Honda Power Equipment MM60 manual Safety Information, Replace immediately if damaged

Page 9

SAFETY INFORMATION

Safety Decals

Replace immediately if damaged.

OF OPERATION

TO AVOID SERIOUS INJURY OR DEATH!

	READOPERATORSMANUALSFOLLOW			KHOW now TO STOP TRACTOR AND
	ALL SAFETY PI4ECAUTIONS.			EOUIPMENT OUICKLV IN AH EMERGENCY.
	I C I I . C I w.LtPr(rn*.IY.,,I			BLOCK UP IMPLEMENT AND HEMOVE
	W.ELW!FLQS	AND GUARDS m PLACE
				KEY DEFORE WORKING UHOERNEATN.

	UEEP_UELR-W.D_RIVU AH0 9CLIS:			ALLOW NO W L D R E N OH UNOUALIFIED
	LOWER IUPLEMENL STOP ENGINE AND			C E i N Z 10 RUN EOUIPMENT.
	I(LM0VE UEV REFORE DISMOUNTING.
				BE CAREFUL ON UNEVEN TERRAIN.
	CLEAR MOWING AREA OF DEBRIS.			DECREASE SPEED WNEN WRNING.
	Pa NOT OPERaTE MOWER IN V I C W ~			DO NOT OPERATE IN TRANSPORT
				..." .

IMPORTANT

FILL GEAR BOX TO CENTER

LINE OF HORIZONTAL SHAFT.

USE SA€ 90 GEAR LUBE.

ALLOW TIME FOR OIL TO

FLOW THRU BEARINGS.

THEN RECHECK.

. .

PTO SPEEO MUST N OT I

EXCEED 2400 RPM.

LOCK DRIVRINE ON

TRACTOR PTO.

.i A LOOSE DRlVELlNE OR A

HIGHER PTO RPM CAN CAUSE PERSONAL INJURV AN0 EQUIPMENT FAILURE.

7

Image 9

Contents Page Page To the Owner IntroductionGeneral INFORMATlON IntroductionContents Operate equipment Safety InformationPreparation Safety InformationBlock mower securely for storage Maintenance SafetyReplace immediately if damaged Safety InformationSET-UP and Assembly SET-UP and Assembly SET-UP and Assembly Point out safety features, shielding and optionsPre-Delivery Check List Dealer Responsibility Finish by tightening two 26 mm flange locknuts SET-UPAND AssemblyLift Unk SET-UP and Assembly ‘y85 mm With Three Point Subassembling Front Link Brackets Assemble both right and left bracketsMounting Front Link Bracket to.Tractor Installing Deck Hooks Installing MowerLevel the mower to assure proper cut. Mower Installing Front Anti-ScalpingRoller Installing MowerRemove level plug Add oil until it seeps out level plug hole Install both plugsAttaching Front Mower Links To Mower Side. Insert linchpin to lock~~~ Attaching Front Mower Links to Front Bracket Lift Arms Fasten to Mower Deck Detaching Mower from Tractor Joint Detaches From Mid-PTO Tor to 4-wheel drive position Switch off engine after moving tractor off mower. Set brakesOperation Operation PRE-OPERATION Check List Tours A small area Operating Your Mower with Other Equipment Installing Mower‘ by mower deck hook Install attachment as needed Owner Service MaintenanceDriveshaft U-joints Hrs Caster Pivot Hrs Caster Wheel Blade SpindlesDriveshaft Slip Joint Hrs Spring Take-up Pivot Arm 30W Oil Oil Level PlugBlade Inspection Blade Servicing Blade InstallationMaintenance Belt Assembly Maintenance Sleeve Bearing cone Housing and cups Cup Shaft Spindle assembly @Remove bearing cone from shaft Spindle AssemblyProper adjustment is attained T1I Yoke Journal cross Seal Snap ring Cup and bearings Universal Joint AssemblyAndhammer L11Remove gearbox from stand Gearbox MaintenanceGear Box Split taper bushing Drive pulley Gearbox stand Key Storage StorageTroubleshooting ProblemSolution Troubleshooting Specifications Owner Satisfaction Warranty Service