Approval | Honeywell MKXXII manual

Honeywell

MK XXII EGPWS Installation Manual

associated ID is read from the Configuration Module and listed on the PC display. Alternately, when not in the Configuration sub-mode, the command “PS<Enter>” (Present Status) will display the EGPWC and Configuration Module data.

7. Configuration Module reprogramming is complete.

4.6Regional Terrain Data base Loading 4.6.1 Effectivity

The MK XXII EGPWS (965-1590-0XX) are shipped from the factory with the North American Regional Terrain Database installed. Aircraft operating outside of the North American region will have to load one of the other eight Regional Terrain Databases before beginning the ground test. Use (operation) of a MK XXII EGPWS outside of the loaded Regional Terrain Database will result in the Terrain Awareness function being unavailable.

4.6.2 Description

This modification consists of loading the PCMCIA card into the EGPWS either In The Aircraft or On The Bench. An optional verification procedure is provided.

4.6.3 Approval

This procedure contains no modification information that revises the approved configuration and therefore does not require FAA or other regulatory agency approval.


CAGE CODE:		SCALE: NONE SIZE: A DWG NO: 060-4314-225						REV: C	115
97896		SCALE: NONE SIZE: A DWG NO: 060-4314-225						REV: C		SHEET
97896

Image 115

Honeywell MKXXII installation manual Regional Terrain Data base Loading 4.6.1 Effectivity, Approval

Contents

Release Date 12/14/00 REV C Sheet ALL Revisions REV Description Honeywell MK Xxii Egpws Installation Manual Table of Contents Honeywell MK VI MK Viii Egpws Installation Design Guide Honeywell MK VI MK Viii Egpws Installation Design Guide 104 Section V Certification 160 143149 158 Aircraft Application Data Section General Information Honeywell MK Xxii Egpws Installation Manual Section I General Information License Requirements Introduction How To Use This Docu mentApplicability Reference Documents Description of Equipm ent OAT Sensor MK Xxii Egpws Comp uterMK Xxii Egpws Conf iguration Module GPS Antenna Smart Cable Pcmcia Interface Technical Characteris tics MK Xxii Egpws Smart Cable Units Supplied Configuration ModuleMK Xxii Egpws Honeywell MK Xxii Egpws Installation Manual Smart Cable Installation and Acces sories KitsNew Egpws installation with Internal GPS 2 RS-232 Cable Flight History Card Terrain Database Card s Circuit Breaker GPS Antenna & cableAnnunciators & Switc h/Annunciators Cockpit Speaker Opti onal Spare Contacts P1, P 2, P3 Tools Required Crimping Tool P1, P 2, P3Contact Positioner P 1, P2, P3 Insertion/Removal Too l P1, P2, P3 Honeywell MK Xxii Egpws Installation Manual Section Installation Honeywell MK Xxii Egpws Installation Manual Section II Installation Unpacking and Inspec ting the Equipment Equipment Installation 2.3.1 General MK Xxii Computer Ins tallation MK Xxii Computer Loc ation Configuration Module Installation Configuration Module Location Required Configuration Module Assembly 1 MK Xxii Egpws Configuration Module Installation Assembly Sequence 2 MK Xxii Egpws Configuration Module 3 MK Xxii Egpws Configuration Module 4 MK Xxii Egpws Configuration Module 5 MK Xxii Egpws Configuration Module 6 MK Xxii Egpws Configuration Module 7 MK Xxii Egpws Configuration Module GPS Antenna location GPS Antenna Installat ionOAT Sensor Installatio n Cockpit Annunciators / Switches Egpws cautionGPWS G/S Cancld Description Gpws warning red & Gpws alert amber Location 8 MK Xxii Egpws Annunciators/Switches Location Audio Inhibit Timed Inhibit Switch Functio ns and SelectionLow Altitude Mode Terrain Inhibit MK Xxii Egpws Outline Honeywell P/N 405-0383-001 MK Xxii Egpws Mounting Tray Honeywell MK Xxii Egpws Installation Manual Section System Planning Honeywell MK Xxii Egpws Installation Manual Section III System Planning Category 8 Radio Altitude Input Select Category 14 Audio Output Level Primary Power Input System Wiring/ Electr ical InterfacesChassis Ground Discrete Inputs Analog and Digital Inp utsSerial Outputs Discrete Outputs Audio Output Instructions Configurable Interface sCategory 1 Aircraft / Mode Type Select Aircraft / Mode Type Category 2 Air Data Input Select Egpws MK Examples Analog altitude and 500 ohm OAT Digital Arinc 429 Cat ID 5, 1 Arinc Digital -ARINC 575 Cat ID Shadin 2000 Cat ID Digital Arinc 429 Dual IOC Buses Cat . ID Arinc 743 Format Category 3 Position Input Select 3.2 RS-232 Transmit-Receive, 9600 baud Cat ID Examples Arinc 429 BUS Cat ID 0,1,4,5 Dual Arinc 429 BUS Cat ID Category 4 Altitude Callouts Category 5 Audio Menu Select TAD Selection Category 6 Terrain Display Select Type of sweep used for terrain data fan, standard, etc Terrain Display Configuration Group 6-1 Single Tube Wx/Terrain Display Output 429 Bus Group Display Input Control GroupExample TRA-45A Egpws J101 Egpws Avidyne FSD Honeywell WRX R/T Honeywell Radar Indicator Arinc 429 Range #1 Arinc 429 Range #2 Kcpb Video #1 Out Avtech DSU Steep Approach Not Available in the Mk Category 7 Options Select Group #17.3 TA&D Alternate Pop-up Obstacle Awareness Peaks ModeBank Angle Callout Enabling GPS Altitude Reference WOW Reversal Example Digital Radio Altitude Interface Category 8 Radio Altitude Input Select Analog Radio Altitude Interface DH Discrete Gnd Valid Radio Altimeter Indicator Category 9 Navigation Inputs Select RNA-34A Example Analog Glideslope Interface cat ID 0,1,5 Dual Glideslope Receiver Digital Glideslope/Localizer Interface Category 10 Attitude Input Select Attitude Signals Vertical Gyro Example Analog Roll Angle Synchro Ahrs Digital Arinc 429 High Speed Magnetic Heading Category 11 Heading Input Select Directional Gyro Example Analog Heading Synchro CAT ID Heading High Speed Instruction Category 12 Windshear Input Select Input/Output Discretes Category 13 Input / Output Discrete Type Select Audio Inhibit Discrete Weight on Wheels WOW DiscreteLanding Gear Discrete Mode 6 Low Volume Discrete Glideslope Cancel DiscreteAutopilot Engaged Discrete Self Test Discrete Terrain Awareness InhibitGlideslope Inhibit Discrete Lamp Format Low Altitude Mode Select DiscreteTimed Audio Inhibit Discrete Output Discretes Gpws Alert Discrete Gpws Inop DiscreteTAD Inop Discrete Gpws Warning Discrete Terrain Display Select #1 & #2 Discrete Low Altitude Mode Discrete REV C Sheet Ohm Category 14 Audio Output Level Category 15, Autorotation Threshold Autorotation Threshold 107 108 1 RS-232 Communicatio n with the MK Xxii Egpws Harness Checkout and Power CheckUnit Installation Egpwc Initialization a nd Configuration WinVIEWS Egpwc Front Panel T est Connector WinVIEWS Operation Configuration Module Programming 112 CFG CUW 0/15 128 3 2 134 128 3 29 1 0 2 0 0 129 0 CUW and CMR Comm ands CATspacecategory #spaceID#spaceT or FEnter Configuration Module Reprogramming Approval Regional Terrain Data base Loading 4.6.1 Effectivity Material Cost and Av ailability Accomplishment Instr uctions Verification of the Ter rain Database Version END of Test 120 Section Certification Honeywell MK Xxii Egpws Installation Manual Section V Certification Ground Test Certification Procedur e Equipment Compatibi lityEquipment Location FAA Requirements Existing STC’s Failure Modes, Effects , and Safety AnalysisFlight Test Pilots Guide Honeywell MK Xxii Egpws Installation Manual Appendix a Customer Worksheet Honeywell MK Xxii Egpws Installation Manual Cockpit Displays MK Xxii Egpws GPS Parameter Discrete Inputs Generic Model Information System REV C Sheet REV C Sheet REV C Sheet REV C Sheet REV C Sheet Appendix B Sample Wiring Diagrams DWG no 060-4314-225 Revc Sheet Honeywell MK Xxii Egpws Installation Manual Honeywell MK Xxii Egpws Installation Manual Appendix C Honeywell MK Xxii Egpws Installation Manual Baud, No Parity, 8 bits, and 1 stop bit RS-232 Communication with the Egpws REV C Sheet REV C Sheet Honeywell MK Xxii Installation Manual Appendix D Vendor Drawings Honeywell MK Xxii Egpws Installation Manual AMP Vendor Contact Information For orders and AOG requirements, contact D1-1 Edmo D1-2 Emteq GPS RF Cable Sets Inches Bend Radius Minimum Per 100 ft 1 Connectors for Tflx cable series GPS 1 Connectors for Pflx cable series GPS Tool Frame and Die Part Numbers Installation Considerations D1-3 Aerospace Optics Aerospace Optics Inc Mail switches@vivisun.com StacoSwitch Appendix E Interface Description Document Honeywell MK Xxii Egpws Installation Manual Honeywell MK Xxii Egpws Installation Manual Connector Interface Purpose Introduction Part NumberSystem Overview Chassis Ground Signal InterfacesPrimary Power Input Electrical Interface Introduction Localizer Deviation or LOW Level Glideslope Validity DC Analog InputsRadio Altitude LOW Level Glideslope Barometric Altitude Outside AIR TemperatureConfiguration Defined DC Inputs 2.4 2.7.2 AC Analog Inputs2.7.1 Synchro Roll Attitude Signal Timing Reference Inputs Configuration Defined Synchro Inputs Arinc 429/575 Digital Serial BUS Inputs 2.9 GPS RS-232 Digital Serial BUS Serial Port 2.9.1 RS-232 / RS-422 Digital Serial BUS InputsGPS RS-422 Digital Serial BUS Serial Port SCI Range RS-422 Digital Serial BUS Serial Port +28 VDC Discrete CharacteristicsAIR Data RS-232 Digital Serial BUS Serial Port AIR Data RS-422 Digital Serial BUS Serial Port Ground Discrete Characteristics Configuration Module InterfaceGPS Antenna Input Lamp Driver Outputs Monitor Output CharacteristicsDiscrete Output Characteristics OAT Voltage Reference Output Arinc 429 Output BUS High Level Speaker Audio OutputLOW Level Interphone Audio Output Arinc Digital Serial Output Busses Arinc 453 Output BUS 2.18.1 RS-232 Maintenance Port Serial PortFront Panel Test Interface Pcmcia / Smartcable Port Front Panel Status IndicatorsGSE Present Discrete Input Configuration Selection Configuration TypesAircraft Application Data Table E 3 Category ID Selection Procedure Signal SelectionInstruction Configuration Selection Tables Category 1, Aircraft / Mode Type Select Effectivity App Cfg Torque Type Table E Fault Designation Engine 2 BUS Bus Type Basic Fault Designation Engine 1 BUS Bus Type BasicEngine Torque Data Selection Fault Designation Engine 2 BUS Bus Type RS-422 9600 baud Fault Designation Engine 1 BUS Bus Type RS-422 9600 baud Torque Data Select 11 Bell 212/412 Summary Data Torque Data Select 8 AS365 Dauphin N3Torque Data Select 9 Bell Torque Data Select 10 Bell Summary Data Connection Summary Data Fault Designation Engine 1 BUSTorque Data Select 14 Coast Guard HH-65 Summary Data Torque Data Select 16 Common DC Torque Table E Description Category 2, AIR Data Input SelectTable E 3.1.2 AIR Data Input Select for Egpws Mkxxii Fault Designation AIR Data BUS Bus Type Basic Configuration DataType Summary Data Table E 3.1.2-3 AIR Data Input Select #3 Summary Data Table E 3.1.2-5 AIR Data Input Select #5 Table E 3.1.2-4 AIR Data Input Select #4 Summary DataConnect to Channel Table E 3.1.2-10 AIR Data Input Select #10 Channel 429RX2Table E 3.1.2-6 AIR Data Input Select #6 Channel Connect to Table E 3.1.2-11 AIR Data Input Select #11 Summary Data Category 3, Position Input Select 3.3Position Input Type TableE Description UTC Fault Designation GPS BUS Bus Type Basic Internal Fault Designation Internal GPS Bus Type Basic Bus Type Basic Fault Designation GPS BUS App Cfg Category 4, Altitude CalloutsTable E 3.1.4 Altitude Callouts for Egpws Mkxxii Honeywell MK Xxii Egpws Installation Manual Table E 3.1.5-128 Audio Menu Type 128 Basic Helicopter Category 5, Audio Menu SelectEffectivity App Cfg 006 Table E 3.1.5 Audio Menu Type Defined By IDand TCF Disable Application NotesCategory 6, Terrain Display Select Section Overview Honeywell MK Xxii Egpws Installation Manual Table E KC Picture Bus Table Table E 3.1.6-2 TA&D / TCF Disabled Table Table E 3.1.6-1 No Display TAD and TCF EnabledChannel Integration note Fault Designation Display BUS Bus Type BasicDisplay Configuration Group 6 Collins PRO-LINE II Table Table E 3.1.6-3 Collins ProLine II Table Table E 3.1.6-4 Bendix PPI-4A/4B Display Configuration Group 1 Bendix RDR 4A/B PPI with MOD Table E Collins ProLine II Display Configuration Group 2 Collins Proline II Table E Collins ProLine II 5x4,5x5 Display Configuration Group 3 Collins Proline II, 5X4 Table E Non-Integrated Efis 40/50 Honeywell/Bendix Display Configuration Group 7 NON-INTEGRATED Efis 40/50 Display Configuration Group 8 Integrated Efis 40/50 Peaks Always EnabledTable E 3.1.6-10 Integrated Efis 40/50 Honeywell/Bendix Honeywell MK Xxii Egpws Installation Manual Table E 3.1.6-12 Collins WXI-701/711, without Auto Range Reference Name Integration note PinsTerrain Display BUS #1 453TX1 Terrain Display BUS #2 Terrain Display BUS #2 453TX2 Table E 3.1.6-14 Bendix PPI-4A/4B without Auto Range Reference Name PIN Function 6.2-3 Display Input Control Group6.3-0OUTPUT 429 BUS Group Traceability Reference section Table E 3.1.6-16 Bendix IN182A/IN812A Radar display RDR Output 429 Bus Group Pins Comments TA&D Alternate Pop Up False TA&D Alternate Pop Up True Table E Bendix IN842A/IN862A Radar display RDRFunction Value Category 7, Options Select Group #1 Display Input Control Group Display Input Control Group Honeywell Fault Designation IOC BUS Table E3.1.6-236 Display Configuration Collins ProLine IV Honeywell Channel 429RX8 Table E 3.1.6-246 Non-Integrated Efis 10 Bendix/Honeywell Channel 422RX2 Connect to DC811 #1 Display Input Control GroupConnect to DC811 #2 Honeywell MK Xxii Egpws Installation Manual SCI Bus RS-422 12K baud Altitude Reference6 Effectivity App Cfg Category 7, Options 1 SelectTable E 317 Options Select Group #1 True False WGS-84 Radio Altitude Type Table E Description Category 8, Radio Altitude Input SelectDescription Value PIN Type Channel Designation Reference PIN Function Connection Reference Summary Data Table E 3.1.8-5 Radio Altitude Input Select Type 5 ALT Connection PIN Type Category 9, Navigation Input SelectTable E 3.1.9 Navigation Input Select for Egpws Mkxxii Table E 3.1.9-0 Navigation Inputs Select Summary Data Fault Designation ILS BUS Fault Designation ILS BUS Bus T ype Basic Table E 3.1.10-0 Attitude Input Select Type Category 10, Attitude Input SelectAttitude Input Select Table E 3.1.10 Attitude Input Select for Egpws MK Table E 3.1.10-4 Attitude Input Select Type Fault Designation Ahrs BUSTable E 3.1.10-128 Attitude Input Select Type Connect to Table E 3.1.11 Heading Input Select for Egpws MK Fault Designation Ahrs BUS Bus Type BasicCategory 11, Heading Input Select Heading Input Select Table E Description Table E 3.1.12 Windshear Input Select Category 12, Windshear Input SelectNo Windshear Effectivity App Cfg 003 Input/Output Discrete Type Table E Category 13, Input / Output Discrete Type Select State Configuration Data Possible StatesTable E 3.1.13-128 INPUT/OUTPUT Discrete Type Table E 3.1.13-129 INPUT/OUTPUT Discrete Type Category 14, Audio Output Level Volume SelectTable E 3.1.14 Audio Output Level Autorotation Threshold Torque Category 15, Autorotation ThresholdTable E 3.1.15 Autorotation Threshold for Egpws MK SYN1X SYN1Z SYN2Z Connector Pin Refer to Category 13 where multiple uses are possible Honeywell MK Xxii Egpws Installation Manual Figure E 4.1, Connector Pin References J1, J2, J3 Definitions AcronymInterpretation Acronym Interpretation Pcmcia