Southbend STRG-5D, STRG-3D manual Door Switch Check

Page 34

SERVICE

STRATOSTEAM COUNTERTOP STEAMER

Figure 20

Door Switch Check

1.DISCONNECT POWER AT CIRCUIT BREAKER.

2.Remove right side panel.

3.Open and close the steamer’s door while looking to see that the door switch actuator rod actuates the door switch when the rod moves.

4.Disconnect the wiring harness from the switch terminals at the two places shown above (where the test-probe tips are located).

5.Place the test probes on the switch terminals (as shown above).

6.Check for continuity with the door open (there should NOT be continuity).

7.Check for continuity when the door is closed (there should be continuity).

8.If the continuity checks are not correct, replace the door switch.

9.Reconnect the wiring harness to the switch terminals.

PAGE 34 OF 50

OWNER’S MANUAL 1185290

Image 34

Contents StratoSteam Countertop Steamer Safety Precautions Introduction Location of Serial PlatesDimensions ClearancesDimensions Water Requirements Electrical RequirementsGAS Pressure Requirements Drain RequirementsOperation Troubleshooting by OperatorStartup ShutdownTimer ControlsCooking Tips Suggested Cooking Times Cleaning & Maintenance Daily Cleaning and MaintenancePeriodic DE-LIMING AS Needed STAINLESS-STEEL SurfacesInstallation Unpacking Attach LegsAttach Legs Mounting on Cabinet Base Installation on CountertopAttach to Countertop Stacking TWO SteamersLocation of Connections and Vents Drain ConnectionWater Connection Water DrainWater Connection Testing the GAS Supply Piping GAS ConnectionElectrical Connection SHUT-DOWN and WIPE-CLEAN Steamer Check the InstallationCheck Steamer Operation Service Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring Diagrams HOW the Steamer OperatesHow the Steamer Operates Steamer Not Heating Up, Power Light Is Not Lit Disconnect Power AT Circuit BreakerCheck that water-supply pressure is adequate Buzzer Does Not Come On When Timer Runs Out Hot Surface Ignitor Glows Red, But Burners Not On Hot Surface Ignitor Does Not Glow Red Not All Burners Ignite Burner Lights But Goes Out Within a Few Seconds Symptom Possible Cause Cure Power Switch Check Disconnect Power AT Circuit BreakerTimer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt and 115 Volt Models Parts Diagram PartsStructural Parts See parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Burner Assemblies, Thermocouple, and Ignition Module Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Stratosteam Countertop Steamer StratoSteam Countertop Steamer Models STRG-3D STRG-5D