2000W Generator
TROUBLESHOOTING
Problem | Cause | Correction | |||
| 1. | One of the circuit breakers is open. | 1. | Reset circuit breaker. | |
| 2. | Fault in generator. | 2. | Contact Briggs and Stratton Power | |
Engine is running, but no |
|
|
| Products service facility. | |
AC output is available. | 3. | Poor connection or defective cord set. | 3. | Check and repair. | |
| 4. | Connected device is bad. | 4. | Connect another device that is in | |
|
|
|
| good condition. | |
|
|
|
|
| |
| 1. | Short circuit in a connected load. | 1. | Disconnect shorted electrical load. | |
Engine runs good at no- | 2. | Engine speed is too slow. | 2. | Contact Briggs and Stratton Power | |
|
|
| Products service facility. | ||
load but "bogs down" when |
|
|
| ||
3. | Generator is overloaded. | 3. | See "Don't Overload Generator". | ||
loads are connected. | |||||
|
|
|
| ||
| 4. | Shorted generator circuit. | 4. | Contact Briggs and Stratton Power | |
|
|
|
| Products service facility. | |
|
|
|
|
| |
| 1. | Engine switch set to "Off". | 1. | Set switch to "On". | |
| 2. | Fuel Valve is in "Off" position. | 2. | Turn fuel valve to "Open" position. | |
| 3. | Dirty air cleaner. | 3. | Clean or replace air cleaner. | |
| 4. | Out of gasoline. | 4. | Fill fuel tank. | |
| 5. | Stale gasoline. | 5. | Drain gas tank and carburetor; fill | |
|
|
|
| with fresh fuel. | |
| 6. | Spark plug wire not connected to spark | 6. | Connect wire to spark plug. | |
|
| plug. |
|
| |
Engine will not start; or | 7. | Bad spark plug. | 7. | Replace spark plug. | |
starts and runs rough. | 8. | Water in gasoline. | 8. | Drain gas tank and carburetor; fill | |
| |||||
|
|
|
| with fresh fuel. | |
| 9. | Flooded. | 9. | Wait 5 minutes and | |
| 10. | Excessively rich fuel mixture. | 10. | Contact Briggs and Stratton Power | |
|
|
|
| Products service facility. | |
| 11. | Intake valve stuck open or closed. | 11. | Contact Briggs and Stratton Power | |
|
|
|
| Products service facility. | |
| 12. | Engine has lost compression. | 12. | Contact Briggs and Stratton Power | |
|
|
|
| Products service facility. | |
|
|
|
|
| |
Engine shuts down when | 1. | Out of gasoline. | 1. | Fill fuel tank. | |
2. | Low oil level. | 2. | Fill crankcase to proper level or place | ||
running. | |||||
|
|
| generator on level surface. | ||
|
|
|
| ||
|
|
|
|
| |
Engine lacks power. | 1. | Load is too high. | 1. | See "Don't Overload Generator". | |
2. | Dirty air filter. | 2. | Replace air filter. | ||
| |||||
|
|
| |||
Engine "hunts" or falters. | Carburetor is running too rich or too lean. | Contact Briggs and Stratton Power | |||
|
| Products service facility. | |||
|
|
| |||
|
|
|
|
| |
|
| 19 |
|
| |