatesHow the Steamer Operates Steamer Not Heating Up, Power Light Is Not Lit Disconnect Power AT Circuit BreakerCheck that water-supply pressure is adequate Buzzer Does Not Come On When Timer Runs Out Hot Surface Ignitor Glows Red, But Burners Not On Hot Surface Ignitor Does Not Glow Red Not All Burners Ignite Burner Lights But Goes Out Within a Few Seconds Symptom Possible Cause Cure Power Switch Check Disconnect Power AT Circuit BreakerTimer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt and 115 Volt Models Parts Diagram PartsStructural Parts See parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Burner Assemblies, Thermocouple, and Ignition Module Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Stratosteam Countertop Steamer StratoSteam Countertop Steamer Models STRG-3D STRG-5D