Weber E/S-320 manual 18MAINTENANCE, Replacing Main Burners, Main Burner Flame Pattern

Page 18

18MAINTENANCE

AnNNUAL MAINTENANCE

Inspection and cleaning of the Spider/Insect screens

To inspect the Spider/Insect screens, remove the control panel. If there is dust or dirt on the screens, remove the burners for cleaning the screens. Brush the Spider/Insect screens lightly with a soft bristle brush (i.e. an old toothbrush).

CAUTION: Do not clean the Spider/Insect screens with hard or sharp tools. Do not dislodge the Spider/Insect screens or enlarge the screen openings.

Lightly tap the burner to get debris and dirt out of the burner tube. Once the Spider/Insect screens and burners are clean replace the burners.

If the Spider/Insect screen becomes damaged or cannot be cleaned, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®.

MAIN BURNER FLAME PATTERN

The Weber® gas barbecue burners have been factory set for the correct air and gas mixture. The correct ﬂ ame pattern is shown.

1)Burner tube

2)Tips occasionally ﬂ icker yellow

3)Light blue

4)Dark blue

If the ﬂ ames do not appear to be uniform throughout the burner tube, follow the burner cleaning procedures.

MAIN BURNER CLEANING PROCEDURE

Turn off the gas supply.

Remove the manifold (See “Replace Main Burners”). Look inside each burner with a ﬂ ashlight.

Clean the inside of the burners with a wire (a straightened-out coat hanger will work). Check and clean the air shutter opening at the ends of the burners. Check and clean the valve oriﬁ ces at the base of the valves. Use a Steel bristle brush to clean outside of burners. This is to make sure all the burner ports are fully open.

CAUTION: Do not enlarge the burner ports when cleaning.

1

2

3

4

REPLACING MAIN BURNERS

1)Your Weber® gas barbecue must be OFF and cool.

2)Turn gas OFF at source.

3)To remove control panel:

(a)Take off the burner control knobs.

(b)Remove screw and washer from back of control panel with a Phillips screwdriver.

(c)Tilt the back edge of the control panel up. Push in on the front edge to release locking tabs.

(d)Disconnect the igniter wires from the ignition module.

(e)Carefully pull control panel away from frame.

a

b

e

c

d

WWW.WEBER.COM®

Image 18

Contents GAS Grill 2WARNINGS For replacement parts call WARRANTY, GARANTÍA, GarantieCustomer Service Center Roselle Road, Suite Schaumburg, IL Para partes de repuesto llame aExploded View E/S/EP Lista DEL Diagrama DE DESPIECE, Liste DE LA Vision Éclatée Exploded View List E/S/EP$ $ Side Burner Table General Instructions For Installation in CanadaCleaning Operating Storage AND/OR NonuseImportant LP Cylinder Information Connecting the Liquid Propane CylinderGAS Instructions Leak Check Preparation Check That ALL Burner Valves are OFFTo Connect the hose to the cylinder Turn on the cylinder valveGAS Instructions Refilling the Liquid Propane Cylinder Checking the Fuel Level in Your TankSafe Handling Tips for Liquid Propane GAS Cylinders Operating InstructionsLighting Liquid Propane LP CylindersMain Burner Lighting Main Burner LightingMain Burner Manual Lighting To ExtinguishTo Extinguish Lighting the Side BurnerTroubleshooting Problem Check CureManually Lighting the Side Burner Maintenance Side Burner TroubleshootingSide Burner Maintenance Side Burner MaintenanceReplacing Main Burners 18MAINTENANCEMain Burner Cleaning Procedure Main Burner Flame PatternReplace Battery if Necessary Crossover Ignition System OperationsBarbacoa DE GAS ADVERTENCIAS21 Instrucciones Generales Preparativos Para LA Búsqueda DE Fugas Instrucciones Sobre EL GASInformación Importante Sobre EL Cilindro DE Propano Licuado Cómo Conectar EL Cilindro DE Propano LicuadoPara conectar la manguera al cilindro Compruebe QUE no Haya Fugas DE GAS Usted necesitará un destornillador PhillipsCómo Recargar EL Cilindro DE Propano Licuado Cómo Verificar EL Nivel DE Combustible EN SU TanqueInstrucciones DE Operación EncendidoCilindros de propano licuado Encendido DEL Quemador Principal Encendido DEL Quemador PrincipalEncendido Manual DEL Quemador Principal Para ApagarPara Apagar Cómo Encender EL Quemador LateralResolución DE Problemas Problema Revisar RemedioEncendido Manual DEL Quemador Lateral Mantenimiento Resolución DE Problemas DEL Quemador LateralMantenimiento DEL Quemador Lateral Mantenimiento DEL Quemador LateralPatrón DE LA Llama DEL Quemador Principal 32MANTENIMIENTOMantenimiento Anual Procedimiento Para LA Limpieza DEL Quemador PrincipalOperación DEL Sistema DE Encendido Crossover Reemplace LA Batería SI Fuese NecesarioGrill a GAZ Mises EN Garde Mises EN Garde36GENERALITES Informations IMP0ORTANTES Relatives a LA Bouteille DE PL GENERALITES37Instructions Relatives AU GAZ Preparation DE LA Detection DES FuitesPour connecter le tuyau à la bouteille de gaz Detection DES Fuites DE GAZ Il vous faudra un tournevis cruciformeRechargement DE LA Bouteille DE Propane Liquide Verification DU Niveau DE Combustible Dans Votre BouteilleInstructions Relatives a L’UTILISATION AllumageBouteilles de gaz propane liquide PL Allumage Manuel DU Bruleur Principal Allumage DU Bruleur PrincipalPour Eteindre Pour Eteindre Allumage DU Bruleur LateralProbleme Verification Solution DepannageAllumage Manuel DU Bruleur Lateral Maintenance DU Bruleur Lateral Maintenance DU Bruleur LateralProbleme Verification Depannage DU Bruleur LateralProcedure DE Nettoyage DU Bruleur Principal 46MAINTENANCEMaintenance Annuelle Remplacement DES Bruleurs PrincipauxOperations DU Systeme D’ALLUMAGE Crossover Remplacez LA Pile SI NecessairePage Page Page Page Page Page WEBER-STEPHEN Products CO Month / MES / Mois DAY / DÍA / Jour For purchases made in the U.S