Honda Power Equipment MM60 manual Detaching Mower from Tractor

Page 27

INSTALLING MOWER

DETACHING MOWER FROM TRACTOR

Detaching Front Links

NOTE: If mower deck hook is engaged to hold mower deck up, deck must be raised and hook released before mower can be detached.

1.Pull locking pins on mower wheels and set wheels so that mower is high as possible. This will make removing quick release.pinson links easier.

2.Pull right and left front quick release pins by pulling back on pin and turning until spring pin catches and holds in slot in front link bracket. Hold front link and lower it to ground. Repeat for other side.

Mower deck will descend when front links are released. Keep fingers and feet from being caught below the mower to avoid injury.

Detaching Rear Links

1.Pull locking pin on left rear link and draw it towards you to remove. If rear link cannot be detached easily, shake the mower back and forth with foot, until rear link comes loose.

NOTE: Be careful not to get your fingers caught between the rear arms of the lift plate assembly and the mower deck. Arms come down when pin is detached.

I

Front Mower Links Detach From Tractor

Rear Mower Links Detach From Tractor

25

Image 27

Contents Page Page To the Owner IntroductionGeneral INFORMATlON IntroductionContents Operate equipment Safety InformationPreparation Safety InformationBlock mower securely for storage Maintenance SafetyReplace immediately if damaged Safety InformationSET-UP and Assembly SET-UP and Assembly SET-UP and Assembly Point out safety features, shielding and optionsPre-Delivery Check List Dealer Responsibility Finish by tightening two 26 mm flange locknuts SET-UPAND AssemblyLift Unk SET-UP and Assembly ‘y85 mm With Three Point Subassembling Front Link Brackets Assemble both right and left bracketsMounting Front Link Bracket to.Tractor Installing Deck Hooks Installing MowerLevel the mower to assure proper cut. Mower Installing Front Anti-ScalpingRoller Installing MowerRemove level plug Add oil until it seeps out level plug hole Install both plugsAttaching Front Mower Links To Mower Side. Insert linchpin to lock~~~ Attaching Front Mower Links to Front Bracket Lift Arms Fasten to Mower Deck Detaching Mower from Tractor Joint Detaches From Mid-PTO Tor to 4-wheel drive position Switch off engine after moving tractor off mower. Set brakesOperation Operation PRE-OPERATION Check List Tours A small area Operating Your Mower with Other Equipment Installing Mower‘ by mower deck hook Install attachment as needed Owner Service Maintenance30W Oil Oil Level Plug Caster Pivot Hrs Caster Wheel Blade SpindlesDriveshaft U-joints Hrs Driveshaft Slip Joint Hrs Spring Take-up Pivot ArmBlade Inspection Blade Servicing Blade InstallationMaintenance Belt Assembly Maintenance Sleeve Bearing cone Housing and cups Cup Shaft Spindle assembly @Remove bearing cone from shaft Spindle AssemblyProper adjustment is attained T1I Yoke Journal cross Seal Snap ring Cup and bearings Universal Joint AssemblyAndhammer L11Remove gearbox from stand Gearbox MaintenanceGear Box Split taper bushing Drive pulley Gearbox stand Key Storage StorageTroubleshooting ProblemSolution Troubleshooting Specifications Owner Satisfaction Warranty Service