Middleby Marshall PS360-L, PS360WB-U Conveyor Installation, Removing the Conveyor Drive Sprocket

Page 9

V. CONVEYOR INSTALLATION

NOTE

Split belt conveyors can only be installed from the end of the oven with the drive motor.

Single-belt conveyor assemblies may be inserted into either end of the oven. If it is to be installed from the end of the oven without the drive motor, the drive sprocket assembly must be removed.

To remove the drive sprocket (if necessary), loosen the set screw on the conveyor collar as shown in Figure 2-7. Then, pull the sprocket assembly straight out.

1.Lift the conveyor and position it in the oven as shown in Figure 2-8.

SECTION 2 - INSTALLATION

Figure 2-7 - Removing the Conveyor Drive Sprocket

ENGLISH

Loosen conveyor collar set screw, then pull shaft straight out

Figure 2-8 - Inserting the Conveyor

2.Continue moving the conveyor into the oven until the frame protrudes equally from each end of the oven (about 457mm).

3.Check that the retainers located on the underside of the conveyor frame rest firmly against the lower end plug, as shown in Figure 2-9.

NOTE:

Each oven has retainer clips on the bottom of the conveyor frame, as shown in Figure 2-9. The clips are only located on the left (drive) side of the frame.

4.When the conveyor is positioned properly, check for free- dom of movement of the conveyor belt by pulling it for about 60 to 90 cm with your fingers. The conveyor must move freely.

5.If the drive sprocket was removed when installing the conveyor, replace it at this time.

6.Install the drive chain between the conveyor drive sprocket and the motor sprocket. To install the chain, it will be necessary to lift the drive end of the conveyor slightly. The drive motor and sprocket are shown in Figure 2-7.

7.Install the conveyor drive motor cover and tighten its hanger screw (on the rear wall of the oven).

8.Check the tension of the conveyor belt as shown in Figure 2-10. The belt should lift between 75-100mm. DO NOT OVERTIGHTEN THE CONVEYOR BELT.

NOTE:

If necessary, the belt tension can be adjusted by turning the conveyor adjustment screws, located at the idler (right) end of the conveyor. See Figure 2-10.

Figure 2-9 - Conveyor retainers

Retainer clip

Figure 2-10 - Checking the conveyor tension

75-100mm

vertical

deflection

Conveyor

tension

adjustment

screws (idler

end only)

9

Image 9
Contents PS360WB PS360English For Your SafetyTable of Contents Description English III. Oven SpecificationsOven Uses II. Oven Components see FigureInstallation Electrical specifications per oven cavityGas orifice and pressure specifications per oven cavity Installation kit components one kit required per cavity Installation KITAdditional installation kit components for gas ovens 710Requirements II. Ventilation SystemRecommendations Other ventilation concernsIV. Thermocouple Installation III. AssemblyRemoving the Conveyor Drive Sprocket Conveyor Installation11 Conveyor and Master Link Orientation VI. Final AssemblyDURINGPRESSURETESTINGNOTEONEOFTHEFOLLOW- ING VII. Electrical SupplyVIII. GAS Supply Gas Utility Rough-In Recommendations Gas MeterGas Line Replacing the Gas Orifices if so required Preparation for Use with Various GasesVolumetric Method Adjusting the Orifice Manifold Pressure and Heat InputChecking the Gas Supply Inlet Pressure Orifice Manifold Pressure MethodReset Switch Gas ovens only. Illuminates Conveyor Switch Turns the conveyor drive motor on and offOperation Location and Description of ControlsDailystartupprocedure DailyshutdownprocedureII. Normal Operation STEP-BY-STEP III. Quick Reference Digital Temperature Controller Symptom IV. Quick Reference TroubleshootingMaintenance Daily MaintenanceRemoving the Conveyor II. Maintenance MonthlySplit Belt Disassembly and Cleaning III. Maintenance Every 3 MonthsIV. Maintenance Every 6 Months KEY Spare Parts KIT Available sepa- rately. See FigureDescription 400V, 50 Hz, 1 Ph DiagramsImportant also located inside An electrical wiring diagram for the oven isCompartment Gas OvenReguleret opvarmningszone Regulerede opvarmningszoner PS300 serien gas- og elektriske ovneMeddelelse DanskIndholdsfortegnelse AFSNIT5-LEDNINGSDIAGRAMMERAfsnit 3 Betjening AFSNIT4-VEDLIGEHOLDELSEOvnens Anvendelsesmuligheder Afsnit 1 Beskrivelse DanskII. Ovnkomponenter se Figur III. OvnspecifikationerAfsnit 2 Installation Tabel 1-3 Generelle specifikationer pr. ovnhulrumTabel 1-4 Specifikationer for gasåbning pr. ovnhulrum Yderligere komponenter til installationssæt til gasovne InstallationssætEnhed Beskrivelse Delnummer ØversteovnKrav II. VentilationssystemAnbefalinger Andre ventilationsanliggenderIII. Montering IV. Installation AF TermoelementInstallation AF Transportbånd DanskBemærk 11 Transportbånds- og samleledsretning VI. Endelig MonteringVII. Strømforsyning VIII. Gasforsyning ForsigtigUnder Trykprøvning Skal ET AF Følgende Bemærkes Gasudsivningstest, før ovnen betjenes Udførelse af disse procedurer, skal Der UdføresUdskiftning af gasåbninger hvis det kræves Forberedelse til brug med forskellige gastyperKontrol af gasforsyningstrykket indgang Volumetrisk metodeJusteringen af åbningens tryk manifold og varmetilførsel Åbningstrykmetoden manifoldAfsnit 3 Betjening Placering OG Beskrivelse AF BetjeningsknapperHeat varme kontakt Tillader at brænder Dagligopstartprocedure DaglignedlukningsprocedureII. Normal Betjening Trin for Trin III. Hurtig Reference Digital Temperaturregulator IV. Hurtig Reference Fejlfinding Bemærk Afsnit 4 VedligeholdelseVedligeholdelse Dagligt ForsigtigEksempler på markeringer II. Vedligeholdelse MånedligAfmontering og rengøring af dobbeltbånd III. Vedligeholdelse Hver 3. MånedIV. Vedligeholdelse Hver 6. Måned Nøgle Reservedelssæt fås separat. Se figurEnhed Del nr Beskrivelse Afbrydere 380-400V, 50 Hz, 1 faseMaskinkassen Der findes også et ledningsdiagramPS360-U/-L eller Gasovn, 220-230V, 50Hz