Southbend STRG-5D, STRG-3D manual Burner Assemblies, Thermocouple, and Ignition Module

Page 44

SERVICE

STRATOSTEAM COUNTERTOP STEAMER

Figure 28

Burner Assemblies, Thermocouple, and Ignition Module

Key

 

Part Number

Quantity*

Description

 

 

 

 

 

 

 

1

 

1185212

4

IR BURNER ASSEMBLY, NATURAL GAS

 

 

1188651

4

IR BURNER ASSEMBLY, PROPANE

2

 

1185237

1

BURNER BOX, STRATOSTEAM GAS

3

 

1183200

1

HOT SURFACE IGNITOR

4

 

1175127

1

FLAME SENSOR

5

 

1185264

2

BRACKET, BURNER HOLD DOWN

6

 

1175723

1

IGNITION MODULE

7

 

1172277

1

24V AC TRANSFORMER

8

 

1175547

1

GROUND LUG

9

 

1170335

1

6 POSITION TERMINAL BLOCK

10

 

1-3195

1

FITTING, BRASS, 68C-8-8

11

 

7-5771

1

VALVE, SHUT OFF, 1/2”

12

 

1146909

1

ELBOW, ST., BLK, 1/2” 90 DEG

13

 

1175016

1

VALVE, NAT GAS, G-CO

 

 

1175375

1

VALVE PROPANE, G-CO

14

 

1182962

1

NIPPLE .75 X 2.50” LG.

15

 

1185258

1

MANIFOLD S/A

16

 

1185273

1

GAS INLET W/A

*

Quantity of part used may depend on model (STRE-3D or SRTE-5D).

PAGE 44 OF 50

OWNER’S MANUAL 1185290

Page 43 Page 45
Image 44
Page 43 Page 45
Contents StratoSteam Countertop Steamer Safety Precautions Introduction Location of Serial PlatesDimensions ClearancesDimensions Electrical Requirements GAS Pressure RequirementsWater Requirements Drain RequirementsTroubleshooting by Operator StartupOperation ShutdownTimer ControlsCooking Tips Suggested Cooking Times Cleaning & Maintenance Daily Cleaning and MaintenancePeriodic DE-LIMING AS Needed STAINLESS-STEEL SurfacesInstallation Attach Legs Attach LegsUnpacking Installation on Countertop Attach to CountertopMounting on Cabinet Base Stacking TWO SteamersLocation of Connections and Vents Drain ConnectionWater Connection Water DrainWater Connection Testing the GAS Supply Piping GAS ConnectionElectrical Connection Check Steamer Operation Check the InstallationSHUT-DOWN and WIPE-CLEAN Steamer Service Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring Diagrams HOW the Steamer OperatesHow the Steamer Operates Steamer Not Heating Up, Power Light Is Not Lit Disconnect Power AT Circuit BreakerCheck that water-supply pressure is adequate Buzzer Does Not Come On When Timer Runs Out Hot Surface Ignitor Glows Red, But Burners Not On Hot Surface Ignitor Does Not Glow Red Not All Burners Ignite Burner Lights But Goes Out Within a Few Seconds Symptom Possible Cause Cure Power Switch Check Disconnect Power AT Circuit BreakerTimer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt and 115 Volt Models Parts Diagram PartsStructural Parts See parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Burner Assemblies, Thermocouple, and Ignition Module Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Stratosteam Countertop Steamer StratoSteam Countertop Steamer Models STRG-3D STRG-5D
Top Page Image Contents