Southbend STRG-3D, STRG-5D manual Not All Burners Ignite

Page 29

STRATOSTEAM COUNTERTOP STEAMER

SERVICE

Figure 16

Not All Burners Ignite

		Not all burners ignite.
		Is gas pressure at least 4” WC for
	No	Is gas pressure at least 4” WC for	Yes
	No	natural gas and at least 11” WC for	Yes


		propane?

Adjust gas pressure to correct

level.

No	Is orifice correctly aligned with burner?	Yes

Align burners and orifices.

Make sure burner orifice are clear

and the correct size.

Natural Gas #54, Propane #64

are installed.

OWNER’S MANUAL 1185290

PAGE 29 OF 50

Image 29

Contents StratoSteam Countertop Steamer Safety Precautions Location of Serial Plates IntroductionClearances DimensionsDimensions GAS Pressure Requirements Electrical RequirementsWater Requirements Drain RequirementsStartup Troubleshooting by OperatorOperation ShutdownControls TimerCooking Tips Suggested Cooking Times Daily Cleaning and Maintenance Cleaning & MaintenanceSTAINLESS-STEEL Surfaces Periodic DE-LIMING AS NeededInstallation Attach Legs Attach LegsUnpacking Attach to Countertop Installation on CountertopMounting on Cabinet Base Stacking TWO SteamersDrain Connection Location of Connections and VentsWater Connection Water DrainWater Connection GAS Connection Testing the GAS Supply PipingElectrical Connection Check Steamer Operation Check the InstallationSHUT-DOWN and WIPE-CLEAN Steamer Service HOW the Steamer Operates Troubleshooting FLOWCHARTS, PROCEDURES, and Wiring DiagramsHow the Steamer Operates Disconnect Power AT Circuit Breaker Steamer Not Heating Up, Power Light Is Not LitCheck that water-supply pressure is adequate Buzzer Does Not Come On When Timer Runs Out Hot Surface Ignitor Glows Red, But Burners Not On Hot Surface Ignitor Does Not Glow Red Not All Burners Ignite Burner Lights But Goes Out Within a Few Seconds Symptom Possible Cause Cure Disconnect Power AT Circuit Breaker Power Switch CheckTimer and Buzzer Check Door Switch Check High-Limit Thermostats Check Water Solenoid Check Wiring Diagram for 208/220/240 Volt and 115 Volt Models Parts Parts DiagramStructural Parts See parts list on previous Door Assembly Parts Door Switch Parts Control Panel Parts Burner Assemblies, Thermocouple, and Ignition Module Water Train Parts Water-Train Parts Cabinet Base Parts Cabinet-Base Parts Stratosteam Countertop Steamer StratoSteam Countertop Steamer Models STRG-3D STRG-5D