Honda Power Equipment MM60 manual Installing Mower, ‘ by mower deck hook

Page 36

INSTALLING MOWER

4. Place other attachment on Rear Three Point Hitch . Mower deck will be held out of the way

‘ by mower deck hook.

NOTE: The mower deck will be raised a small amount when Lift Control Lever in fully “UP” position. This is due to the play in the mower deck hook and will not affect the operation of the Rear Three Point Hitch or attachment.

Unlocking Mower Hook

1. Start engine and set Lift Control Lever on “UP” to raise lift arms to maximum position.Turn off engine, turn Lowering Speed Control fully clockwise to lock hydraulic system and set brakes.

2. Remove clevis pin and use fool to pull mower hook off of lockup pin. Use caution since hook may be under pressure.

! . - Mower hook may be under tension. Set Lift Control Lever to “UP” and raise arm to take tension off hook before detaching. Turn engine off so that lift arm cannot move. Wear heavy gloves and keep fingers away from lift arms to avoid injury.

3 4

Image 36

Contents Page Page Introduction To the OwnerIntroduction General INFORMATlONContents Safety Information Operate equipmentSafety Information PreparationMaintenance Safety Block mower securely for storageSafety Information Replace immediately if damagedSET-UP and Assembly SET-UP and Assembly SET-UP and Assembly Point out safety features, shielding and optionsPre-Delivery Check List Dealer Responsibility SET-UPAND Assembly Finish by tightening two 26 mm flange locknutsLift Unk SET-UP and Assembly ‘y85 mm With Three Point Subassembling Front Link Brackets Assemble both right and left bracketsMounting Front Link Bracket to.Tractor Installing Mower Installing Deck HooksLevel the mower to assure proper cut. Mower Installing Mower Installing Front Anti-ScalpingRollerInstall both plugs Remove level plug Add oil until it seeps out level plug holeSide. Insert linchpin to lock Attaching Front Mower Links To Mower~~~ Attaching Front Mower Links to Front Bracket Lift Arms Fasten to Mower Deck Detaching Mower from Tractor Joint Detaches From Mid-PTO Switch off engine after moving tractor off mower. Set brakes Tor to 4-wheel drive positionOperation Operation PRE-OPERATION Check List Tours A small area Installing Mower Operating Your Mower with Other Equipment‘ by mower deck hook Install attachment as needed Maintenance Owner ServiceCaster Pivot Hrs Caster Wheel Blade Spindles Driveshaft U-joints HrsDriveshaft Slip Joint Hrs Spring Take-up Pivot Arm 30W Oil Oil Level PlugBlade Inspection Blade Installation Blade ServicingMaintenance Belt Assembly Maintenance Spindle assembly @ Sleeve Bearing cone Housing and cups Cup ShaftSpindle Assembly Remove bearing cone from shaftProper adjustment is attained T1I Universal Joint Assembly Yoke Journal cross Seal Snap ring Cup and bearingsL11 AndhammerGearbox Maintenance Remove gearbox from standGear Box Split taper bushing Drive pulley Gearbox stand Key Storage StorageTroubleshooting ProblemSolution Troubleshooting Specifications Warranty Service Owner Satisfaction