Garland XG24-JIB, XG36-JIB service manual Yes, Noyes

Page 45

TECHNICAL TROUBLESHOOTING continued

Controller Displays “IGNITION FAILURE” - Module is sparking, flame comes on and goes out

Dig Gas Valve Open?

Check for 120 VAC across gas NO Valve, terminal 3&4

YES

Check for 3.5”W.C. (NAT

GAS), 10”W.C. (LP) NO burner pressure.

YES

Check gas view port

YES

to ensure ￿ame is lighting.

 

Is Burner lighting at all?

 

NO

 

Check for any obstructions

 

in gas piping and repair

 

as needed

 

Check for 120VAC output from

Check wiring connections

ignition module, terminal

YES

between Ignition Module,

VALVE & VALVE.

 

and Gas Valve.

 

 

NO

 

YES

Adjust gas

Replace Ignition

Replace gas

pressure

Module

valve

Check micrpamp reading between

Ignition Module and Ignitor. UA

Reading should be between .8 and 1.6

Ideal microamps is between 1.0 and 1.2

NOYES

Adjust UA reading until

recommended UA areReplace Ignitor obtained.

Part # JIBSM08 Rev.6 (08/04/09)

Page 45

Page 44 Page 46
Image 45
Page 44 Page 46
Contents Jack in the BOX GAS Xpress GRILLS, Models XG24-JIB, XG36-JIB Table of Contents Table of Contents Dimensions and SPECIFICATIONS, XG24-JIB Model Dimensions and SPECIFICATIONS, XG36-JIB Model Plug Configuration SpecificationsWarranty SafetyShipping Damage Claim Procedure IntroductionSafety Rating Plate Location Unit InstallationGeneral Information National Codes RequirementsAccessory Kit Main Gas Inlet Unit InstallationAppliances Equipped with Casters Electrical ConnectionsAccessory Kit Electrical Supply Lines Grease Bucket Electrical Connection Terminal Block ConnectionVentilation and Clearance Changing to a different type of gasBurner Air Adjustment Igniter AdjustmentIgniter Inspection Grill Controls Grill Controls Platen Zeroing Programming Mode System SetupLower Front Left Raise Back Right Platen ZeroingOptional Accessories Release material sheet must be replaced when Release Material InstallationNormal Operation Normal Operation Cleaning and Maintenance Cleaning During OperationDaily Cleaning Cleaning and Maintenance Programming Modes/Menu Sequence ProgrammingProgramming To Change Grill Set Temperature To Change Upper Platen Set TemperatureTo Change Product Gap Setting To Change the Cook Time of a ProductTo View Recovery Time Grill To View Recovery Time Upper PlatenTo Change Product Button,KeyAssignment To Change a Product NameTo Change Gap Setting Display Units To Change temperature Units, F or CTo View the Flash Number To View the Software NumberTo Change the Key Chirp To Change the Alarm VolumeTo Change Probe Calibration Upper To Change Probe Calibration GrillTo Change Instant-On Time To Change Platen SetTo Change Control Type To Turn Extended Time On/OffTo Change the Alarm Mode To Change the Start DelayTo Turn Clean Mode On/Off To Change the Grill FunctionTo Perform Limit Switch Test To Modify a Product Name in LibraryTo Change SCK Address Calibration Bi-Weekly CalibrationTo Calibrate Probe Locations CalibrationError Messages TroubleshootingLow Internal Product Temperatures Technical TroubleshootingTechnical Troubleshooting Controller Displays Too HotYES YES Controller displays Probe Error Upper platen is not zeroed properly Inconsistent Or Erratic Internal Product TemperatureProbable diagnosis YES Check voltage of upper limit Does Upper Limit YES Controller Displays Ignition Failure No flame at allNoyes Linear Actuator Replacement Linear Actuator Replacement JIBSM08 Rev 7 08/04/09 Contents Parts ListModel XG24-JIB Description Quantity Gas Xpress Grill Complete Exploded View Model XG24-JIBXpress Grill Actuator Gas Xpress Grill Actuator Assembly View Model XG24-JIB Xpress Grill Platen 4517022 Platen Conduit Gas Xpress Grill Platen Assembly View Model XG24-JIBXpress Grill Burner Gas Xpress Grill Burner Assembly View Model XG24-JIB Assembly View Model XG24-JIB Component Bracket Contactor BracketIgnition Module Xpress Grill Heat Sink Assembly View Model XG24-JIB Gas Xpress Grill Heat Sink Assembly View Model XG24-JIB REV. # Revision HistoryItem # Part List Book ReleasedRight Zone Parts ListGrill Complete Assembly Description Quantity Critical Gas Xpress Grill Complete Exploded View Model XG36-JIB4520578 Grill Plate Thermocouple JIBSM08 Rev.6 08/04/09 Actuator Assembly GAS Xpress Grill Actuator Assembly View Model XG36-JIB Platen Assembly Gas Xpress Grill Platen Assembly View Model XG36-JIB Assembly View Model XG35-JIB Gas Xpress Grill Burner Assembly View Model XG36-JIB Xpress Grill Bracket Component Mounting Bracket Xpress Grill Heat Sink Assembly View Model XG36-JIB Gas Xpress Grill Heat Sink Assembly View Model XG36-JIB Description & Location Quantity Critical Gas Xpress Grill Accessories And Tools Model XG36-JIB Center Zone Right Zone Left Zone Gas Xpress Grill Gas Tubing Model XG36-JIBItem # Date Revision HistoryDiagram WiringWiring Diagram Controller Menu Items Jack in the Box Menu ItemsTime Temperature Conversion F / C Page JIBSM08 Rev.6 08/04/09
Top Page Image Contents