Manuals / Henny Penny / Kitchen Appliance / Fryer

Henny Penny OEA/OGA-342, OFE/OFG-342 Drain switch wired N/C, Model OFE/OFG/OEA/OGA-341,342, 2-36

Models: OEA/OGA-341 OEA/OGA-342 OFE/OFG-341 OFE/OFG-342

1 82

Download 82 pages 31.46 Kb

Page 46

Image 46

Model OFE/OFG/OEA/OGA-341, 342

Drain switch wired N/C

2-36

106

Page 46

Image 46

Henny Penny OEA/OGA-342, OFE/OFG-342, OFE/OFG-341 Drain switch wired N/C, Model OFE/OFG/OEA/OGA-341,342, 2-36

Contents

Model OFE/OFG-341 Model OFE/OFG-342 Henny Penny High Volume Open FryerTECHNICAL MANUAL Model OEA/OGA-341 Model OEA/OGA-342Model OFE/OFG/OEA/OGA-341,342 FM06-030 Revised Section TABLE OF CONTENTSPage 1-1.INTRODUCTION SECTION 1. TROUBLESHOOTING1-2.SAFETY injuryinjuries and/or property damage could result 1-3.TROUBLESHOOTINGPROBLEM CAUSEthoroughly 1-3.TROUBLESHOOTINGContinuedcleaning the fryer PROBLEMPROBLEM 1-2.TROUBLESHOOTINGContinued CAUSEPANEL BOARD CORRECTION 1-4.ERROR CODESDISPLAY CAUSEDISPLAY 1-4.ERROR CODESContinued CAUSEHIGH TEMPERATURE SECTION 2. MAINTENANCEMAINTENANCE HINTS INTRODUCTIONFigure Gas Units Continuedand remove the high limit from bracket Figurepower switch to OFF and disconnect main circuit 2-3.HIGH TEMPERATUREReplacement power terminals2-4.COMPLETE CONTROL PANEL REPLACEMENT2-5.POWER SWITCH power switch to OFF and disconnect main circuitFigure 2-5.POWER SWITCH ContinuedFigure FigureFigure 1.Remove electrical power supplied to the fryerContinued Figure2-8.FLAME SENSOR/ PILOT / IGNITOR ASSEMBLY GAS Figure FigureFigure FigureFigure power switch to OFF and disconnect main circuitbreaker, or unplug cord at wall receptacle Figure2-10.TRANSFORMER REPLACEMENT1. Remove electrical power supplied to the unit those components with low voltagebreaker, or unplug cord at wall receptacle power switch to OFF and disconnect main circuitFigure Figure1. Remove electrical power supplied to the unit 2-14.FILTER SWITCHREPLACEMENT FigureTO AVOID PERSONAL INJURY OR PROPERTY PROCEDURE, MOVE THE MAIN POWER SWITCHBOX OR UNPLUG SERVICE CORD FROM WALL DAMAGE, BEFORE STARTING THISFigure 2-15.GAS CONTROL VALVE REPLACEMENT ContinuedFigure FigureFigure 2-15.GAS CONTROL VALVE REPLACEMENT Continuedpower switch to OFF and disconnect main circuit FigureFigure 2-16.BLOWER MOTOR REPLACEMENT ContinuedFigure FigureBLOWER MOTOR units will have power2-16 2-17Wattage Wire NosVoltage Ohms cold2-18.HEATING Checkout Power RemovedHeat Contactorunits will have power. Mercury CONTACTORSReplacement 2-18.HEATING CONTACTORS ELECTRIC ContinuedHeat Contactor FigureFigure Figure Replacement Primary Contactor2-18.HEATING CONTACTORS ELECTRIC Continued FigureFigure 2-19.SPEAKER ASSEMBLYpower switch to OFF and disconnect main circuit breaker, or unplug cord at wall receptacleCheckout power switch to OFF and disconnect main circuitFigure breaker, or unplug cord at wall receptacleLIMIT CONTROL ELECTRIC Continued 2-20.HIGH TEMPERATUREconnect the two electrical wires 1. Drain the shortening from the frypotLIMIT CONTROL ELECTRIC Continued terminals2-20.HIGH TEMPERATURE FigureFigure MOTOR REMOVALFigure FigureTRANSFORMER 2-21.FILTER PUMP AND MOTOR REMOVAL Continued2-22.AUTOLIFT if applicableREPLACEMENT 2-24.AUTOLIFTACTUATOR MOTOR power switch to OFF and disconnect main circuitFigure 2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENTif applicable Figureif applicable 10. Install new actuator in reverse order2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENT FigureModel OFE/OFG/OEA/OGA-341,342 Drain switch wired N/C2-31 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/C2-32 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/C2-33 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/C2-34 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/C2-35 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/C2-36 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/C2-37 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/C2-38 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/O2-39 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/O2-40 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/O2-41 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/O2-42 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/O2-43 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/O2-44 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/O2-45 Model OFE/OFG/OEA/OGA-341,342 Drain switch wired N/O2-46 SECTION 3. PARTS INFORMATION 3-3.WHEN ORDERING3.6 WARRANTY 3-1.INTRODUCTIONDescription Item NoPart No Qty. per WellPart No Gas ComponentsItem No DescriptionPart No Gas Burner AssemblyItem No DescriptionPart No Electric ComponentsItem No DescriptionDescription Item NoPart No Qty. per WellModel OFE/OFG/OEA/OGA-341,342 Part No Qty. per UnitItem No DescriptionDescription Item NoPart No Qty. per UnitDescription Item NoPart No Qty. per UnitDescription Item NoPart No Qty. per WellQty. per Unit Item NoDescription 33501Description Item NoPart No Qty. per WellDescription Item NoPart No Qty. per WellDescription Item NoPart No Qty. per WellPart No Electric ComponentsItem No DescriptionItem No OFG/OGA-341OFG/OGA-342 DescriptionDescription Item NoPart No Qty. per WellPART NUMBER OFG/OFE ELECTRO MECHANICAL PARTS LISTDESCRIPTION Item No DescriptionDescription Item No71899 Part No 341 DIRECT-CONNECTPARTS LIST Before March 1,342 DIRECT-CONNECTPARTS LIST Before March 1, DescriptionPart No Item NoDescription Part No Part NoDescription DescriptionDescription Model OFE/OFG/OEA/OGA-341,342 Part NoDescription 3-26