Category 14, Audio Output Level, Volume Select | Honeywell MKXXII

Honeywell

MK XXII EGPWS Installation Manual

E 5.3.14 CATEGORY 14, AUDIO OUTPUT LEVEL

The following table provides identification of the Audio Output Level Select. Each entry in the ID column corresponds to a particular nominal alert output level selection (Max, -6 dB, -12 dB, -18dB and –24dB). The nominal output is 4 Wrms for the 8-ohm output and 100 mWrms for the 600-ohm output. The Audio Output Level can be additionally reduced by 6dB with the Mode 6 Low Volume discrete (see Category 13). The output power level will be the nominal maximum output (4W or 100mW) reduced by the volume selection from Table 5.3.14 and the Mode 6 Low Volume discrete.

ID

0

1

2

3

4

TABLE E 3.1.14: AUDIO OUTPUT LEVEL

Volume Select

Nominal

-6 dB

-12 dB

-18 dB

-24 dB

Effectivity

App		Cfg.
-001	-001
-001	-001
-001	-001
-001	-001
-001		-001

CAGE CODE: 97896 SCALE: NONE SIZE: A DWG NO: 060-4314-225

REV: C SHEET 245

Image 245

Honeywell MKXXII installation manual Category 14, Audio Output Level, Volume Select, Table E 3.1.14 Audio Output Level

Contents

Release Date 12/14/00 REV C Sheet ALL Revisions REV Description Honeywell MK Xxii Egpws Installation Manual Table of Contents Honeywell MK VI MK Viii Egpws Installation Design Guide Honeywell MK VI MK Viii Egpws Installation Design Guide 104 Section V Certification 149 143158 160 Aircraft Application Data Section General Information Honeywell MK Xxii Egpws Installation Manual Section I General Information License Requirements Applicability How To Use This Docu mentIntroduction Reference Documents Description of Equipm ent MK Xxii Egpws Conf iguration Module MK Xxii Egpws Comp uterGPS Antenna OAT Sensor Smart Cable Pcmcia Interface Technical Characteris tics MK Xxii Egpws Smart Cable MK Xxii Egpws Configuration ModuleUnits Supplied Honeywell MK Xxii Egpws Installation Manual New Egpws installation with Internal GPS Installation and Acces sories Kits2 RS-232 Cable Smart Cable Flight History Card Terrain Database Card s Annunciators & Switc h/Annunciators GPS Antenna & cableCircuit Breaker Cockpit Speaker Opti onal Contact Positioner P 1, P2, P3 Tools Required Crimping Tool P1, P 2, P3Insertion/Removal Too l P1, P2, P3 Spare Contacts P1, P 2, P3 Honeywell MK Xxii Egpws Installation Manual Section Installation Honeywell MK Xxii Egpws Installation Manual Section II Installation Unpacking and Inspec ting the Equipment Equipment Installation 2.3.1 General MK Xxii Computer Ins tallation MK Xxii Computer Loc ation Configuration Module Installation Configuration Module Location Required Configuration Module Assembly 1 MK Xxii Egpws Configuration Module Installation Assembly Sequence 2 MK Xxii Egpws Configuration Module 3 MK Xxii Egpws Configuration Module 4 MK Xxii Egpws Configuration Module 5 MK Xxii Egpws Configuration Module 6 MK Xxii Egpws Configuration Module 7 MK Xxii Egpws Configuration Module OAT Sensor Installatio n GPS Antenna Installat ionCockpit Annunciators / Switches GPS Antenna location Egpws cautionGPWS G/S Cancld Description Gpws warning red & Gpws alert amber Location 8 MK Xxii Egpws Annunciators/Switches Location Low Altitude Mode Inhibit Switch Functio ns and SelectionTerrain Inhibit Audio Inhibit Timed MK Xxii Egpws Outline Honeywell P/N 405-0383-001 MK Xxii Egpws Mounting Tray Honeywell MK Xxii Egpws Installation Manual Section System Planning Honeywell MK Xxii Egpws Installation Manual Section III System Planning Category 8 Radio Altitude Input Select Category 14 Audio Output Level Chassis Ground System Wiring/ Electr ical InterfacesPrimary Power Input Serial Outputs Analog and Digital Inp utsDiscrete Inputs Discrete Outputs Audio Output Category 1 Aircraft / Mode Type Select Configurable Interface sAircraft / Mode Type Instructions Category 2 Air Data Input Select Egpws MK Examples Analog altitude and 500 ohm OAT Digital Arinc 429 Cat ID 5, 1 Arinc Digital -ARINC 575 Cat ID Shadin 2000 Cat ID Digital Arinc 429 Dual IOC Buses Cat . ID Arinc 743 Format Category 3 Position Input Select 3.2 RS-232 Transmit-Receive, 9600 baud Cat ID Examples Arinc 429 BUS Cat ID 0,1,4,5 Dual Arinc 429 BUS Cat ID Category 4 Altitude Callouts Category 5 Audio Menu Select TAD Selection Category 6 Terrain Display Select Type of sweep used for terrain data fan, standard, etc Terrain Display Configuration Group 6-1 Single Tube Wx/Terrain Display Example Display Input Control GroupOutput 429 Bus Group TRA-45A Egpws J101 Egpws Avidyne FSD Honeywell WRX R/T Honeywell Radar Indicator Arinc 429 Range #1 Arinc 429 Range #2 Kcpb Video #1 Out Avtech DSU 7.3 TA&D Alternate Pop-up Category 7 Options Select Group #1Steep Approach Not Available in the Mk Bank Angle Callout Enabling Peaks ModeObstacle Awareness GPS Altitude Reference WOW Reversal Example Digital Radio Altitude Interface Category 8 Radio Altitude Input Select Analog Radio Altitude Interface DH Discrete Gnd Valid Radio Altimeter Indicator Category 9 Navigation Inputs Select RNA-34A Example Analog Glideslope Interface cat ID 0,1,5 Dual Glideslope Receiver Digital Glideslope/Localizer Interface Category 10 Attitude Input Select Attitude Signals Vertical Gyro Example Analog Roll Angle Synchro Ahrs Digital Arinc 429 High Speed Magnetic Heading Category 11 Heading Input Select Directional Gyro Example Analog Heading Synchro CAT ID Heading High Speed Instruction Category 12 Windshear Input Select Input/Output Discretes Category 13 Input / Output Discrete Type Select Landing Gear Discrete Weight on Wheels WOW DiscreteAudio Inhibit Discrete Autopilot Engaged Discrete Glideslope Cancel DiscreteMode 6 Low Volume Discrete Glideslope Inhibit Discrete Terrain Awareness InhibitSelf Test Discrete Timed Audio Inhibit Discrete Low Altitude Mode Select DiscreteOutput Discretes Lamp Format TAD Inop Discrete Gpws Inop DiscreteGpws Warning Discrete Gpws Alert Discrete Terrain Display Select #1 & #2 Discrete Low Altitude Mode Discrete REV C Sheet Ohm Category 14 Audio Output Level Category 15, Autorotation Threshold Autorotation Threshold 107 108 Unit Installation Harness Checkout and Power CheckEgpwc Initialization a nd Configuration 1 RS-232 Communicatio n with the MK Xxii Egpws WinVIEWS Egpwc Front Panel T est Connector WinVIEWS Operation Configuration Module Programming 112 CFG CUW 0/15 128 3 2 134 128 3 29 1 0 2 0 0 129 0 CUW and CMR Comm ands CATspacecategory #spaceID#spaceT or FEnter Configuration Module Reprogramming Approval Regional Terrain Data base Loading 4.6.1 Effectivity Material Cost and Av ailability Accomplishment Instr uctions Verification of the Ter rain Database Version END of Test 120 Section Certification Honeywell MK Xxii Egpws Installation Manual Section V Certification Equipment Location Certification Procedur e Equipment Compatibi lityFAA Requirements Ground Test Flight Test Failure Modes, Effects , and Safety AnalysisPilots Guide Existing STC’s Honeywell MK Xxii Egpws Installation Manual Appendix a Customer Worksheet Honeywell MK Xxii Egpws Installation Manual Cockpit Displays MK Xxii Egpws GPS Parameter Discrete Inputs Generic Model Information System REV C Sheet REV C Sheet REV C Sheet REV C Sheet REV C Sheet Appendix B Sample Wiring Diagrams DWG no 060-4314-225 Revc Sheet Honeywell MK Xxii Egpws Installation Manual Honeywell MK Xxii Egpws Installation Manual Appendix C Honeywell MK Xxii Egpws Installation Manual Baud, No Parity, 8 bits, and 1 stop bit RS-232 Communication with the Egpws REV C Sheet REV C Sheet Honeywell MK Xxii Installation Manual Appendix D Vendor Drawings Honeywell MK Xxii Egpws Installation Manual AMP Vendor Contact Information For orders and AOG requirements, contact D1-1 Edmo D1-2 Emteq GPS RF Cable Sets Inches Bend Radius Minimum Per 100 ft 1 Connectors for Tflx cable series GPS 1 Connectors for Pflx cable series GPS Tool Frame and Die Part Numbers Installation Considerations D1-3 Aerospace Optics Aerospace Optics Inc Mail switches@vivisun.com StacoSwitch Appendix E Interface Description Document Honeywell MK Xxii Egpws Installation Manual Honeywell MK Xxii Egpws Installation Manual Connector Interface System Overview Introduction Part NumberPurpose Primary Power Input Signal InterfacesElectrical Interface Introduction Chassis Ground Radio Altitude DC Analog InputsLOW Level Glideslope Localizer Deviation or LOW Level Glideslope Validity Configuration Defined DC Inputs Outside AIR Temperature2.4 Barometric Altitude 2.7.1 AC Analog InputsSynchro Roll Attitude 2.7.2 Signal Timing Reference Inputs Configuration Defined Synchro Inputs Arinc 429/575 Digital Serial BUS Inputs 2.9 GPS RS-422 Digital Serial BUS Serial Port 2.9.1 RS-232 / RS-422 Digital Serial BUS InputsGPS RS-232 Digital Serial BUS Serial Port AIR Data RS-232 Digital Serial BUS Serial Port +28 VDC Discrete CharacteristicsAIR Data RS-422 Digital Serial BUS Serial Port SCI Range RS-422 Digital Serial BUS Serial Port GPS Antenna Input Configuration Module InterfaceGround Discrete Characteristics Discrete Output Characteristics Monitor Output CharacteristicsOAT Voltage Reference Output Lamp Driver Outputs LOW Level Interphone Audio Output High Level Speaker Audio OutputArinc Digital Serial Output Busses Arinc 429 Output BUS Front Panel Test Interface 2.18.1 RS-232 Maintenance Port Serial PortArinc 453 Output BUS GSE Present Discrete Input Front Panel Status IndicatorsPcmcia / Smartcable Port Aircraft Application Data Configuration TypesConfiguration Selection Instruction Signal SelectionTable E 3 Category ID Selection Procedure Configuration Selection Tables Category 1, Aircraft / Mode Type Select Effectivity App Cfg Torque Type Table E Engine Torque Data Selection Fault Designation Engine 1 BUS Bus Type BasicFault Designation Engine 2 BUS Bus Type Basic Fault Designation Engine 2 BUS Bus Type RS-422 9600 baud Fault Designation Engine 1 BUS Bus Type RS-422 9600 baud Torque Data Select 9 Bell Torque Data Select 8 AS365 Dauphin N3Torque Data Select 10 Bell Summary Data Torque Data Select 11 Bell 212/412 Summary Data Torque Data Select 14 Coast Guard HH-65 Summary Data Fault Designation Engine 1 BUSTorque Data Select 16 Common DC Torque Connection Summary Data Table E 3.1.2 AIR Data Input Select for Egpws Mkxxii Category 2, AIR Data Input SelectTable E Description Type Summary Data Configuration DataFault Designation AIR Data BUS Bus Type Basic Table E 3.1.2-3 AIR Data Input Select #3 Summary Data Connect to Channel Table E 3.1.2-4 AIR Data Input Select #4 Summary DataTable E 3.1.2-5 AIR Data Input Select #5 Table E 3.1.2-6 AIR Data Input Select #6 Channel 429RX2Channel Connect to Table E 3.1.2-10 AIR Data Input Select #10 Table E 3.1.2-11 AIR Data Input Select #11 Summary Data Position Input Type TableE Description 3.3Category 3, Position Input Select UTC Fault Designation GPS BUS Bus Type Basic Internal Fault Designation Internal GPS Bus Type Basic Bus Type Basic Fault Designation GPS BUS Table E 3.1.4 Altitude Callouts for Egpws Mkxxii Category 4, Altitude CalloutsApp Cfg Honeywell MK Xxii Egpws Installation Manual Effectivity App Cfg 006 Category 5, Audio Menu SelectTable E 3.1.5 Audio Menu Type Table E 3.1.5-128 Audio Menu Type 128 Basic Helicopter Category 6, Terrain Display Select IDand TCF Disable Application NotesSection Overview Defined By Honeywell MK Xxii Egpws Installation Manual Table E KC Picture Bus Channel Table Table E 3.1.6-1 No Display TAD and TCF EnabledTable Table E 3.1.6-2 TA&D / TCF Disabled Display Configuration Group 6 Collins PRO-LINE II Fault Designation Display BUS Bus Type BasicTable Table E 3.1.6-3 Collins ProLine II Integration note Table Table E 3.1.6-4 Bendix PPI-4A/4B Display Configuration Group 1 Bendix RDR 4A/B PPI with MOD Table E Collins ProLine II Display Configuration Group 2 Collins Proline II Table E Collins ProLine II 5x4,5x5 Display Configuration Group 3 Collins Proline II, 5X4 Table E Non-Integrated Efis 40/50 Honeywell/Bendix Display Configuration Group 7 NON-INTEGRATED Efis 40/50 Table E 3.1.6-10 Integrated Efis 40/50 Honeywell/Bendix Peaks Always EnabledDisplay Configuration Group 8 Integrated Efis 40/50 Honeywell MK Xxii Egpws Installation Manual Table E 3.1.6-12 Collins WXI-701/711, without Auto Range Terrain Display BUS #1 453TX1 Integration note PinsTerrain Display BUS #2 Reference Name Terrain Display BUS #2 453TX2 Table E 3.1.6-14 Bendix PPI-4A/4B without Auto Range 6.3-0OUTPUT 429 BUS Group Traceability 6.2-3 Display Input Control GroupReference Name PIN Function Reference section Table E 3.1.6-16 Bendix IN182A/IN812A Radar display RDR Output 429 Bus Group Pins Comments Function Value Table E Bendix IN842A/IN862A Radar display RDRCategory 7, Options Select Group #1 TA&D Alternate Pop Up False TA&D Alternate Pop Up True Display Input Control Group Display Input Control Group Honeywell Fault Designation IOC BUS Table E3.1.6-236 Display Configuration Collins ProLine IV Honeywell Channel 429RX8 Table E 3.1.6-246 Non-Integrated Efis 10 Bendix/Honeywell Connect to DC811 #2 Connect to DC811 #1 Display Input Control GroupChannel 422RX2 Honeywell MK Xxii Egpws Installation Manual SCI Bus RS-422 12K baud Table E 317 Options Select Group #1 Category 7, Options 1 SelectAltitude Reference6 Effectivity App Cfg True False WGS-84 Description Value Category 8, Radio Altitude Input SelectRadio Altitude Type Table E Description PIN Type Channel Designation Reference PIN Function Connection Reference Summary Data Table E 3.1.8-5 Radio Altitude Input Select Type 5 ALT Table E 3.1.9 Navigation Input Select for Egpws Mkxxii Category 9, Navigation Input SelectTable E 3.1.9-0 Navigation Inputs Select Summary Data Connection PIN Type Fault Designation ILS BUS Fault Designation ILS BUS Bus T ype Basic Attitude Input Select Category 10, Attitude Input SelectTable E 3.1.10 Attitude Input Select for Egpws MK Table E 3.1.10-0 Attitude Input Select Type Table E 3.1.10-128 Attitude Input Select Type Connect to Fault Designation Ahrs BUSTable E 3.1.10-4 Attitude Input Select Type Category 11, Heading Input Select Fault Designation Ahrs BUS Bus Type BasicHeading Input Select Table E Description Table E 3.1.11 Heading Input Select for Egpws MK No Windshear Category 12, Windshear Input SelectEffectivity App Cfg 003 Table E 3.1.12 Windshear Input Select Input/Output Discrete Type Table E Category 13, Input / Output Discrete Type Select Table E 3.1.13-128 INPUT/OUTPUT Discrete Type Configuration Data Possible StatesState Table E 3.1.13-129 INPUT/OUTPUT Discrete Type Table E 3.1.14 Audio Output Level Volume SelectCategory 14, Audio Output Level Table E 3.1.15 Autorotation Threshold for Egpws MK Category 15, Autorotation ThresholdAutorotation Threshold Torque SYN1X SYN1Z SYN2Z Connector Pin Refer to Category 13 where multiple uses are possible Honeywell MK Xxii Egpws Installation Manual Figure E 4.1, Connector Pin References J1, J2, J3 Definitions AcronymInterpretation Acronym Interpretation Pcmcia