Manuals / LG Electronics / Household Appliance / Air Conditioner

LG Electronics AS-W126URH1/UBH1/UWH1/UMH1 For left piping. Follow the instruction below Good case

Models: AS-W096URH1/UBH1/UWH1/UMH1 AS-W126URH1/UBH1/UWH1/UMH1 AS-W096URH0/UBH0/UWH0/UMH0 AS-W126URH0/UBH0/UWH0/UMH0/UCH0

1 84

Download 84 pages 60.42 Kb

Page 20

Installation

CAUTION: Installation Information

For left piping. Follow the instruction below.

Good case

• Press on the upper side of clamp and unfold the tubing to downward slowly.

Bad case

• Following bending type from right to left may cause damage to the tubing.

20Room Air Conditioner

Image 20

LG Electronics AS-W126URH1/UBH1/UWH1/UMH1 service manual For left piping. Follow the instruction below Good case, Bad case

Contents

LG Room Air Conditioner Table of Contents Code Type Code of Model Meaning LG Model Name2002 2003~2005 Meaning Safety Precautions Installation There is risk of fire, electric shock, explosion, or injury Operation Thinner Keep level even when installing the product Be cautious that water could not enter the product Operation Dimensions Symbols Used in this ManualIndoor Unit 9k, 12k Btu Series Outdoor Unit Product Specifications AS-W096U0 AS-W126U0 AS-W096U1 AS-W126U1 Installation Select the best LocationIndoor unit Outdoor unit Piping Length and Elevation Fixing Installation PlateOil trap should be installed every 5~7 meters Drill a Hole in the Wall Flaring Work Connecting the Piping CheckIndoor Foamed polyethylene or equivalent is recom- mended Wrap the insulation material around the connecting portion For left rear piping Indoor unit installation For left piping. Follow the instruction below Good case Bad case Outdoor Outdoor unit Connecting the Cables Circuit Grade Breaker Drain piping Checking the DrainageTo check the drainage Forming the Piping Air purging with vacuum pump Air PurgingAir purging Finishing the job Soap water methodEvacuation Prepare remote controller Test RunningSettlement of outdoor unit Evaluation of the performance Pump Down Procedure Pump Down Functions Power relay control Active power filter controlPSCOverheatng. ProtectionPower module Stand by control at low temp Cancel Sleep Mode, Timer on or Timer OFF 3, 4, 5, 6 Off TimerHigh39C Low11C Cooling Down to 18C Heating Down to 16C Up to 30C LG Brand/OEM Brand OperationLED display of indoor unit Protection of the evaporator pipe from frosting Control method Cooling mode operation Model Comp. Operating frequency Healthy Dehumidification mode operation Intake air Temp Setting Temp Temp. differences Comp. Operating frequency Heating mode operationOperating freq. step of comp Fuzzy mode operationOptionals Intake air temp Setting temp Fan speedFuzzy operation for cooling At beginning Fuzzy operation for Heating Fuzzy operation for dehumidification Jet cool mode operation Jet heat mode operationSwing mode Chaos swing mode Sleep timer operation for heating cycle Sleep timer operationSleep timer operation for cooling cycle Indoor temp Operating Mode Setting temp Auto restarting operationForced operation Trial Operation Protection from total current control Protection from DC Peak Current Portection from overheating of power module Portection from overheating of compressor AS-W096/126U1 Series Defrosting controlAS-W096/126U0 Series Low Ambient Auto CleaningAuto ChangeoverOptional Disassembly To remove the Grille from the Chassis To remove the Evaporator To remove the Control BoxTo remove the Discharge Grille To remove the Motor Cover To remove the Cross-Flow Fan IndoorAS-W096U 0, AS-W126U 0 Series Schematic DiagramElectric Control Device OutdoorAS-W096Series, AS-W126Series Wiring Diagram Indoor Unit AS-W096/126U0,1 Series Outdoor Unit AS-W096U0 Series AS-W126U0 Series Indoor Main P.W.B Assembly DC Part Components Location Display ASSEMBLYAS-W096/126U0,1 Series Outdoor Main P.W.B Assembly AS-W096/126U0 Series Troubleshooting Guide Refrigeration Cycle DiagramModel Capillary Tube Model Adopted Electrion Expansion Valve Outdoor unit Indoor unit Oil trap should be installed per 5~7 metersPipe Length and the Elevation Way, 3-way Valve Way Valve Liquid Side Procedure Air purgingCheck for gas leakage Purge the air from the system Set the 2-way valve to the closed position Pumping DownAir purging of the charge hose Re-installation Mount the valve stem nuts and the service port nutRe-air Purging Air purging Balance Refrigerant of the 3-way Valve Gas leakage Evacuation All amount of refrigerant leaked Gas Charging After EvacuationConnect the charge hose to the charging cylinder Purge the air from the charge hose Cycle Parts Trouble analysis Self-diagnosis function Precaution in Service or Check Diagnosis Procedure Procedure Specification Remedy Electronic Parts Product doesnt operate with the remote controller Compressor/Outdoor Fan are unable to drive Check Point Comp. on Comp. OFF When indoor Fan does not operate Trouble 5 When the horizontal louver does not operate Heater does not operate at all Outdoor Unit does not operate at all Indoor Outdoor Trouble 8-1When compressor does not operate normally DC Peak ErrorError Code ➅ Trouble 8-2When compressor does not oprate normally Communication error between Indoor and Outdoor Error Code ➄ Trouble 8-3When compressor does not oprate normally CT Error Error Code ➆ Problem of missing the connector Indoor Main PCB Assy Problem of missing the connector Outdoor Main PCB AssyConnectors Condition Problem error mode CN-T/Block Exploded View Indoor Unit Outdoor Unit Replacement Parts List Description Panel ASSY, Front SUB No A20061Z October