Southbend STRG-3D, STRG-5D manual Door Assembly Parts

Page 41

STRATOSTEAM COUNTERTOP STEAMER

SERVICE

Figure 25

Door Assembly Parts

2

1

13

3

4

5

6

7

8

	10	9
	10
11
		15	16	18	19
12		15			19
12		14		17
				17

Note: The entire door, assembled, can be ordered (see page 39).

Key	Part Number	Qty	Description
1	1177317	1	LATCH ASSEMBLY
2	1177344	4	SCREW, #10-24 X 3/4 SLOTTED HEX
3	1146527	6	WASHER #10 LOCK, SS, 300
4	1146526	4	WASHER, #10, FLAT
5	1185053	1	PANEL W/A, R2 STACKABLE
6	1185028	2	HINGE PLATE W/A
7	1185115	1	GASKET, DOOR R2 REDESIGN
8	1146268	2	BOLT, 1/4-20 X 5/8 HEX HEAD, SS
9	6600412	2	LOCK WASHER, SS
10	1177086	1	RETAINER
11	1185048	1	TRAY, DOOR CONDENSATION
12	1146390	4	SCREW, 10-24 X 1/2, SS, TRUSS SLOT
13	PH-292	2	NYLON WASHER, 1/4 X 1/2 X 1/8
14	1185029	1	INSULATION, DOOR
15	1185023	1	SUPPORT W/A , DOOR GASKET
16	1173254	8	SCREW, 6-32 X 3/4, SELF TAP
17	1185118	1	RETAINER, DOOR GASKET
18	1180460	4	WASHER, FLAT #10
19	1173224	4	SCREW, 1/2-20 X 5/8 S, SLOT TRS

OWNER’S MANUAL 1185290

PAGE 41 OF 50

Image 41

Contents StratoSteam Countertop Steamer Safety Precautions Location of Serial Plates IntroductionClearances DimensionsDimensions GAS Pressure Requirements Electrical RequirementsWater Requirements Drain RequirementsStartup Troubleshooting by OperatorOperation ShutdownControls TimerCooking Tips Suggested Cooking Times Daily Cleaning and Maintenance Cleaning & MaintenanceSTAINLESS-STEEL Surfaces Periodic DE-LIMING AS NeededInstallation Attach Legs Attach LegsUnpacking Attach to Countertop Installation on CountertopMounting on Cabinet Base Stacking TWO SteamersDrain Connection Location of Connections and VentsWater Connection Water DrainWater Connection GAS Connection Testing the GAS Supply PipingElectrical Connection Check Steamer Operation Check the InstallationSHUT-DOWN and WIPE-CLEAN Steamer Service HOW the Steamer Operates Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring DiagramsHow the Steamer Operates Disconnect Power AT Circuit Breaker Steamer Not Heating Up, Power Light Is Not LitCheck that water-supply pressure is adequate Buzzer Does Not Come On When Timer Runs Out Hot Surface Ignitor Glows Red, But Burners Not On Hot Surface Ignitor Does Not Glow Red Not All Burners Ignite Burner Lights But Goes Out Within a Few Seconds Symptom Possible Cause Cure Disconnect Power AT Circuit Breaker Power Switch CheckTimer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt and 115 Volt Models Parts Parts DiagramStructural Parts See parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Burner Assemblies, Thermocouple, and Ignition Module Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Stratosteam Countertop Steamer StratoSteam Countertop Steamer Models STRG-3D STRG-5D