Southbend STRG-5D, STRG-3D manual Buzzer Does Not Come On When Timer Runs Out

Page 26

SERVICE

STRATOSTEAM COUNTERTOP STEAMER

Figure 13

Buzzer Does Not Come On When Timer Runs Out

Buzzer does not come on when timer runs out.

DISCONNECT POWER AT CIRCUIT BREAKER

Remove right side panel for access.

Set timer for 5 minutes.

No	Does timer time down?	Yes

Replace timer.

Disconnect buzzer lead wires from the timer.

Check the timer (see page 33).

No

Timer OK?

Yes

Replace timer.

Replace buzzer.

PAGE 26 OF 50

OWNER’S MANUAL 1185290

Image 26

Contents StratoSteam Countertop Steamer Safety Precautions Introduction Location of Serial PlatesDimensions ClearancesDimensions Water Requirements Electrical RequirementsGAS Pressure Requirements Drain RequirementsOperation Troubleshooting by OperatorStartup ShutdownTimer ControlsCooking Tips Suggested Cooking Times Cleaning & Maintenance Daily Cleaning and MaintenancePeriodic DE-LIMING AS Needed STAINLESS-STEEL SurfacesInstallation Attach Legs Attach LegsUnpacking Mounting on Cabinet Base Installation on CountertopAttach to Countertop Stacking TWO SteamersLocation of Connections and Vents Drain ConnectionWater Connection Water DrainWater Connection Testing the GAS Supply Piping GAS ConnectionElectrical Connection Check Steamer Operation Check the InstallationSHUT-DOWN and WIPE-CLEAN Steamer Service Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring Diagrams HOW the Steamer OperatesHow the Steamer Operates Steamer Not Heating Up, Power Light Is Not Lit Disconnect Power AT Circuit BreakerCheck that water-supply pressure is adequate Buzzer Does Not Come On When Timer Runs Out Hot Surface Ignitor Glows Red, But Burners Not On Hot Surface Ignitor Does Not Glow Red Not All Burners Ignite Burner Lights But Goes Out Within a Few Seconds Symptom Possible Cause Cure Power Switch Check Disconnect Power AT Circuit BreakerTimer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt and 115 Volt Models Parts Diagram PartsStructural Parts See parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Burner Assemblies, Thermocouple, and Ignition Module Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Stratosteam Countertop Steamer StratoSteam Countertop Steamer Models STRG-3D STRG-5D