Manuals / Henny Penny / Kitchen Appliance / Fryer

Henny Penny OFE/OFG-342 Electric Components, Item No, Part No, Description, Qty. per Well

Models: OEA/OGA-341 OEA/OGA-342 OFE/OFG-341 OFE/OFG-342

1 82

Download 82 pages 31.46 Kb

Page 72

Image 72

Model OFE/OFG/OEA/OGA-341, 342

Electric Components

	1	2	3	4
Item No.		Part No.	Description		Qty. per Well
	1	60241	High Limit - 425º F		1
	2	23823	Assy-Heater Terminal Block		1
	3	14973	Temperature Probe Assembly		1
	4	18227	Microswitch		1
	5*	32497	EMC Filter Board - CE		1
	6*	32498	Assy – 4 Inch Terminal Block		1

recommended parts/*not shown

3-16

607

Page 72

Image 72

Henny Penny OFE/OFG-342, OFE/OFG-341, OEA/OGA-342 Electric Components, Item No, Part No, Description, Qty. per Well

Contents

Henny Penny High Volume Open Fryer TECHNICAL MANUALModel OFE/OFG-341 Model OFE/OFG-342 Model OEA/OGA-341 Model OEA/OGA-342Model OFE/OFG/OEA/OGA-341,342 FM06-030 Revised TABLE OF CONTENTS SectionPage SECTION 1. TROUBLESHOOTING 1-2.SAFETY1-1.INTRODUCTION injury1-3.TROUBLESHOOTING PROBLEMinjuries and/or property damage could result CAUSE1-3.TROUBLESHOOTINGContinued cleaning the fryerthoroughly PROBLEM1-2.TROUBLESHOOTING ContinuedPROBLEM CAUSE1-4.ERROR CODES DISPLAYPANEL BOARD CORRECTION CAUSE1-4.ERROR CODES ContinuedDISPLAY CAUSESECTION 2. MAINTENANCE MAINTENANCE HINTSINTRODUCTION HIGH TEMPERATUREGas Units Continued and remove the high limit from bracketFigure FigureReplacement power switch to OFF and disconnect main circuitpower terminals 2-3.HIGH TEMPERATUREPANEL REPLACEMENT 2-5.POWER SWITCH2-4.COMPLETE CONTROL power switch to OFF and disconnect main circuit2-5.POWER SWITCH Continued FigureFigure Figure1.Remove electrical power supplied to the fryer ContinuedFigure Figure2-8.FLAME SENSOR/ PILOT / IGNITOR ASSEMBLY GAS Figure FigureFigure Model OFE/OFG/OEA/OGA-341,342power switch to OFF and disconnect main circuit breaker, or unplug cord at wall receptacleFigure FigureREPLACEMENT 1. Remove electrical power supplied to the unit2-10.TRANSFORMER those components with low voltagepower switch to OFF and disconnect main circuit Figurebreaker, or unplug cord at wall receptacle Figure2-14.FILTER SWITCH REPLACEMENT1. Remove electrical power supplied to the unit FigurePROCEDURE, MOVE THE MAIN POWER SWITCH BOX OR UNPLUG SERVICE CORD FROM WALLTO AVOID PERSONAL INJURY OR PROPERTY DAMAGE, BEFORE STARTING THIS2-15.GAS CONTROL VALVE REPLACEMENT Continued FigureFigure Figure2-15.GAS CONTROL VALVE REPLACEMENT Continued power switch to OFF and disconnect main circuitFigure breaker, or unplug cord at wall receptacle2-16.BLOWER MOTOR REPLACEMENT Continued FigureFigure Figureunits will have power 2-16BLOWER MOTOR 2-17Wire Nos VoltageWattage Ohms coldCheckout Power Removed Heat Contactorunits will have power. Mercury2-18.HEATING CONTACTORS2-18.HEATING CONTACTORS ELECTRIC Continued Heat ContactorReplacement FigureFigure Replacement Primary Contactor 2-18.HEATING CONTACTORS ELECTRIC ContinuedFigure Figure2-19.SPEAKER ASSEMBLY power switch to OFF and disconnect main circuitFigure breaker, or unplug cord at wall receptaclepower switch to OFF and disconnect main circuit FigureCheckout breaker, or unplug cord at wall receptacleconnect the two electrical wires 2-20.HIGH TEMPERATURELIMIT CONTROL ELECTRIC Continued 1. Drain the shortening from the frypotterminals 2-20.HIGH TEMPERATURELIMIT CONTROL ELECTRIC Continued FigureMOTOR REMOVAL FigureFigure Figure2-21.FILTER PUMP AND MOTOR REMOVAL Continued 2-22.AUTOLIFTTRANSFORMER if applicable2-24.AUTOLIFT ACTUATOR MOTORREPLACEMENT power switch to OFF and disconnect main circuit2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENT if applicableFigure Figure10. Install new actuator in reverse order 2-24.AUTOLIFT ACTUATOR MOTOR REPLACEMENTif applicable FigureDrain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-31 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-32 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-33 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-34 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-35 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-36 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-37 Drain switch wired N/C Model OFE/OFG/OEA/OGA-341,3422-38 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-39 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-40 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-41 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-42 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-43 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-44 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-45 Drain switch wired N/O Model OFE/OFG/OEA/OGA-341,3422-46 3-3.WHEN ORDERING 3.6 WARRANTYSECTION 3. PARTS INFORMATION 3-1.INTRODUCTIONItem No Part NoDescription Qty. per WellGas Components Item NoPart No DescriptionGas Burner Assembly Item NoPart No DescriptionElectric Components Item NoPart No DescriptionItem No Part NoDescription Qty. per WellModel OFE/OFG/OEA/OGA-341,342 Qty. per Unit Item NoPart No DescriptionItem No Part NoDescription Qty. per UnitItem No Part NoDescription Qty. per UnitItem No DescriptionQty. per Well 60207Item No DescriptionQty. per Unit 33501Item No Part NoDescription Qty. per WellItem No Part NoDescription Qty. per WellItem No Part NoDescription Qty. per WellElectric Components Item NoPart No DescriptionOFG/OGA-341 OFG/OGA-342Item No DescriptionItem No Part NoDescription Qty. per WellOFG/OFE ELECTRO MECHANICAL PARTS LIST PART NUMBERDESCRIPTION Item No DescriptionItem No Description71899 341 DIRECT-CONNECTPARTS LIST Before March 1, 342 DIRECT-CONNECTPARTS LIST Before March 1,Part No DescriptionItem No Part NoDescription Part No DescriptionPart No DescriptionDescription Part No DescriptionModel OFE/OFG/OEA/OGA-341,342 3-26