Burnham IN10 manual Burner Tray 1 Inch Main Burners

Page 73

	Key	Description	Part No.					Quantity
	No.	Description	Part No.	IN3	IN4	IN5	IN6	IN7	IN8	IN9	IN10	IN11	IN12
	No.			IN3	IN4	IN5	IN6	IN7	IN8	IN9	IN10	IN11	IN12

	3. Base Assembly (Continued)

			72060035	1	---	---	---	---	---	---	---	---	---

			72060045	---	1	---	---	---	---	---	---	---	---

			72060055	---	---	1	---	---	---	---	---	---	---

			72060065	---	---	---	1	---	---	---	---	---	---

	3B2	Base Rear Insulation	72060075	---	---	---	---	1	---	---	---	---	---

			72060085	---	---	---	---	---	1	---	---	---	---
			72060085	---	---	---	---	---	1	---	---	---	---
			72060095	---	---	---	---	---	---	1	---	---	---
			72060105	---	---	---	---	---	---	---	1	---	---
			72060115	---	---	---	---	---	---	---	---	1	---

			72060126	---	---	---	---	---	---	---	---	---	1

			618600341	1	---	---	---	---	---	---	---	---	---

			618600441	---	1	---	---	---	---	---	---	---	---

			618600541	---	---	1	---	---	---	---	---	---	---

			618600641	---	---	---	1	---	---	---	---	---	---

	3C	Base Front Panel Assembly	618600741	---	---	---	---	1	---	---	---	---	---
	3C	Base Front Panel Assembly	618600841	---	---	---	---	---	1	---	---	---	---
			618600841	---	---	---	---	---	1	---	---	---	---
			618600941	---	---	---	---	---	---	1	---	---	---

			618601041	---	---	---	---	---	---	---	1	---	---

			618601141	---	---	---	---	---	---	---	---	1	---

			618601241	---	---	---	---	---	---	---	---	---	1

			718600305	1	---	---	---	---	---	---	---	---	---

			718600405	---	1	---	---	---	---	---	---	---	---

			718600505	---	---	1	---	---	---	---	---	---	---
			718600605	---	---	---	1	---	---	---	---	---	---
		Burner Tray (1 Inch Main Burners)	718600705	---	---	---	---	1	---	---	---	---	---
		Burner Tray (1 Inch Main Burners)	718600805	---	---	---	---	---	1	---	---	---	---
			718600805	---	---	---	---	---	1	---	---	---	---

			718600905	---	---	---	---	---	---	1	---	---	---

			718601005	---	---	---	---	---	---	---	1	---	---

	3D		718601105	---	---	---	---	---	---	---	---	1	---

			718601205	---	---	---	---	---	---	---	---	---	1

			71806037	1	---	---	---	---	---	---	---	---	---
			71806047	---	1	---	---	---	---	---	---	---	---
			71806057	---	---	1	---	---	---	---	---	---	---
		Burner Tray (40mm Main Burners)	71806067	---	---	---	1	---	---	---	---	---	---

			71806077	---	---	---	---	1	---	---	---	---	---

			718600806	---	---	---	---	---	1	---	---	---	---

			718600906	---	---	---	---	---	---	1	---	---	---

	3E	Base Leg Assembly	6186001	4	4	4	4	4	4	4	4	6	6

	3E1	Base Leg [Included in Key No. 3E]	71860021	4	4	4	4	4	4	4	4	6	6

	3E2	Nylon Glide [Included in Key No. 3E]	8186006	4	4	4	4	4	4	4	4	6	6

73

Image 73

Contents 8141049R26-10/08 Price $5.00 IndependencePage Page Dimensional Drawing Table of Contents Probe L.W.C.O Float L.W.C.O Tankless Heater Pre-Installation Clearance to Combustible Materials Install Base-Burner-Manifold Assembly II. Knocked-Down Boiler AssemblyInstall assembled cast iron sections on base assembly Canopy Gasket Installation Install CanopyCombustion Chamber Intermittent Ignition EI Install Ignition Module Install Blocked Vent Switch with sheet metal screwsInstall Trim and Controls III. Semi-Pak Boiler AssemblyRemove Crate Steam Boiler with Probe Low Water CutoffWater Boiler Junction Box and Mounting Bracket AssemblyInstall Jacket Front Panel IV. Packaged Boiler AssemblyRemove Jacket Front Panel. See Figure Piping and Trim Page Recommended Water Piping for Circulator Zoned Heating System Recommended Water Piping for Zone Valve Zoned Heating System Recommended Piping for Indirect Water Heater Page Rated Input VI. Gas PipingConnect boiler gas valve to gas supply system Specific Gravity Correction Factors for Natural Gas Fitting Equivalent LengthsBoiler Equipped With Vent Damper VII. VentingIf an Existing Boiler is Removed Typical Vent InstallationVIII. Electrical Wire Vent Damper if usedAlliance Indirect Water Heater if used Thermostat Heat Anticipator SettingsVent Damper Harness to Limit This page Left Intentionally Blank Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Fill boiler with water IX. System Start-upPrepare to check operation Follow Lighting or Operating InstructionsPage Page Page Page Ignition Module Terminal Cross-Reference Ignition Module Wiring Ladder Diagram Terminal DesignationOFF Green LED Status CodesPilot Burner Flame, Honeywell Q350 Check low water cutoff steam only Adjust gas input rate to boiler. Natural GasDo not drain below gauge glass Check LimitInput Rate Adjust gas input rate to boiler. LP/PropanePage Page Maintenance of Low Water Cutoff Service InstructionsClean Boiler Flueways Boiler Flueway CleaningTankless Heater Pilot Burner LocationModel No Gallons Per Month Year Excessive Make-Up WaterHoneywell Electronic Ignition Trouble Shooting Guide Honeywell Hot Surface to Pilot Trouble Shooting Guide Avoid Breathing Fiber Particulates and Dust Service Record XI. Repair PartsSection Assembly Canopy and Draft Hood Canopy/Draft Hood Parts Base Tray Base AssemblyBurner Tray 1 Inch Main Burners Manifold and 1 Main Burners Manifold and Main Burners 1 Inch Main Burners Only Manifold and Main Burners 40MM Main Burners only Manifold and 40mm Main BurnersIntermittent Ignition Only Volt Continuous Ignition Standing Pilot Natural GasNatural Gas, High Altitude 5000-9000 Ft. USA Only LP Gas, High Altitude 2000-5000 Ft. USA OnlyLP Gas, High Altitude 5000-9000 Ft. USA Only Natural Gas, High Altitude 2000-4500 Ft. Canada OnlyPilot Burner, Honeywell Q350A1321 Pilot Burner, Honeywell Q348A1002 Page Jacket Assembly Front Top Panel Jacket Assembly Refer to Figure onSteam Trim Page Water Trim Quantity This page Left Blank Intentionally Page Blocked Vent Switch Flame Rollout SwitchTransformer Steam and Gravity Water Only Ignition Module Intermittent Ignition OnlyXII. Low Water Cut Off Lwco Wiring of Typical LwcoLwco Location Limited Warranty Limited Warranty