Burnham IN10 manual Jacket Assembly Refer to Figure on, Front Top Panel

Page 82

	Key	Description	Part No.					Quantity
	No.	Description	Part No.	IN3	IN4	IN5	IN6	IN7	IN8	IN9	IN10	IN11	IN12
	No.			IN3	IN4	IN5	IN6	IN7	IN8	IN9	IN10	IN11	IN12

	Jacket Assembly (Continued) - Refer to Figure on Page 80

	5A	Upper Left Rear Panel (not shown)	604101051	---	---	---	---	---	---	---	1	1	1

	5B	Upper Right Rear Panel (not shown)	604101052	---	---	---	---	---	---	---	1	1	1

			60410036	1	---	---	---	---	---	---	---	---	---

			60410046	---	1	---	---	---	---	---	---	---	---

			60410056	---	---	1	---	---	---	---	---	---	---

			60410066	---	---	---	1	---	---	---	---	---	---
	6A	Front Top Panel	60410076	---	---	---	---	1	---	---	---	---	---
	6A	Front Top Panel	60410086	---	---	---	---	---	1	---	---	---	---
			60410086	---	---	---	---	---	1	---	---	---	---
			60410096	---	---	---	---	---	---	1	---	---	---

			60410106	---	---	---	---	---	---	---	1	---	---

			60410116	---	---	---	---	---	---	---	---	1	---

			60410126	---	---	---	---	---	---	---	---	---	1

			604100361	1	---	---	---	---	---	---	---	---	---

			604100461	---	1	---	---	---	---	---	---	---	---

			604100561	---	---	1	---	---	---	---	---	---	---
			604100661	---	---	---	1	---	---	---	---	---	---
	6B	Rear Top Panel	604100761	---	---	---	---	1	---	---	---	---	---

			604100861	---	---	---	---	---	1	---	---	---	---
			604100861	---	---	---	---	---	1	---	---	---	---

			604100961	---	---	---	---	---	---	1	---	---	---

			604101061	---	---	---	---	---	---	---	1	---	---

			604101161	---	---	---	---	---	---	---	---	1	---

			604101261	---	---	---	---	---	---	---	---	---	1

			70410034	1	---	---	---	---	---	---	---	---	---
			70410044	---	1	---	---	---	---	---	---	---	---
			70410054	---	---	1	---	---	---	---	---	---	---
			70410064	---	---	---	1	---	---	---	---	---	---

	7	Lower Front Tie Bar	70410074	---	---	---	---	1	---	---	---	---	---

			70410084	---	---	---	---	---	1	---	---	---	---
			70410084	---	---	---	---	---	1	---	---	---	---

			70410094	---	---	---	---	---	---	1	---	---	---

			70410104	---	---	---	---	---	---	---	1	---	---

			70410114	---	---	---	---	---	---	---	---	1	---
			70410124	---	---	---	---	---	---	---	---	---	1

82

Image 82

Contents Independence 8141049R26-10/08 Price $5.00Page Page Dimensional Drawing Table of Contents Probe L.W.C.O Float L.W.C.O Tankless Heater Pre-Installation Clearance to Combustible Materials Install Base-Burner-Manifold Assembly II. Knocked-Down Boiler AssemblyInstall assembled cast iron sections on base assembly Install Canopy Canopy Gasket InstallationCombustion Chamber Install Blocked Vent Switch with sheet metal screws Intermittent Ignition EI Install Ignition ModuleRemove Crate III. Semi-Pak Boiler AssemblyInstall Trim and Controls Steam Boiler with Probe Low Water CutoffJunction Box and Mounting Bracket Assembly Water BoilerInstall Jacket Front Panel IV. Packaged Boiler AssemblyRemove Jacket Front Panel. See Figure Piping and Trim Page Recommended Water Piping for Circulator Zoned Heating System Recommended Water Piping for Zone Valve Zoned Heating System Recommended Piping for Indirect Water Heater Page Rated Input VI. Gas PipingConnect boiler gas valve to gas supply system Fitting Equivalent Lengths Specific Gravity Correction Factors for Natural GasVII. Venting Boiler Equipped With Vent DamperTypical Vent Installation If an Existing Boiler is RemovedWire Vent Damper if used VIII. ElectricalThermostat Heat Anticipator Settings Alliance Indirect Water Heater if usedVent Damper Harness to Limit This page Left Intentionally Blank Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Prepare to check operation IX. System Start-upFill boiler with water Follow Lighting or Operating InstructionsPage Page Page Page Ignition Module Wiring Ladder Diagram Terminal Designation Ignition Module Terminal Cross-ReferenceGreen LED Status Codes OFFPilot Burner Flame, Honeywell Q350 Do not drain below gauge glass Adjust gas input rate to boiler. Natural GasCheck low water cutoff steam only Check LimitAdjust gas input rate to boiler. LP/Propane Input RatePage Page Service Instructions Maintenance of Low Water CutoffBoiler Flueway Cleaning Clean Boiler FluewaysPilot Burner Location Tankless HeaterExcessive Make-Up Water Model No Gallons Per Month YearHoneywell Electronic Ignition Trouble Shooting Guide Honeywell Hot Surface to Pilot Trouble Shooting Guide Avoid Breathing Fiber Particulates and Dust XI. Repair Parts Service RecordSection Assembly Canopy and Draft Hood Canopy/Draft Hood Parts Base Assembly Base TrayBurner Tray 1 Inch Main Burners Manifold and 1 Main Burners Manifold and Main Burners 1 Inch Main Burners Only Intermittent Ignition Only Manifold and 40mm Main BurnersManifold and Main Burners 40MM Main Burners only Volt Continuous Ignition Standing Pilot Natural GasLP Gas, High Altitude 5000-9000 Ft. USA Only LP Gas, High Altitude 2000-5000 Ft. USA OnlyNatural Gas, High Altitude 5000-9000 Ft. USA Only Natural Gas, High Altitude 2000-4500 Ft. Canada OnlyPilot Burner, Honeywell Q350A1321 Pilot Burner, Honeywell Q348A1002 Page Jacket Assembly Jacket Assembly Refer to Figure on Front Top PanelSteam Trim Page Water Trim Quantity This page Left Blank Intentionally Page Transformer Steam and Gravity Water Only Flame Rollout SwitchBlocked Vent Switch Ignition Module Intermittent Ignition OnlyXII. Low Water Cut Off Lwco Wiring of Typical LwcoLwco Location Limited Warranty Limited Warranty