Briggs & Stratton 30239 Engine Technical Information, Product Specifications, Power Ratings

Page 14

2000W Generator

ENGINE TECHNICAL INFORMATION

This is a single cylinder, overhead valve(OHV), air cooled engine. It is a low emissions engine.

In the State of California, this type of engine is certified by the California Air Resources Board to meet emissions standards for 125 hours. Such certification does not grant the purchaser, owner or operator of this engine any additional warranties with respect to the performance or operational life of this engine. The engine is warranted solely according to the product and emissions warranties stated elsewhere in this manual.

Power Ratings

The power ratings for an individual engine model are initially developed by starting with SAE (Society of Automotive Engineers) code J1940 (Small Engine Power & Torque Rating Procedure) (Revision 2002-05). Given both the wide array of products on which our engines are placed, and the variety of environmental issues applicable to operating the equipment, it may be that the engine you have purchased will not develop the rated horsepower when used in a piece of power equipment (actual “on-site” power). This difference is due to a variety of factors including, but not limited to, the following: differences in altitude, temperature, barometric pressure, humidity, fuel, engine lubrication, maximum governed engine speed, individual engine to engine variability, design of the particular piece of power equipment, the manner in which the engine is operated, engine run-in to reduce friction and clean out of combustion chambers, adjustments to the valves and carburetor, and other factors. The power ratings may also be adjusted based on comparisons to other similar engines utilized in similar applications, and will therefore not necessarily match the values derived using the foregoing codes.

PRODUCT SPECIFICATIONS

Generator Specifications

Starting Wattage

. 3,000 Watts

Wattage

. 2,000 Watts

Load Current

 

At 120 Volts AC

.16.6 Amps

At 12 Volts DC

.8.3 Amps

Phase

.Single Phase

Frequency

.60 Hertz

Fuel Capacity

.1.32 U.S. gallons (5.0 l)

Packaged Weight

.87 lbs. (39.5 kg.)

Engine Specifications

Model . . . . . . . . . . . . . . . . . . . . . . . . Mitsubishi GM132 Rated Horsepower . . . . . . . . . . . . . . 3.25 at 3600 rpm Displacement . . . . . . . . . . . . . . . . . . . 126cc

Spark Plug Type: . . . . . . . . . . . . . . . . . NGK BPR6HS or equivalent

Set Gap To: . . . . . . . . . . . . . . . . . . . . . 0.030inch (0.76mm)

NOTE: Should you have questions about replacing components on your Briggs & Stratton Power Products generator, please call 1-800-743-4115for assistance.

14

Image 14
Contents 030239 2000W Equipment Description Table of ContentsSafety Rules When Operating Equipment When Adding or Draining FuelWhen Starting Equipment When Transporting or Repairing EquipmentWhen Adjusting or Making Repairs to Your Generator When Testing for Engine SparkKnow Your Generator Engine ON/OFF Switch Used to stop a running engineEngine ON/OFF Switch Assembly Before Starting EngineTo Add Engine Oil When Adding FuelAdd Fuel System Ground Using the GeneratorConnecting to a Building’s Electrical System Generator LocationStarting the Engine OperatingGenerator Stopping the Engine Charging a BatteryConnecting Electrical Loads Oil Alert SystemCold Weather Operation Volt DC Accessory JackReceptacles Volt AC, 15 Amp ReceptacleRemove shelter when temperatures are above 40F 4C Permanent Cold Weather ShelterCapacity Power ManagementDont Overload Generator ExampleGenerator Specifications Product SpecificationsPower Ratings Engine SpecificationsEmission Control Generalgenerator Recommendations MaintenanceGenerator Cleaning Clean area around oil drain plug Figure Engine MaintenanceClean/Replace Spark Plug Checking Oil LevelTo clean or replace air cleaner Service Air CleanerClean Spark Arrester Screen Air Cooling SystemGenerator Storage InstructionsLong Term Storage Instructions Other Storage TipsTroubleshooting 2000W Generator 2000W Generator Emission Control System Warranty Consumer Use Years Years or YearDescription DE L Équipement Symboles de danger et moyensTable DES Matières Règles DE SécuritéLorsque Léquipement Fonctionne Lors DE Lajout OU DE LA Vidange DU CarburantLors DU Démarrage DE Léquipement Lorsque Vous Transportez OU Réparez LéquipementLorsque Vous Réglez OU Réparez Votre Générateur Lors DE Tests Dallumage DU MoteurConnaissez Votre Générateur Lanceur Dispositif utilisé pour le démarrage du moteurMoteur AssemblageAvant LE Démarrage DU Lors DE Lajout DU Carburant Ajoutez de lessencePour ajouter de lhuile Mise à la terre du système Emplacement de la génératriceUtilisation DE LA Génératrice Branchement au système électrique dun édificeUtilisation DU Générateur Démarrage du moteurArrêt du moteur Recharge dune batterieBranchement des charges électriques Système dalerte de niveau dhuileFonctionnement PAR Temps Froid Fiches DE ConnexionRallonges Prise de 120 volts CA, 15 ampèresAbri Permanent Pour Temps Froids Gestion de la consommation NE Surchargez PAS Votre GénérateurCapacité ExemplePuissance nominale Renseignements Techniques SUR LE MoteurCaractéristiques Caractéristiques de la génératriceEntretien DU Générateur Recommandations Générales DentretienDispositif Antipollution Pour nettoyer le générateurVérification du niveau dhuile Nettoyage/Remplacement de la bougie dallumageEntretien DU Moteur Avertissement Vidange de lhuile moteurSystème de refroidissement à air Entretien du filtre à airNettoyage de lécran pare-étincelles Pour nettoyer ou remplacer le filtre à airGénératrice Directives DentreposageDirectives dentreposage à long terme Autres conseils dentreposageDépannage Garantie DU Dispositif Antipollution Garantie Limitée Reglas DE Seguridad Tabla DE ContenidosDescripción DEL Equipo AdvertenciaCuando Ponga EN Funcionamiento EL Equipo PeligroCuando Añada Combustible O Vacíe EL Depósito Cuando Opere EL EquipoCuando Pruebe LA Bujía DEL Motor PrecauciónCuando Ajuste O Haga Reparaciones a SU Generador Etiqueta de Datos Conozca SU GeneradorBujía Conexión de TierraMontaje Antes DE Darle Arranque AL GeneradorPara Añadir Aceite al Motor Añadir GasolinaSeleccione una viscosidad de acuerdo a la tabla siguiente Cuando Añada CombustibleConexión al Sistema Eléctrico de un Edificio USO DEL GeneradorTierra del Sistema Ubicación del GeneradorOperando EL Generador Precaución Encienda el MotorDetener el Motor Procedimiento de Carga de la BateriaConexion De Cargas Electricas Aceite Sistema AlertaOperación Durante UN Clima Frío Enchufes DE Conexión PrecauciónCables DE Extensión Receptáculo de 120 Voltios ACFigura 45 Refugio Frío Permanente del Tiempo Control de la Energía No Sobrecargue EL GeneradorCapacidad EjemploPotencia Nominal Información Técnica Sobre EL MotorEspecificaciones DEL Producto Especificaciones del GeneradorControl DE Emisiones Recomendaciones GeneralesMantenimiento DEL Generador Limpieza del GeneradorCambiar el Aceite del Motor Mantenimiento DEL Motor AdvertenciaVerfique el Nivel de Aceite Limpie/Reemplace la BujíaSistema de Refrigeración de Aire Mantenimiento del Filtro de AireLimpieza del Filtro del Amortiguador de Chispas Para limpiar o sustituir el filtro de aireGenerador Instrucciones DEL AlmacenamientoInstrucciones de Almacenamiento a Largo Plazo Otros Consejos de AlmacenamientoNotas Problema Causa Solución Diagnóstico Y Reparación DE AveríasGarantia DEL Sistema DE Control DE Emisiones Garantía Limitada