Turbo Chef Technologies i5 service manual 32.0 813 mm

Page 16

5

Partition

24.3” (618 mm) Above Counter Top

TurboChef

Grill

i5 Oven

6”				12”
(152 mm)				(305 mm)
(152 mm)				(305 mm)
Minimum				Minimum

Figure 4: Installation Near Open Heat Source

Counter Top / Table

Partition

24.3” (618 mm) Above Counter Top

Deep Fryer

32.0” (813 mm)

27.8” (706 mm)					26.625” (676 mm)
27.8” (706 mm)					26.625” (676 mm)

Figure 5: Oven Cart Dimensions

SPECIFICATIONS AND INSTALLATION

Image 16

Contents Accelerating the World of Cooking TM Page For further information, call 800.90TURBO Page Table of Contents Edit Mode Oven SystemsRTD Troubleshooting Oven Schematic Appendix Replacing Oven ComponentsGeneral Safety Information Reducing Fire RiskGrounding Instructions Power Cord ReplacementRF Interference Considerations Specifications and Installation Dimensions Theory of OperationCertifications Oven Construction Single Phase Electrical Specifications Multi Phase Unpacking Instructions Lifting and Placing the OvenOptional Installation Items Installation Near Open Heat SourceVoltage Selection 32.0 813 mm This page intentionally Left blank Daily Maintenance Remove and Clean the Wire Rack Remove and Clean the Lower JetplateRemove and Clean the Lower Air Diverter Clean the Oven InteriorClean and Dry the Oven Door Reinstall ComponentsClean the Drain Pan Clean the Oven ExteriorOven Controls and Cooking Oven Controls Mode 1 Oven Off CookingMode 2 Temperature Select Mode 3 Warming UpMode 4 Soak Mode 5 Ready to Cook or IdleMode 9 Cook More Mode 7 CookingMode 8 Remove Food from Oven Mode 10 Cooling DownOverview of the Info Mode Viewing the Fault LogViewing the Service Numbers Viewing Cook Counter/Time LogsInfo Mode Resetting the Oven Setting the LanguageSetting the Date/Time Turning Oven Options On/OffTest Mode Testing Oven Parts Test Mode Status IndicatorsTest Mode Fault Log Test Mode Turning On/Off Diagnostic ModeTest Mode Self Test Test Mode Manufacturing ModeMicrowave Power Test Microwave Leakage TestChanging Temperature Measurement Setting Erase/Default Oven SettingsLoading a Menu Serial Number EditUpdating the Software Inserting Smart Card/USB DeviceEdit Mode Overview of the Edit Mode Single vs. Multiple Temperature ModeChanging Set Temperatures Changing Food Group/Recipe NameChanging Recipe Settings This page intentionally Left blank Oven Systems Convection System Troubleshooting Convection System Removing/Reinstalling the Oven DoorAdjusting the Oven Door Oven DoorOven Systems Adjusting the Door Switches Interlock SwitchesHinges and Counter-Balance Assembly Measuring RF Leakage for Microwave Safety = Loosen = Tighten = Loosen Slightly StepTroubleshooting Survey Meter PlacementTesting a Capacitor Wiring the Filament TransformersMicrowave System CapacitorsWiring the High-Voltage Transformers Testing a Filament or HV TransformerHigh-Voltage Transformers High-Voltage DiodesTesting a High-Voltage Diode Magnetrons Testing a Magnetron for an Open/Shorted FilamentWave Guides Control System Power Supply High Limit ThermostatMagnetron Thermostats Relay K1 FilamentWire Harness Relay K7 Magnetron Cooling FanRelay K8 Stirrer Motor Smart Card ReaderFiltering System Catalytic ConverterDrain Pan Air FilterTroubleshooting Overview of Troubleshooting Fault Code DescriptionsF7 RTD Open Fault Code Troubleshooting BelowNo YES Is the K6 mechanical Replace the F3 or F4 Are both cooling fans rotating? Yesno Non-Fault Code Troubleshooting Does the keypad beep when YES YES no Did you use a smart card or USB Smart Card Verify the USB device is Is the connection from Troubleshooting Oven Schematic Delta WYE This page intentionally Left blank Appendix Replacing Oven Components Comprehensive Table of Oven Components To Replace This First Remove This2APPENDIX Replacing Oven Components Replacing Items No Cover Removal Required Figures A-1, A-2 16 17 Figure A-1 No Cover Removal RequiredReplacing Items Opening Top Cover Required Figure A-3 4 5 11 12 13 15 16Cover, Top I5-9243 13 14 15 Figure A-4 Removing Top Cover RequiredFigure A-6 Top Cover Detail Qty Figure A-7 Removing Left Side Cover Required Replacing Oven Components I5-9316 Screw, 10-32 x 3/8 lg, PFLH, 100 Deg, SS 101401 qty Oven Components For service or information

Related manuals

Manual 34 pages 18.03 Kb